Page 1
MOONEY M20K SERVICE AND MAINTENANCE MANUAL MOONEY INTERNATIONAL CORPORATION ISSUED: SEPTEMBER 1997 P/N: MAN134 REVISION B: MAY 2014 Copyright 2014 - - All Rights Reserved MOONEY INTERNATIONAL CORPORATION 165 Al Mooney Road, Kerrville, Texas 78028 tel: 830-896-6000...
Page 3
SERVICE AND MAINTENANCE MANUAL LOG OF REVISIONS The Log of Revisions pages are updated by Mooney International Corporation each time revisions are issued. The Log of Revisions contains a list of all revisions made to the service and maintenance manual since its original issue.
Page 4
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
Page 15
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 4 AIRWORTHINESS LIMITATIONS...
Page 16
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 4 AIRWORTHINESS LIMITATIONS LIST OF EFFECTIVE PAGES CHAPTER SECTION SUBJECT PAGE DATE 4--Effectivity ....... . .
Page 18
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
Page 19
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 4 AIRWORTHINESS LIMITATIONS TABLE OF CONTENTS CHAPTER SECTION SUBJECT PAGE 4--00--00 ......
Page 20
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK Page 1997 Date Rev Date...
Page 21
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL 4- -00- -00 - - AIRWORTHINESS LIMITATIONS - - MODEL M20K (Normal Category) S/N’s 25- -2013 THROUGH 25- -2032 The Airworthiness Limitations Section is FAA approved and specifies maintenance required under 14 CFR ww 43.16 and 91.403 unless an alternative program has been FAA approved.
Page 22
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
Page 23
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION CHAPTER 5 TIME LIMITS, MAINTENANCE CHECKS...
Page 24
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
Page 25
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 5 TIME LIMITS/MAINTENANCE CHECKS LIST OF EFFECTIVE PAGES CHAPTER SECTION SUBJECT PAGE DATE 5--Effectivity ......
Page 26
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 5 TIME LIMITS/MAINTENANCE CHECKS TABLE OF CONTENTS CHAPTER SECTION SUBJECT PAGE 5--00--00 ......
Page 28
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL INTENTIONALLY LEFT BLANK...
SERVICE AND MAINTENANCE MANUAL 5-00-00 has an overvoltage protective relay and an overvoltage - GENERAL annunciator light. Circuit breakers or circuit breaker switches protect the electrical wiring and equipment AIRCRAFT DESCRIPTION. The M20K series of from overloads. Standard electrical equipment...
Page 30
ON CONDITION Powerplant Engine Refer to Engine Manufacturer’s Continued Airworthiness Data for specific Time Limits. Mooney has no special re- quirements over those found in the Manufacturer’s Data. Propeller Refer to Propeller Manufacturer’s Continued Airworthiness Data for specific Time Limits. Mooney has no special re- quirements over those found in the Manufacturer’s Data.
Page 31
MOONEY INTERNATIONAL CORPORATION M20K SERVICE AND MAINTENANCE MANUAL 5- -20- -00 - - SCHEDULED INSPECTIONS ducts, drain and vent lines shall be torqued to 15 inch pounds. Inspection Intervals. Perform a 25, 50, or 100--hour in- 4. Pipe Threads -- Tightening and torque procedures.
Page 32
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION BOLT - NUT TORQUE VALUES ————————————————————————————————————————————— METRIC BOLTS, SCREWS & NUTS Failure of threaded fasteners due to over-tightening can occur by bolt shank fracture or by stripping of the nut and/or bolts thread. A bolt or screw assembled with a nut of the appropriate class is intended to provide an assembly capable of being tightened to the bolt proof load without thread stripping occurring.
Page 33
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL METRIC TORQUE TABLES (CONTINUED) --- NOMINAL PROPERTY DIAMETER CLASS (Fine Thread) --------------------------------------------------------------------------------------------------------------------------------------------------------- ---------- TORQUE Ma 10.9 12.9 Nm/ft.lb. Nm/ft.lb. Nm/ft.lb. ————————————————————————————-————-———————————— M8 x 1 27/19 38/28 45/33 M10 x 1.25 52/38 73/53 88/64 M12 x 1.25...
