For Europe model Ver. 1 SERVICE MANUAL DN-A100 MODEL INTEGRATED STEREO AMPLIFIER 注 意 サービスをおこなう前に、このサービスマニュアルを 必ずお読みください。本機は、火災、感電、けがなど に対する安全性を確保するために、さまざまな配慮を おこなっており、また法的には「電気用品安全法」に もとづき、所定の許可を得て製造されております。 従ってサービスをおこなう際は、これらの安全性が維 持されるよう、このサービスマニュアルに記載されて いる注意事項を必ずお守りください。 本機の仕様は性能改良のため、予告なく変更すること For purposes of improvement, specifications and ● ● があります。 design are subject to change without notice. 補修用性能部品の保有期間は、製造打切後8年です。...
DN-A100 SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check.
Page 4
DN-A100 ADJUSTMENT 調整 Idling Current アイドリング電流 Required measurement equipment: DC Voltmeter 調整に必要な測定器 : DC Voltmeter 1. Setup 1. 準備 (1) Place the unit at an ordinary position avoiding direct air (1) セットをクーラ、扇風機のそばなど風通しの良い場所 flow from an air-conditioner or fan. Do the adjustment at を避け、通常の使用状態に置きます。セットの周囲温...
Page 5
DN-A100 SEMICONDUCTORS Only major semiconductors are shown, general semiconductors etc. are omitted to list. 主な半導体を記載しています。汎用の半導体は記載を省略しています。 1. IC’s TMP86FH47AUG (IC51) TMP86FH47AUG Terminal Function Pin No. Port Name Function X IN XOUT X OUT TEST TEST XTIN MUTE/STANDBY LED XTOUT RESET RESET...
DN-A100 Pin No. Port Name Function INT1 POWER OFF PDO3/PWM3 AC RELAY 2 AIN0 MODEL AIN1 SP A/B AIN2 REC. SEL AIN3 FUNC. SEL AIN4 STOP2 H/P MUTE AIN5 STOP3 SP A AIN6 STOP4 SP B AIN7 STOP5 VAREF Vref...
DN-A100 TC9164AN (IC20) TC9164AN L-COM R-COM L-COM R-COM L-COM R-COM R-COM L-COM L-COM R-COM DATA LM1117 R-COM L-COM SOT-223 PKG (FRONT VIEW) DATA Shift Register NJM2831F (IC81) LM1117S (IC53) TOP VIEW 1. CONTROL 2. GND FRONT 3. NC VIEW 4. V 5.
Page 8
DN-A100 2. REMOTE CONTROL SENSOR KSM-603TH2A (RC71) TOP VIEW Head Limiter Detector & Hysteresis Comparator Integrator Comparator GND Vcc Vout 3. TRANSISTORS KSA916Y KTA1024Y 2SB1383P KSA1175Y KTA1268GR 2SD2083P KSC2316Y KTC3200GR KTC3114A KSC2785Y KTC3206Y KSC3198Y FRONT FRONT VIEW VIEW B C E...
Page 9
DN-A100 4. DIODES (LED included) 1SS133M ZJ4.7B 1N4003 ZJ7.5B ZJ15B ZJ16B FMG-22S FMG-22R FRONT FRONT VIEW VIEW A K A SEL-2915A (Orange) SML1216W (Red/Green) TOP VIEW TOP VIEW 5. POSISTOR PTFM04BB222QN34 (TH51)
Page 10
DN-A100 PRINTED WIRING BOARDS MAIN P.W.B. UNIT COMPONENT SIDE...
DN-A100 NOTE FOR PARTS LIST 部品表について • Part indicated with the mark "nsp" are not always in stock and possibly to 1.nsp 印の部品は常時在庫していませんので供給に長時間を要すること take a long period of time for supplying, or in some case supplying of part があります。 may be refused.
DN-A100 PARTS LIST OF P.W.B. UNIT *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
DN-A100 EXPLODED VIEW 2 -5 2 -1 2 -4 2 -3 15 -1 15 -2 2 -2 WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer. 印の部分は安全を維持するために重要 な部品です。従って交換時は必ず指定の 部品を使用してください。...
DN-A100 PACKING VIEW 4 -1 4 -4 4 -2 4 -5 4 -3 PARTS LIST OF PACKING & ACCESSORIES *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions.
DN-A100 NOTE FOR SCHEMATIC DIAGRAM 配線図について WARNING: ! 印の部品は安全を維持するために重要な部品です。 Parts marked with this symbol ! have critical characteristics. 従って交換時は必ず指定の部品を使用してください。 Use ONLY replacement parts recommended by the manufactur- 注) CAUTION: (1) 指定なき抵抗値は Ω、k は kΩ、M は MΩ を示す。 Before returning the unit to the customer, make sure you make (2) 指定なきコンデンサーの値は...
Page 26
DN-A100 SCHEMATIC DIAGRAMS (1/2) +16.8V +40.8V +1.0V +39.8V +15.5V -15.5V +11.4V 0.0V -0.1V +11.7V 0.0V -39.8V - 40.8V -1.0V +9.9V -16.5V +15.5V +11.7V +9.9V +11.7V +12.0V +6.0V +3.4V +15.5V -15.5V CUP11904 Main Part SIGNAL LINE SCHEMATIC DIAGRAMS (1/2) MAIN UNIT...
Page 27
DN-A100 SCHEMATIC DIAGRAMS (2/2) +15.5V -15.5V +5.1V +5.1V SIGNAL LINE SCHEMATIC DIAGRAMS (2/2) TONE UNIT FUNCTION SW UNIT VOLUME UNIT POWER SW, H/P UNIT POWER UNIT...
Page 28
DN-A100 DOCUMENTS FOR WEEE Details of Recycle parts * You have to remove the parts that marked “WEEE Mark ◆ “ when the recycling processing. (Europe model only) WEEE Ref. No. Part Name Material Q'ty Mark MAIN PWB COMPLEX ◆...
Page 29
DN-A100 Exploded view of DN-A100 unit (Europe model) You have to remove the parts that marked “WEEE Mark ◆ “ when the recycling processing. (Europe model only) 2 -5 2 -1 2 -4 2 -3 15 -1 15 -2 2 -2...