Gas Conversion - Anvil CBF0300 Installation Operation And Care

SPECIFIC INSTRUCTIONS FLAT TOP GRILLERS
1. Turn the unit on and preheat on 'HIGH' position before
attempting to grill. Adjust the valve to obtain the desired heat.
2. The fat tray is located at the bottom of the unit, and is easily
removed from the front of the unit. The fat tray catches the
grease and should be emptied on a regular basis.
3. Air for combustion enters from the bottom of the unit. Do not
obstruct this area.
SPECIFIC INSTRUCTIONS GAS RADIANT CHARBROILER
1. Turn the valves on and preheat the unit on 'HIGH' before
attempting to grill.
2. It is recommended that the grate be set at the full tilt position to
start with. This position allows the grease to run down the grate
into the fat tray reducing flare ups.
3. Check water pans regularly and add a sufficient amount of water.
Hot water vapors rising from the water pan and through the
combustion chamber help to reduce flare ups.
4. The grate can be tilted by using the bracket located at the rear of
the unit. It is possible using this arrangement to have a high heat
or searing section while having a low heat finishing or holding
section. The gas valves can be set accordingly.
5. All radiant charbroilers can be readily converted to lava rock
versions by using the conversion kit as described in the
description of models.The radiant cover over the burner must be
removed and replaced with the cast iron grate and lava rocks.

GAS CONVERSION:

Conversion from LPG to Natural Gas or vice versa may only be
performed by the factory or its authorized service agent. In the case
of troubleshooting, ensure that the correct orifice sizes of the spuds
have been provided.
LP GAS ORIFICE #56
NOTE: THE ORIFICE SIZE IS MARKED ON THE SPUD
3
GAS RADIANT CHARBROILER
MODEL CODE: CBL0600
Part
Stock Code
No.
1 7-RAD-GRID
2
3
4 7-BURNER-CBF-1
5
6 7-MAN-GGR0900
7
8 7-SP-GGR0400
9
10
11 7-JET-GGR0400
12 7-ELB-GGR0400
13 7-VAL-FTG0300
14 7-IS-GGR0400
15
16 4-BEZ-COA3004
17 3-KNOB-LEAVER
18 4-BEZ-BADGE
19 4-DL-L-APEX
20 7-FOOT-FTA7016
21
22 7-TC-GGR0400
23
24
25
26
27
28
GAS RADIANT CHARBROILER
MODEL CODE :GGR0900 R01
Description
GRID
SPLASH GUARD ASSEMBLY
FIRE WALL
BURNER
LEFT SIDE PANEL
MANIFOLD
CROSS BRACKET TOP AND BOTTOM
SPARK PLUG WITH WIRE
DRIP TRAY
FRONT FIRE WALL
JET
ELBOW
CONTROL VALVE
IGNITION SWITCH
FRONT PANEL
GAS CONTROL BEZEL
LEVER KNOB
BADGE BEZEL
DOMED LABEL APEX
ADJUSTABLE FOOT
RIGHT SIDE PANEL
PREMIER GAS RANGE THERMOCOUPLE
BURNER SURPORT BRACKET
BURNER SURPORT BRACE
GRATE ADJUSTMENT SUPPORT
RADIANT COVER
CROSS PIECE RADIANT COVER
BACK PANEL
20