BIOS chapter All company names, brand names, and product names referred to in this manual are registered or unregistered trademarks of their respective holders and are, as such, protected by national and international law. page 6 ADL Embedded Solutions ADLE3800HDC...
Via our website at www.adl-usa.com/support or www.adl-europe.com/support 1.3 Warranty This product is warranted to be free of defects in workmanship and material. ADL Embedded Solutions' sole obligation under this warranty is to provide replacement parts or repair services at no charge, except shipping cost.
Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense. page 8 ADL Embedded Solutions ADLE3800HDC...
The frontpanel provides standard interfaces, such as a DVI/HDMI/DisplayPort connector, 3 Gigabit LAN interfaces and 4 USB2.0 interfaces. The ADLE3800HDC also provides internal interfaces, such as an 30pin I-PEX connector, which makes DVI/HDMI/DP signals and a USB3.0 interface available, a SATA connector and two M.2(B) sockets, which make PCI Express (1 x PCIe x1) and SATA signals available.
BIOS AMI® Aptio V 16V - 36V input voltage range Power Supply Over- and undervoltage protection S-UPS connection Reverse voltage protection not galvanically isolated Format 102 mm x 147 mm page 10 ADL Embedded Solutions ADLE3800HDC...
3.2 SUPS Optionally the ADLE3800HDC can be equipped with a plug-in SUPS, which can keep the board alive over a short period of time in case of power failure or voltage fluctuation. The exact amount of time is hard to predict as it also depends on factors such as the SUPS' capacitors and the boards' power consumption etc.
Chapter: Connectors 4 Connectors This section describes all the connectors found on the ADLE3800HDC. Please consider the requirements on the cabling! OTICE For most interfaces, the cables must meet certain requirements. For instance, USB 2.0 requires twisted and shielded cables to reliably maintain full speed data rates.
"DVI/HDMI/DisplayPort and USB3.0" p. 31 P1005 "SATA Interface" p. 33 P1006 "S-UPS" p. 18 P1100/2/4 "LAN" p. 23 P1101/3 "USB" p. 22 P1105 "DVI / HDMI / VGA" p. 20 P1106 "Mainboard Power Supply" p. 15 page 14 ADL Embedded Solutions ADLE3800HDC...
4.2 Power Supply 4.2.1 Mainboard Power Supply The power supply of the ADLE3800HDC is realized via a 2x2pin connector (P20THR-1787014). The main 24V power lines are assigned to pin 3. If a UPS is present you need to have a possibility to shut down the board in a regular way without activating the UPS, thereby preventing premature aging of UPS components.
Power Supply 4.2.2 Power Supply for Peripherals (I-PEX) The ADLE3800HDC has a 2x6pin connector, which provides the power supply for displays, which are connected via I-PEX. Maximum current is 6 amperes for VCC combined (2A per contact), and also 6 amperes for 12V (2A per contact).
Chapter: Connectors 4.2.3 Power Supply for Peripherals (SATA) The ADLE3800HDC has a 2x4pin connector, which provides the power supply for devices, which are connected via SATA. Maximum current is 2 amperes for VCC combined (2A per contact), and also 2 amperes for 12V and 3,3V (2A per contact).
Power Supply 4.2.4 S-UPS A S-UPS module can be connected to the ADLE3800HDC via a 2x5pin connector. The S-UPS is able to maintain the power supply for the ADLE3800HDC for a few seconds, depending on the capacity and power consumption.
ADLE3800HDC. 4.3.1 DVI / HDMI / VGA The ADLE3800HDC is connected to an external display via a DVI-I connector, which supports analog and digital displays. A HDMI display can be connected. Description...
Page 21
Front Panel Connectors Chapter: Connectors Name Description TMDS CLK DVI clock TMDS CLK# DVI clock C_RED VGA red C_GREEN VGA green C_BLUE VGA blue C_HSYNC VGA horizontal synchronization ground ADL Embedded Solutions ADLE3800HDC page 21...
In ACPI state S5 via USB connected devices will not be energized. Description Mating Connectors Manufacturer Foxconn UB11121C-8D1-4F (standard connector) Pinout USB connector for channel X: Name Description 5 volt for USBX USBX# minus channel USBX USBX plus channel USBX ground page 22 ADL Embedded Solutions ADLE3800HDC...