Page 34
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION METRIC --- TORQUE TABLES (CONTINUED) NOMINAL PROPERTY DIAMETER CLASS (Fine Thread) TORQUE Ma 10.9 12.9 Nm/ft.lb. Nm/ft.lb. Nm/ft.lb. ————————————————————————-————————————————————— M8 x 1 25/18 35/25 42/30 M10 x 1.25 49/36 68/50 82/60 M12 x 1.25...
Balance Record, TCM Service Information, Aircraft Radio Station License applicable), Airworthiness 1. Engine. Directives, and Mooney serivce documents. A. Drain engine oil sump. 5-20-03 - ENGINE FUNCTIONAL CHECK B. Remove and clean suction oil strainer; reinstall strainer and plug. Safety wire strainer plug.
Page 37
(security) of cable housing swage at head this interval when applicable. Comply with applicable tube and security of attachment. FAA Directives, AD Notes, and applicable Mooney and Vendor mandatory Service Bulletins and Instructions. NOTE Check for aircraft conformance to FAA Specification Cablecraft control cables are lubricated for life of 2A3.
Page 38
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION INSPECTION: Inspect “Q-Tip” for stone nicks and scratches using the same procedure as on the complete blade. Inspect for evidence of the bend being deformed by assuring that the bend edge is 90 degrees.
Page 39
(interior panels require removal). installation. Reference Mooney Service Bulletin M20-208B or D. Inspect wings, flaps, and ailerons for corrosion, subsequent revisions. damage, loose or popped rivets, dents, scratches, cracks, condition of attaching points, lubrication, E. Inspect wing ribs and stringers for cracks and freedom of operation, free-play, travel, and balance evidence of damage or corrosion.
Page 40
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION H. Inspect wing interior for foreign material, 2. Visually Inspect for chafing on all moving parts. corrosion, and evidence of fuel leakage. 3. Manually operate speed brake doors and feel for smooth operation [vacuum units only].
Page 41
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL I. Check operation of annunciator light press-to-test N. Inspect battery & battery connection for proper switch. installation and cleanliness. 11. MISCELLANEOUS/OPTIONAL EQUIPMENT J. Check operation of ignition switch, and starter solenoid. A. Inspect any installed equipment not covered by previous paragraphs for proper operation, attachment K.
Page 42
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION ACCESS COVER ID, LUBRICATION & SERVICE GUIDE - FIGURE 5 - 4 NOTE Access covers rrveted in place during production need not be removed for routine inspections. 5-20-07 REV. 3 - 00...
Page 43
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL 6. (con’t.) Stabilizer Trim Jack Screw/Actuator . . Variable Downspring System . § . Tail Strobe Light Power Supply § . Empennage Attach Points. § . Stabilizer Trim Attach Point Elevator & Rudder controls: Control Tube Rod End Bearings Elevator &...
TCM Spec MHS-24(B ) or subsequent revision. Union Aircraft Engine Oil HD; For aircraft S/N 25-1000 & ON — Mooney Aircraft Gulfpride Aviation AD; Quaker State AD Aviation Corporation recommends using multiviscosity oil in these aircraft, both mineral & additive oil.
Page 46
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION BLANK 5-20-07...
Page 111
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 24 ELECTRICAL POWER...
Page 112
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION CHAPTER 24 ELECTRICAL POWER LIST OF EFFECTIVE PAGES CHAPTER PAGE DATE SECTION SUBJECT 24-Effectivity 1/2BLANK 3-00 24-Contents. 3/4BLANK 9-97 24-00-00 . 9-97 24-31-02 . 9-97 24-32-00 . 3-00 24-34-00 . 9-97 24-35-00 .
Page 113
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL CHAPTER 24 ELECTRICAL POWER TABLE OF CONTENTS CHAPTER . SUBJECT . PAGE SECTION SUBJECT 24-00-00 . General 24-30-00 D.C. Generation . 24-31-01 Alternator Charging System Maintenance . 24-31-02 Voltage Regulator Maintenance 24-32-00 Battery Maintenance .
