Maintenance Schedule - HUSTLER Raptor Operator's Manual

Refer to Figure 4-16, Figure 4-17, Figure 4-18, Figure 4-19, Figure 4-20,
Verify safety start interlock system
Visually inspect unit for loose hardware and/or damaged parts
Visually inspect tires
Check oil level, engine (1)
Clean air intake screen (7)
Check fuel level
Blades - sharpen & securely fastened
Discharge chute - securely in place & in lowest position
Check tire pressure with a gauge
Clean engine and transmission compartment
Replace engine air cleaner element (4)(8)
Grease front wheel bearings
Change engine oil & filter (1)(3)
Clean cylinder and head fins (8)
Check battery connections
Clean engine exterior (8)
Tighten lug nuts on wheels (2)
Clean & regap spark plugs (8)
Check transmission & deck belt tension and condition (5)
Check fuel system (6)
Check fuel tank grommet (6)
Change fuel filter (6)
Replace fuel evaporation system filter (7)
Replace spark plugs (8)
NOTES:
Initial engine oil change is after 5 hours of operation. Thereafter, change oil after every 40 hours operation. Change more often under dusty or
1.
dirty conditions and during hot weather periods. Hustler
Torque initially and after first 2 hours of operation.
2.
Change engine oil filter per the engine manufacturer's recommendations. Refer to Engine Owner's Manual for recommendations and other
3.
maintenance items.
Service more often under dusty or dirty conditions. Use caution when servicing to prevent dust contamination in the engine. Do not clean filter
4.
element. Replace with a new one.
Pump drive belt only - Inspect every month and replace if worn or cracking is noticed. Otherwise, replace every 2 years.
5.
Check fuel system for any cracks or leaks including, but not limited to, fuel line hoses, fuel valve, vent line hoses, vent valve, vapor valve, carbon
6.
canister, and grommets. Replace as needed.
More often under dusty or dirty conditions and during hot weather.
7.
Refer to engine owner's manual for engine service information.
8.
* After completing maintenance cycle (100 hours), repeat cycle.
604220

Maintenance Schedule

Figure 4-21, Figure 4-22, & Figure 4-23
SERVICE AT
INTERVALS INDICATED
® Motor Oil is recommended.
4-9
WEEKLY * ANNUALLY
OR 40 OR 100
HOURS HOURS
Prior to each use
Prior to each use
Prior to each use
Prior to each use or every 4 hours
Prior to each use or every 4 hours
Prior to each use
Prior to each use
Prior to each use
Prior to each use
After each use
As needed
X
X
X
X
X
X
X
X
X
X
X
X
X
REV U