LAN channel 0 minus LAN-1 LAN channel 1 plus LAN-2 LAN channel 2 plus LAN-2# LAN channel 2 minus LAN-1# LAN channel 1 minus LAN-3 LAN channel 3 plus LAN-3# LAN channel 3 minus ADL Embedded Solutions ADLE3800HDC page 23...
1 + DQS1 RESET# Reset ground ground data 10 DQ10 DQ14 data 14 data 11 DQ11 DQ15 data 15 ground ground data 16 DQ16 DQ20 data 20 data 17 DQ17 DQ21 data 21 page 24 ADL Embedded Solutions ADLE3800HDC...
Page 25
DQ38 data 38 data 34 DQ34 DQ39 data 39 data 35 DQ35 ground ground DQ44 data 44 data 40 DQ40 DQ45 data 45 data 41 DQ41 ground ground DQS5# data strobe 5 - ADL Embedded Solutions ADLE3800HDC page 25...
Page 26
58 DQ58 DQ62 data 62 data 59 DQ59 DQ63 data 63 ground ground SPD address 0 EVENT# Event 3.3 volt supply 3.3V SMBus data SPD address 1 SMBus clock termination current termination current page 26 ADL Embedded Solutions ADLE3800HDC...
Chapter: Connectors 4.4.2 M.2 2280 (Keying B) The ADLE3800HDC is equipped with an M.2 socket, in which M.2-2280 cards (keying B) can be inserted. The socket leads PCIe signals (1x PCIe x1) through. Adaptor cards with standard PCIe sockets are available, please contact your distributor.
4.4.3 M.2 2242 (Keying B) The ADLE3800HDC is equipped with a further M.2 socket, in which M.2-2242 cards (keying B) can be inserted. The socket leads SATA signals (up to 6 Gb/s) through, which enables the use of an SSD card.
Chapter: Connectors 4.4.4 DVI/HDMI/DisplayPort and USB3.0 The ADLE3800HDC provides a second DVI interface which is realized as a 30pin flat cable header (I- PEX Cabline-VS 20455-030E-12). Analog VGA is not available on this connector. However, an HDMI device or DisplayPort device can be connected.
Page 32
Super Speed receiver - SSTX Super Speed receiver + USB# USB - USB + SSRX# Super Speed transmitter - SSRX Super Speed transmitter 3.3V 3.3V supply 3.3V 3.3V supply 5V supply 5V supply 5V supply page 32 ADL Embedded Solutions ADLE3800HDC...
Chapter: Connectors 4.4.5 SATA Interface The ADLE3800HDC provides one SATA interfaces which allows transfer rates of up to 3 Gb/s. The interface is made available via a standard SATA connector and supports RAID 0/1/5/10. The required settings are made in the BIOS setup.
They do not represent the recommended settings or the default settings. Determination of the appropriate settings is dependent upon the particular application scenario in which the board is used. page 34 ADL Embedded Solutions ADLE3800HDC...
Options: none BayTrail SoC Options: none Total Memory Options: none System Date Options: The system date can be adjusted here. System Time Options: The system time can be adjusted here. ADL Embedded Solutions ADLE3800HDC page 35...
Sub menu: see "Network Stack" (page 46) Power Controller Options Sub menu: see "Power Controller Options" (page 47) CSM Configuration Sub menu: see "CSM Configuration" (page 48) NVMe Configuration Sub menu: see "Advanced-Menü-NVMe Configuration" (page 49) page 36 ADL Embedded Solutions ADLE3800HDC...
Page 37
Security Configuration Sub menu: see "Security Configuration" (page 52) Intel(R) Gigabit Network Connection Sub menu: see "Intel(R) I210 Gigabit Network Connection" (page 53) Driver Health Sub menu: see "Driver Health" (page 55) ADL Embedded Solutions ADLE3800HDC page 37...
└─────────────────────────────────────────────────────────────────┴────────────────────────────────┘ Version 2.17.1249. Copyright (C) 2016 American Megatrends, Inc. CPU C state Report Options: Disabled / Enabled Max CPU C-state Options: C7 / C6 / C1 S0ix Options: Disabled / Enabled ADL Embedded Solutions ADLE3800HDC page 43...
Storage Options: Do not launch / UEFI only / Legacy only Video Options: Do not launch / UEFI only / Legacy only Other PCI devices Options: UEFI only / Legacy only page 48 ADL Embedded Solutions ADLE3800HDC...
