Subscribe to Our Youtube Channel
Related Manuals for MacroAir Technologies Controller 4
Summary of Contents for MacroAir Technologies Controller 4
- Page 1 © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217...
-
Page 2: Table Of Contents
Fan Diameter Screen ........................22 Startup Sequence ........................23 Controller Dimensions ........................24 Warranty Information ......................... 25 Technical Support ..........................26 © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217... -
Page 3: Caution & Safety
All electrical troubleshooting and repair must be done by a qualified technician and meet all applicable codes. REFER TO FAN INSTALLATION MANUAL(S) FOR FURTHER MAINTENANCE INFORMATION. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 4: Fan Network Ordering
Note: If you did not order your fans for a network by default they will all have Node Address “2”, and you will be missing necessary materials. Contact technical support to modify your fans for networking. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 5: Network Wiring Requirements
Daisy Chain Networked MacroAir fans must be connected in one single line, referred to in this document as a “daisy chain”. The characteristics of a proper daisy chain are: one beginning (Controller 4) and one end (last fan). If the fans are not connected in one line/chain there will be a de-gradation of the communication signal and the network may not function as intended (fans in the network may not operate). -
Page 6: Network Wiring Configurations
Network Wiring Configurations Improper Wiring Configuration Proper Wiring Configuration One Beginning, One End © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217... -
Page 7: Temp/Humidity Sensor Location (Optional)
The optional sensor can be placed between two fans or between the controller and a fan as per the diagrams below. Refer to page 12 for more information. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 8: Network Excess Cable
If more than two feet of cable is needed for future relocation of the fan, run the cable up toward the ceiling and back down in a horseshoe shape. ALWAYS AVOID SHARP BENDS OF THE CABLE. Trim Excess Cable © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 9: Wiring Diagrams
Wiring Diagrams Typical T-Splice of CAT5 Wiring: CAT5 Pin-Out © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217... -
Page 10: Connection Method
2 inches 3. Strip approximately 1/2 inch off each color wire leaving the bare copper exposed. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... - Page 11 6. Double check that the 3 drain wire/bare wires are also crimped together as this is what continues the shielding throughout the network. The shielding and drain wire MUST be connected to Earth Ground at only one point of the cable run. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com...
- Page 12 9. Make sure to tape or zip tie all 3 CAT5 lines to the structure to support the 3 way splice and provide strain relief. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com...
-
Page 13: Temp/Humidity Sensor Installation (Optional)
Use the bean crimps supplied by Macro Air to wire the lead into the network. Please refer to network wiring diagram on the following page. Please refer to the wiring diagram below: © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 14: Connect Fans To Network
4. Review safety and caution information in the fan installation manual(s) and apply power to all of the fans. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 15: Screen Setup
The blade size is set via the “Settings” (pg 19). Once the size is programmed into every AVD3-450, 550 and 780 on the network, the fans can be operated normally. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 16: Screen Flow
Setpoint - Pg 17 Fan Select - Pg 18 Fan Settings - Pg 19 Fan Address - Pg 20 Mkey - Pg 21 © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217... -
Page 17: Controller Home Screen
Temperature mode indicates that the fan will turn on and off according to the temperature set point. Humidity mode indicates that the fan will turn on and off according to the humidity set point © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 18: Setpoint
Change Units: Changes the Temperature Reading and Set Point between Fahrenheit and Celsius Left Arrow: Navigates to the Home Screen Right Arrow: Navigates to the Fan Select screen © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 19: Fan Select Screen
Setpoint page. * If fans are connected, but not displayed on the Fan Select screen, check your CAT5 connections. Call technical support if you require further assistance. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 20: Fan Settings Screen
Heatsink Temp: Displays the temperature of the heatsink FW: Displays the firmware version number of the AirBrain Left Arrow: Takes you to Fan Select Right Arrow: Takes you to address page © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 21: Address Screen
Reset Drive: Resets the AirBrain. Address changes do not take effect until the drive is reset Left arrow: Takes you to Fan Settings Right Arrow: Takes you to Mkey © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 22: Mkey
After the 4 digits are typed in the keypad will automatically take you to the Calibrate screen Left Arrow: Takes you to the Address page © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 23: Fan Diameter Screen
Up/Down Arrow: Adjust the diameter up and down. For AVD3-450 fans, adjust the diameter past 24 to access 3-blade fan settings Left Arrow: Takes you to the Home Screen Right Arrow: Takes you to the Startup Sequence page © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 24: Startup Sequence
The startup sequence page allows you to automatically detect the blade size on AVD 550, 780, and AVD3-450 fans without manually inputting the diameter on the Fan Diameter page. Press “3-Blade” for AVD3-450 fans and “6-blade” for 550/780 fans. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com... -
Page 25: Controller Dimensions
Controller Dimensions LCD Screen Enclosure © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217... -
Page 26: Warranty Information
Warranty Info MacroAir 3-Year Controller Limited Warranty MacroAir Technologies, Inc. Warrantor: The warrantor for the limited warranties set forth herein is MacroAir Technologies Inc. (“MacroAir”). Limited Warranty: This limited warranty (this “Warranty”) applies only to the original End-User (the “End-User”) of any MacroAir Technologies’ Three or Six Blade fan Controllers, Network Controllers or AIRLYNK Building Management System interfaces hereafter referred to as the “Product”... -
Page 27: Technical Support
Technical Support For installation assistance, application questions, technical support & any other inquiries, please contact our Technical Support team at (866) 668-3247. © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217... - Page 28 © 2017 MacroAir Technologies Toll Free: 866 668 3247 Fax: 909 890 2313 w w w.macroairfans.com Rev. Date 032217...
Need help?
Do you have a question about the Controller 4 and is the answer not in the manual?
Questions and answers