Page 114
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION 24-00-00 NOTE - GENERAL It is recommended that the approved Auxiliary Power Cable be connected to the booster battery S/N 25-0001 thru 25-0999 and the plug inserted into the auxiliary power A 14 volt, 70 AMP alternator utilizing a transistorized receptacle, if equipped.
Page 115
(5) Lower engine hoist to allow engine to pivot replaced every 2000 hours of no load operation. downward just enough to permit alternator to be removed. Mooney Aircraft Corporation recommends the generator (6) Remove cooling air duct and any wiring form connections,...
Page 116
Adapters can be ordered A. Turn Master Switch - OFF. through Mooney Marketing or Service Centers. Refer to Figure 24-3 & -3A for location of adjustment screws. B. Remove tailcone access cover and battery box lid.
Page 117
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL Install annunciator connect At the L position the right magneto grounds. At the calibration transfer standard to annunciator panel and BOTH position both magnetos are HOT and the harness plug. Remove front plate and legend on new ignition system is on.
Page 118
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION 24-35-00 - LIGHTING CIRCUITS remain ON for approximately 2 minutes. The rocker switch is connected through the MASTER switch on 1. Navigation Lights. A circuit breaker switch on the these aircraft and interior lights will go out when the flight panel controls the navigation lights.
Page 119
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL (1) Low Boost Auxiliary fuel system adjustment (c) Connect a voltmeter to the aircraft bus. — S/N 25-0001 thru 25-0780: (d) Turn “MASTER” switch ON and assure that bus (a) Install a calibrated pressure gauge, tee into the voltage is at least 12 volts(25-0001 thru 25-0999);(24...
Page 120
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION A circuit breaker switch controls the pitot tube heater. CURRENT SENSOR - ADJUSTMENT 3. Hour Meter (Optional). Effective S/N 25-2000 thru 25-TBA The hour meter operates directly from the alternator A. Remove front cover from Annunciator.
Page 121
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL 24-39-00 - TROUBLE SHOOTING CHARTS 24-39-01 - ALTERNATOR TROUBLE SHOOTING TROUBLE PROBABLE CAUSE REMEDY Alternator over-charges battery; Regulator faulty. Check bus voltage with engine running. Observe aircraft ammeter. Ammeter battery uses excessive water.
Page 122
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION plug. Normal indication is a very low resistance. If reading indicates no, or poor continuity, repair or replace wiring from regulator to alternator. +25-0001 thru 25-0999; field terminal for 25-1000 thru 25-1230.
Page 123
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL 24-39-03 - BATTERY TROUBLE SHOOTING TROUBLE PROBABLE CAUSE REMEDY Discharged battery. Battery worn out. Replace battery. Improper charging rate setting. Reset charging rate. Excessive discharging. Turn off some equipment when alternator is not charging. Decrease starter usage by using external power whenever possible.
Page 124
- ANNUNCIATOR TROUBLE SHOOTING (S/N 25-0001 thru 25-1224) The following is a brief failure/cause analysis which pertains to the annunciator (IAI P/N 500D0061) on the Mooney M20K. Each cause is listed in probable order. All designator references are made from IAI drawings 710D0125A, 900D0134 and 900D0135.
Page 125
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL ( ANNUNCIATOR TROUBLE SHOOTING (S/N 25-0001 thru 25-1224) - con’t.) 8. The “left low fuel” channel functions properly but the lamp is always dim. CR22 (Assy A2) open 9. The “left low fuel” lamp flickers on and off.
Page 126
24-39-06 -ANNUNCIATOR TROUBLE SHOOTING (S/N 25-1225 thru 25-TBA) The following is a brief operational analysis which pertains to the I.A.I. annunciator on Mooney M20K, S/N 25-1225 thru 25-TBA. GENERAL This document is intended to be a guide to assist a service technician in understanding the theory and operation of International Avionics, Inc.