Options: none Chip Type Options: none PCI Device ID Options: none PCI Address Options: none Link Status Options: none MAC Address Options: none Virtual MAC Address Options: none ADL Embedded Solutions ADLE3800HDC page 53...
Page 54
Version 2.17.1249. Copyright (C) 2016 American Megatrends, Inc. Link Speed Options: Auto Negotiated / 10Mbps Half / 10Mbps full / 100Mbps Half / 100Mbps Full Wake On LAN Options: Enabled / Disabled page 54 ADL Embedded Solutions ADLE3800HDC...
│ │ │ │ │ └─────────────────────────────────────────────────────────────────┴────────────────────────────────┘ Version 2.17.1249. Copyright (C) 2016 American Megatrends, Inc. North Bridge Sub menu: see "North Bridge" (page 58) South Bridge Sub menu: see "South Bridge" (page 62) ADL Embedded Solutions ADLE3800HDC page 57...
Restore AC Power Loss Options: Power Off / Power On / Last State Onboard Gigabit LAN X Options: Enabled / Disabled M.2-PCIe Configuration Pins Options: none M.2-SATA Configuration Pins Options: none page 62 ADL Embedded Solutions ADLE3800HDC...
Page 64
│ └─────────────────────────────────────────────────────────────────┴────────────────────────────────┘ Version 2.17.1249. Copyright (C) 2016 American Megatrends, Inc. USB Mode Options: EHCI / XHCI USB Per Port Control Options: Enabled / Disabled USB Port x Options: Disabled / Enabled page 64 ADL Embedded Solutions ADLE3800HDC...
Page 65
│ │ │ │ │ │ │ │ │ │ │ │ │ │ │ │ └─────────────────────────────────────────────────────────────────┴────────────────────────────────┘ Version 2.17.1249. Copyright (C) 2016 American Megatrends, Inc. PCIe Port x is assigned to Options: none ADL Embedded Solutions ADLE3800HDC page 65...
Legacy / UEFI / DUAL Fixed Boot Order Priorities Options: Review or change the sequence of available boot devices Advanced Fixed Boot Order Parameters Sub menu: see "Advanced Fixed Boot Order Parameters" (page 70) ADL Embedded Solutions ADLE3800HDC page 69...
BIOS file which was issued for the exact board and exact board revision that you wish to update. If you try to update the BIOS using the wrong file the board will not start up again. page 72 ADL Embedded Solutions ADLE3800HDC...
Chapter: Mechanical Drawings 6 Mechanical Drawings All dimensions are in mil (1 mil = 0,0254 mm) OTICE 6.1 PCB: Mounting Holes A true dimensioned drawing can be found in the PC/104 specification. 1102 1300 2750 3858 ADL Embedded Solutions ADLE3800HDC page 73...
The figure below includes all hole spacing for each heat spreader available and can be used to aid in mating the heat spreader to a bulkhead or chassis. Dimensions are in inch (1 in = 2.54cm; 1 mil = 0.0254 mm) ADL Embedded Solutions ADLE3800HDC page 77...
5 up to 9Hz, 3.5mm amplitude 9 up to 500Hz, 10m/s , for packaged boards Shock and vibration figures pertain to the motherboard alone and do not OTICE include additional components such as heat sinks, memory modules, cables etc. page 78 ADL Embedded Solutions ADLE3800HDC...
100°C. Permanent overheating may destroy the board! In case the temperature exceeds 100°C the environmental temperature must be reduced. Under certain circumstances sufficient air circulation must be provided. ADL Embedded Solutions ADLE3800HDC page 79...
(POST code card). The meaning of these codes is described in the document "Aptio™ 4.x Status Codes" by American Megatrends®, which can be downloaded from their website http://www.ami.com. The following additional OEM POST codes are generated: Description Code BIOS-API started PCA9535 started PWRCTRL-Firmware started ADL Embedded Solutions ADLE3800HDC page 81...
The exclusivity is not given and not possible on the PCI side. Function Adress IRQ0 Timer IRQ1 PS/2 Keyboard IRQ2 (8) IRQ3 COM2 IRQ4 COM1 IRQ5 IRQ6 IRQ7 IRQ8 IRQ9 IRQ10 IRQ11 IRQ12 IRQ13 IRQ14 page 82 ADL Embedded Solutions ADLE3800HDC...