SERVICE MANUAL POWERED SUBWOOFER MB082 2003 SX-DW303 Area Suffix J ----------------- U.S.A. TABLE OF CONTENTS PRECAUTION............... . . 1-3 SPECIFIC SERVICE INSTRUCTIONS .
Page 2
www.freeservicemanuals.info Absolutly Free manuals SPECIFICATION Type Powered subwoofer Bass-reflex type, (magnetically shielded type) Speaker unit 16.0 cm (6 5/16 in.) cone ( × 1) Frequency range 30 Hz to 200 Hz Input impedance 50 kΩ (LOW-LEVEL) 470 Ω (HIGH-LEVEL) Input terminals INPUT 1 (LOW-LEVEL) INPUT 2 (HIGH-LEVEL) Power requirements...
www.freeservicemanuals.info Absolutly Free manuals SECTION 1 PRECAUTION Safety Precautions (1) This design of this product contains special hardware and voltmeter. many circuits and components specially for safety purpos- Move the resistor connection to each exposed metal es. For continued protection, no changes should be made part, particularly any exposed metal part having a return to the original design unless authorized in writing by the path to the chassis, and measure the AC voltage across...
Page 4
www.freeservicemanuals.info Absolutly Free manuals Importance administering point on the safety Power switch board (Forward side) Caution: For continued protection against risk of fire, replace only with same type 3A/250V for F9001. This symbol specifies type of fast operating fuse. 1-4 (No.MB082)
www.freeservicemanuals.info Absolutly Free manuals SECTION 2 SPECIFIC SERVICE INSTRUCTIONS This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS. (No.MB082)1-5...
www.freeservicemanuals.info Absolutly Free manuals SECTION 3 DISASSEMBLY Removing the amplifier assembly (See Figs.1 and 2) (1) Remove the eleven screws A attaching the amplifier as- Service cabinet sembly. (See Fig.1.) (2) Remove the amplifier assembly from the service cabinet. (See Fig.2.) (3) From the back side of the amplifier assembly, disconnect the wire from the wire connector.
Page 7
www.freeservicemanuals.info Absolutly Free manuals Removing the power cord Bracket (CORD) (See Figs.4 and 5) • Prior to performing the following procedures, remove the back panel. (1) Remove the two screw C attaching the bracket (CORD). (See Fig.4.) (2) Take out the bracket (CORD) toward this side. (3) Disconnect the power cord from the connector CN901.
Page 8
www.freeservicemanuals.info Absolutly Free manuals Removing the stand (See Figs.7 and 8) (1) Remove the foot spacers. (See Fig.7.) (2) Remove the eight screws H attaching the stand. (See Fig.8.) (3) Remove the stand toward this side. Foot spacer Stand Stand Fig.8 Foot spacers Fig.7...
Page 12
www.freeservicemanuals.info Absolutly Free manuals VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MB082) Printed in Japan...
Absolutly Free manuals PARTS LIST [ SX-DW303 ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix J -------------- Northern America - Contents - 3- 2 Exploded view of general assembly and parts list (Block No.M1) 3- 4 Electrical parts list (Block No.01)
Page 14
www.freeservicemanuals.info Absolutly Free manuals Exploded view of general assmbly and parts list...
Page 15
www.freeservicemanuals.info Absolutly Free manuals General assembly Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local LV21341-002A SHIELD LV10709-002A COVER LV30225-044A SPACER (x4) LV30225-079A SPACER LV30225-0E4A SPACER LV30225-025A SPACER LV30225-0G8A SPACER QYSBSG3016E TAP SCREW M3 x 16mm(x2) QYSBSF3008Z SCREW 3mm x 8mm(x4) LV43179-002A BKT(SW)
www.freeservicemanuals.info Absolutly Free manuals Electrical parts list Symbol No. Part No. Part Name Description Local Main board Block No. [0][1][0][0] D5006 1SS133-T2 DIODE Symbol No. Part No. Part Name Description Local D5007 MTZJ16B-T2 Z DIODE D5008 M1FL20U-X FR DIODE D5009 MTZJ18B-T2 Z DIODE Dual Operational...
Page 17
www.freeservicemanuals.info Absolutly Free manuals Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C1027 NCB31HK-103X C CAPACITOR 0.01uF 50V K C9503 NCB31HK-471X C CAPACITOR 470pF 50V K C1028 QETN1HM-475Z E CAPACITOR 4.7uF 50V M C9504 QETN1VM-107Z E CAPACITOR...
Page 18
www.freeservicemanuals.info Absolutly Free manuals Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R5003 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R5729 NRSA63J-683X MG RESISTOR 68kΩ 1/16W J R5004 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R5730 NRSA63J-104X MG RESISTOR...
Page 19
www.freeservicemanuals.info Absolutly Free manuals Symbol No. Part No. Part Name Description Local CN505 QGB2016K1-11 CONNECTOR B-B (1-11) CN901 QGA7901F2-02 CONNECTOR W-B (1-2) CN951 QGB2510J1-10 CONNECTOR B-B (1-10) CN952 QGB2016K1-05 CONNECTOR B-B (1-5) EP951 QNZ0136-001Z EARTH PLATE EP952 QNZ0136-001Z EARTH PLATE HS951 LV33802-001A HEAT SINK1...
Page 20
www.freeservicemanuals.info Absolutly Free manuals Packing materials and accessories parts list Block No. A1,A2,A3,A4...
Page 21
www.freeservicemanuals.info Absolutly Free manuals Packing and accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local LVT0951-006A INST BOOK ENG FRE BT-51018-3 WARRANTY CARD YU20333 SAFETY INST. QAM0199-001 PIN CABLE LV43196-003B CAUTION SHEET SXDW303K-SPBOX SPEAKER BOX QPA02503503P POLY BAG 25cm x 35cm LV31492-047A CARTON...
Absolutly Free manuals SCHEMATIC DIAGRAMS POWERED SUBWOOFER SX-DW303 CD-ROM No.SML200311 Area suffix J ----------------------------- U.S.A. Contents Block diagram Standard schematic diagram 2-5 to 7 Printed circuit boards No.MB082SCH COPYRIGHT 2003 VICTOR COMPANY OF JAPAN, LTD. 2003/11...
Page 23
www.freeservicemanuals.info Absolutly Free manuals In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the "...
Page 24
www.freeservicemanuals.info Absolutly Free manuals < M E M O >...
www.freeservicemanuals.info Absolutly Free manuals VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MB082SCH)