Page 127
IAI annunciators used unfiltered aircraft 28 VDC to the internal test line, on Mooney aircraft. The GEAR DOWN channel is identified with the mnemonic TEST+. This signal, diode dimmed for night operation; however, in the interest of isolated by CR5, is also supplied as OUTTEST+.
Page 128
IAI annunciators used on Mooney aircraft. The method of dimming, however, has been changed and expanded from what has been used in the past. In the past only...
Page 129
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL Transistor Q6 is controlled in conduction by a latch three signals, the analog signal LAINPUT from a composed of U3 and its associated resistors R22, R23, current sensor, the +28 VDC signal LOVERRIDE from...
Page 130
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION U6 monitors the aircraft 28 VDC by comparing the resistor mounted external to the annunciator is voltage at the arm of R68 with the regulated voltage at required for the 9500326000 annunciator.
Page 131
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL equivalent variable resistor mounted external to the annunciator required 9500326000 annunciator. 9.0 TYPICAL POSITIVE APPLY W/DIM A typical Positive Apply, Dimmable circuit is shown in Figure 8. This channel is designed to accept a +28 VDC signal to illuminate an indicator channel and provide for dimming of that channel, as well.
Page 132
SERVICE AND MAINTENANCE MANUAL M20K MOONEY AIRCRAFT CORPORATION 24-50-00 - ELECTRICAL LOAD DISTRIBUTION de-energize the control relay and connect the standby generator to the standby generator bus. This will allow 24-51-00 - POWER DISTRIBUTION SYSTEM limited equipment to be operated until aircraft can be landed and the alternator system repaired.
Page 133
MOONEY AIRCRAFT CORPORATION M20K SERVICE AND MAINTENANCE MANUAL BLANK 24-51-00 REV. 3 - 00...
Page 435
Service & Maintenance Manual MAN134, Revised March 2000) MOONEY AIRPLANE COMPANY, INC. ISSUED - - JULY 2005 P/N: MAN501 MOONEY AIRPLANE COMPANY, INC. Louis Schreiner Field, Kerrville, Texas 78028 tel: 830-896-6000 www.mooney.com Copyright 2005 - - All Rights Reserved Mooney Airplane Company, Inc.
Page 437
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CHAPTER 91 ELECTRICAL WIRING PARTS LIST & DIAGRAMS (SCHEMATICS) LIST OF EFFECTIVE PAGES CHAPTER ....... .
Page 438
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL INTENTIONALLY LEFT BLANK Page Date SEPT 1997 Rev Date...
Page 439
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL 91- -00- -00 - - GENERAL The electrical system hardware lists and related schematics are sequenced in this section by serial num- ber effectivity. The chapter is divided into the following sections:...
Page 440
91- -00- -02 - - WIRING IDENTIFICATION SYSTEM Under the Mooney wiring system, a typical Wire Identification Number is 21PA03A18. This 9--character number is composed of five functional groups, each of which communicates certain specific information. These functional groups are as follows:...
Page 441
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CIRCUIT FUNCTION LEGEND (con’t.) Miscellaneous -- Auxiliary Power Plug Miscellaneous -- Radio Circuits Miscellaneous -- Cigar Lighter Miscellaneous -- Clock Light Miscellaneous -- Electric Clock Miscellaneous -- Microphone Miscellaneous -- Marker Beacon...
Page 444
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL 91- -20- -00 - - ELECTRICAL SYSTEM HARDWARE CHARTS Refer to the Electrical Schematic (located in the envelopes at the back of this manual) that depicts the Se- rial Number configuration of the aircraft being serviced. The S/N’s vs. Schematic’s are shown below:...
Page 445
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL 91- -20- -01 - - ELECTRICAL SYSTEM HARDWARE CHART - - 14 VOLT SERIAL NUMBER’s 25--0001 THRU 25--0999, MOONEY DRAWING NUMBER. 800330 (CP) CODE DESCRIPTION VENDOR PART NO. NOTES 21 CB101A C/B DEFROSTER BLOWER...
