Mineral pool care system for pools up to 25,000 gallons (21 pages)
Summary of Contents for Pool Frog XL PRO
Page 1
Softer because it reduces chlorine use up to 50%* Easier with pre-filled pacs for no mess, no guess and no stress POOL FROG XL Pro comes with the POOL FROG Mineral Reservoir Patented Mineral Disinfectant ® Customer Service 800-222-0169 frogproducts.com...
TABLE OF CONTENTS POOL FROG XL Pro Introduction Notes and Safety Information Safety Labels on Cyclers Installation Tips to Ensure Proper Performance In-Line Installation Step 1: Preparing the Pool Step 2: Putting the System to Work Step 3: Setting the Cyclers Control Dials...
POOL FROG Mineral System consists of the FROG minerals silver chloride and carbonate used in conjunction with 0.5 ppm chlorine. The POOL FROG Mineral Reservoir must be used in conjunction with the POOL FROG Pac (EPA Reg. No.: 53735-2), an EPA registered chlorine pool product or a chlorine delivery device.
Notes and Safety Information General Notes These instructions contain information for the safe and proper These instructions do not provide for every possible contingency operation of these Cyclers. Observe the following principles: that might be encountered in connection with installation, opera- •...
Use only POOL FROG Pacs, POOL FROG Mineral Reservoir, and FROG BAM in the POOL FROG XL Pro Cyclers. Never use bulk chemicals. a To prevent the build up of gas pressure in the POOL FROG XL Pro Cyclers, be sure the pool return line valves are open –...
The best option is to have two lines. One line with pump, filter, heater and per day on high speed, you must POOL FROG XL Pro Cyclers and a second line with a separate pump for the bleed the air while the pump is on by in-floor cleaning system (filter optional).
(or between heater using POOL FROG Pac as chemical MATERIALS NEEDED and pool if applicable). Never install POOL FROG XL Pro corrosion may lead to pipe failure. Cyclers before the heater or damage to the heater could Primer and PVC occur.
200 – 400 pool if required. Total Dissolved Solids: <1500 • Never use fast dissolving chlorine tablets, liquid Stabilizer: 20 – 80 ppm bleach, or calcium hypochlorite in the POOL FROG Free Chlorine: 0.5 – 1.0 ppm XL Pro Cyclers.
Install a POOL FROG POOL FROG FROG Mineral Mineral Reservoir into the Insert FROG BAM into Reservoir POOL FROG XL Pro Mineral POOL FROG Mineral Cycler. (See page 12 for Reservoir in POOL directions.) FROG XL Pro Mineral Cycler. (See page 13 for IMPORTANT: directions.)
1a. Set POOL FROG XL Pro Mineral Cycler control dial to Setting 10. No further adjustments are needed. 1b. Set POOL FROG XL Pro Chlorine Cycler control dial by matching up the parameters of your pool on the chart below. THIS IS A STARTING POINT ONLY and may need to be adjusted to fit your individual pool needs.
To prevent the build up of gas pressure in the POOL FROG DANGER XL Pro Cyclers, be sure the pool return line valves are open –except when opening or servicing the unit. • Never add any other types of chlorine, pH adjusters, shock treatments or algaecides through the skimmer.
50%*. Simply use with at least 0.5 ppm of an EPA registered Mineral Cycler by hitting the source of chlorine such as the POOL FROG Bac Pac (EPA Reg. No. 53735-2) or a chlorine delivery device. Using the POOL FROG Mineral System...
Turn pump on for 90 minutes Never use fast dissolving chlorine tablets, liquid bleach, allowing FROG BAM to or calcium hypochlorite in the POOL FROG XL Pro Cyclers. circulate through pool. Important: If storing FROG BAM prior to use, always keep in a cool, dry place away from children and pets.
Finished cut ends towers towers Turn off pump. Turn control dial on POOL FROG XL Pro Chlorine Cycler to 0. Remove cap from POOL FROG XL Pro Chlorine Cycler and stand back to let any chlorine C. Squeeze the handles D.
Mineral Cycler Chlorine Cycler WARNING Avoid sparks, smoking, or any open flame near Unscrew knob in the back POOL FROG XL PRO Cyclers or chemicals. of both POOL FROG XL Pro Cyclers. Allow all water to drain. Replace both caps and...
4. Make sure pump run time the POOL FROG will be low and the skimmer of the POOL FROG Pac and is at least 6 hours on high will be taking in air. Contact Pac? it is installed properly.
1 or 3 part SILICONE unavailable, LUB RICANT see your dealer INCLUDED WITH POOL FROG XL Pro CYCLERS REPLACEMENT PARTS FOR POOL FROG XL Pro CYCLERS REF. # DESCRIPTION QTY. INCLUDED REF. # PART NO. DESCRIPTION 1, 2, 3 Caps w/O-Rings 1 &...
POOL FROG XL Pro Cyclers Maintenance Replacing the Control Dial O-Rings Push control dial Using a needle nose pliers, completely into the find the snap ring tail housing and turn the dial located at approximately to setting 2. the five o’clock position under the control dial.
Continued..POOL FROG XL Pro Cyclers Maintenance Replacing Cap O-Ring Replacing Knobs Remove old O-ring. To replace, simply unscrew old knob and replace with the new one. Top half of groove Place new O-ring in bottom half of groove. Place your thumbs on each...
To extend your warranty to 10 years, go to frogproducts.com/reg. 5. Misuse or failure to use the proper POOL FROG Mineral Reservoir and POOL FROG Pac may cause damage to equipment or personal 2.
Need help?
Do you have a question about the XL PRO and is the answer not in the manual?
Questions and answers