Startup Record - Boreal W-Series Installation And Service Manual

Startup Record Sheet—W-Series Size 25-75 Two-Stage R410a
Installation Site
City
Province
Country
Indoor Loop All shut-off valve are open (full flow available)
(Hydronic)
Loop is full and purged of air
Antifreeze type
Antifreeze concentration
Loop static pressure
Ground Loop All shut-off valve are open (full flow available)
System
Loop is full and purged of air
Antifreeze type
Antifreeze concentration
Loop static pressure
Ground Water Water Valve installed in return line
System
Flow control installed in return line
Domestic Hot All shut-off valves are open
Water
Lines are full and purged
Desuperheater pump wire is disconnected
Electrical High voltage connections are correct and securely fastened
Circuit breaker (or fuse) size and wire gauge for Heat Pump
Circulator pump voltages (Outdoor 1, Outdoor 2, Indoor 1)
Low voltage connections are correct and securely fastened
Preparation Voltage across L1 and L2, L1 and L3, L2 and L3
Heating Mode Suction Pressure / Discharge Pressure
(10 minutes)
Indoor In (Hot In), Indoor Out (Hot Out), and Delta T
Outdoor In (Supply In), Outdoor Out (Supply Out), and Delta T
Outdoor Flow
Compressor L1 (black wire) current
Heating aquastat setpoint and discharge pressure at cycle end
Domestic Hot Water functioning
Cooling Mode Suction Pressure / Discharge Pressure
(10 minutes)
Indoor In (Hot In), Indoor Out (Hot Out), and Delta T
Outdoor In (Supply In), Outdoor Out (Supply Out), and Delta T
Cooling aquastat setpoint and suction pressure at cycle end
Final Aquastat Heating S1 Setpoint, S1 Delta, S2 Setpoint, S2 Delta
Settings
Cooling S1 Setpoint, S1 Delta, S2 Setpoint, S2 Delta
02 JULY 2009
Startup Date Installer
Company
Check boxes unless Model
asked to record data.
Serial #
Circle data units.
PRE-START INSPECTION
STARTUP DATA
Page 23
% Volume % Weight
PSI kPa
% Volume % Weight
PSI kPa
A Ga.
V V V
psig kPa
In Out °F
In Out °F
Igpm USgpm L/s
A
°F °C psig kPa
psig kPa
In Out °F
In Out °F
°F °C psig kPa
°F °C
°F °C
Boreal Geothermal Inc.
VAC
°C
°C
°C
°C