Page 457
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES 21 PB07J BUSS BAR, MAIN POWER MOONEY 21 PB07K BUSS BAR MOONEY 21 PB07L BUSS BAR MOONEY 21 PB08A BUSS BAR, RADIO FLEX MOONEY 21 PB09A...
Page 458
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES 21 PB35A BUSS BAR, MAIN PWR #3 MOONEY 913127--035 21 PB36A BUSS BAR, RADIO #1 MOONEY 913127--035 21 PB37A BUSS BAR, MAIN #1 MOONEY 913127--037 21 PG01A...
Page 469
Set for 75 MPH (+/--5.0) (65 +7/--4 KIAS) increasing actuation. (2.775 in. H O, +0.384/--0.358 in.) Use with socket, 27E122; spring, 206176; stand--off, (2 ea) 21B212. (AN515--6R5 screw, AN936--A6 washer). Alternate L110--1--N--K3L or Mooney P/N 880013--501. Mounting Hardware KC2B Mica Insulating Wafer H.H.
Page 470
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL NOTES (con’t.) Alternate Landing Gear: Mooney 880037--501 Use buss bar 913127--029, --023 or --013 as required by installation of optional equipment. Effective 25--0821 & ON (All are 930023--2xx C/B’s). Effective 24--1464 & ON also.
Page 471
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL 91- -20- -02 - - ELECTRICAL SYSTEM HARDWARE CHART - - 28 VOLT SERIAL NUMBER’s 25--1000 THRU 25--1224, MOONEY DRAWING NO. 800350 (AV--9) CODE DESCRIPTION VENDOR PART NO. NOTES JKL CB101A C/B DEFROSTER BLOWER...
Page 472
MOONEY AIRPLANE COMPANY, INC. M20K EMERGENCY SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JKL CT101A C/B ELECTRIC TRIM KLIXON 7277--2--3 JKL CT101A C/B ELECTRIC TRIM KLIXON 7277--2--5 CT150A POTENIOMETER, TRIM POS. ALLEN--BRADLEY WA2--G056S502UA CT151A PLUG, TRIM POSITION, 4 PIN...
Page 499
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES DM101A HOUR METER MOONEY 880035--505 JK DM102A RECEPTACLE, 4 PIN 206153--1 CLAMP 206062--1 JK DM103A PLUG, 4 PIN 206060--1 CLAMP 206062--1 DM104A FUSEHOLDER LITTEL 155020 (ALT)
Page 500
MOONEY AIRPLANE COMPANY, INC. M20K EMERGENCY SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JK DV102A INDICATOR, FUEL FLOW MOONEY 880034--501 JK DV102A (ALT) MOONEY 880034--503 (ALT) MOONEY 880034--505 (ALT) INDICATOR, F/F (GAL) SHADIN 912021 (ALT) (LBS) SHADIN 912023 JK DV102B...
Page 501
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JK EG109A RECEPTACLE, 4 PIN 206153--1 CLAMP 206062--1 JK EG110A RELAY, GEAR UP C--H 6041H220 JK EG111A DIODE 1N2483 JK EG112A RELAY, GEAR DOWN C--H 6041H220...
Page 502
JK LL104A LIGHT, LANDING, LEFT 4596 JK LL105A LIGHT, LANDING (COWL) 4553 JK LN101A C/B, NAV LIGHT MOONEY 930023--201 JK LN102A LGT ASSY, NAV, TAIL (LT WING) MOONEY 800051--501 BULB WHELEN 34--022--8030--85 91- -20- -03 Page SEPT 1997 Date Rev Date...
Page 503
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JK LN103A LGT ASSY, NAV, TAIL (RT WING) MOONEY 800051--501 BULB WHELEN 34--022--8030--85 JK LN104A PLUG, 9 PIN (RT WING) 206708--1 CLAMP 206062--1 JK LN105A RECEPTACLE, 9 PIN (RT WING) AMP...
Page 504
MOONEY AIRPLANE COMPANY, INC. M20K EMERGENCY SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JK LP125A LIGHTING TRAP (TIT/EGT) B & D 0221--128 JK LP126A PLUG, 20 PIN MOONEY 930022--501 JK LP127A RECEPTACLE, 20 PIN MOONEY 930021--502 JK LP130A RHEOSTAT, MAP LGT (500 OHM) NEWARK...
Page 505
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JK LS113A RECEPTACLE, POWER SUPPLY AMP 1--480305--0 60620--1 JK LS114A RECEPTACLE, POWER SUPPLY AMP 1--480305--0 60620--1 JK LS115A PLUG, 4 PIN 206060--1 CLAMP 206062--1 JK LS116A...
Page 506
MOONEY AIRPLANE COMPANY, INC. M20K EMERGENCY SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES JK MB123A C/B, AUTOPILOT/TRIM KLIXON 7277--2--10-- JK MB124A C/B, A/P ALERT KLIXON 7277--2--7.5 JK MB125A C/B, INVERTER KLIXON 7277--2--7.5 JK MB126A C/B, ART. HORIZ. KLIXON 7277--2--2...
Page 507
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES PA103B SWITCH, ALT. FLD. (STD) MOONEY 880052--503 JK PA104A VOLTAGE REGULATOR MOONEY 880270--501 (ALT) AUXILEC VR--802 (ALT) AM PROD DGR--2 JK PA105A RECEPTACLE, 9 PIN 206708--1...
Page 508
MOONEY AIRPLANE COMPANY, INC. M20K EMERGENCY SCHEMATICS MANUAL CODE DESCRIPTION VENDOR PART NO. NOTES (ALT 3720--GE JK PB104A SWITCH, MASTER MOONEY 880052--501 JK PB105A C/B, BATTERY 41--3--S34--LN2--041800 JK PB106A 41--3--S34--LN2--40A JK PB107A BUS BAR #1 MOONEY 913127--89 JK PB108A BUS BAR #2...
Page 525
6. NOTE 3 USE TO REPLACE ARCHER 40--1325 FOR SPARES. 7. SEAL BACK OF SWITCH WITH DOW CORNING #738 ELECTRICAL SEALANT AFTER WIRES ARE SOLDERED TO TERMINALS (MOONEY CODE #225905) WHEN USED AS “THROTTLE SWITCH GEAR WARNING”. 8. ANNUNCIATOR P/N WILL BE DETERMINED BY OPTIONS INSTALLED, SEE 880090 FOR DETAILS.
Page 526
MOONEY AIRPLANE COMPANY, INC. M20K EMERGENCY SCHEMATICS MANUAL 91- -30- -00 - - ELECTRICAL SYSTEM SCHEMATICS [SEE ENVELOPES] CAUTION: USE SCHEMATIC APPLICABLE TO SERIAL NUMBER OF AIRCRAFT BEING SERVICED. 91- -30- -00 Page SEPT 1997 Date Rev Date...
Page 527
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE A ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800330 (F) (BB) 25--0002 thru 25--0171 91--20--01, Page 9 thru 34...
Page 531
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE B ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800330 (F3) (B) 25--0299 thru 25--0446 91--20--01, Page 9 thru 34...
Page 535
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE C ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800330 (F6) (CF) 25--0781 thru 25--0841 91--20--01, Page 9 thru 34...
Page 539
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE D ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800350 (K1) (J) SHEET 1 OF 2...
Page 542
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE E ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800350 (K2) (AV) Sheet 1 of 2...
Page 546
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE F ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800383 (K2) (F) 25--2001 thru 25--2012 91--20--04, Page 77 thru 89...
Page 549
MOONEY AIRPLANE COMPANY, INC. M20K ELECTRICAL SCHEMATICS MANUAL ENVELOPE G ENCLOSED IN THIS ENVELOPE ELECTRICAL SCHEMATICS MOONEY AIRPLANE COMPANY, INC. M20K RELATED S&M MANUAL SCHEMATIC (NO) (REV) M20K S/N EFFECTIVITY (P/N MAN194) PAGES 800383 (K4) (H) 25--2026 thru 25--2032 91--20--04, Page 77 thru 89...
Need help?
Do you have a question about the M20K and is the answer not in the manual?
Questions and answers