CS Series CS60.4 4 CHANNEL POWER AMPLIFIER SERVICE MANUAL JBL Consumer Products 250 Crossways Park Dr. Woodbury, New York 11797 Rev0 11/2005...
Page 2
(336mm x 260mm x 55mm) Fuses: 25A x 2 JBL continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice.
Page 4
Figures 4 through 6. bridged operation is 4 ohms. Figure 4. CS60.4 amplifier in 4-channel (stereo) Figure 5. CS60.4 is set up for 3-channel operation to Figure 6. CS60.4 used in bridged 2-channel mode to drive a set of components or subwoofers. Set operation to drive front and rear full-range speakers.
For subwoofers, choose the highest frequency that removes vocal information from the sound of the subwoofer. If using the CS60.4 to drive a subwoofer(s), set the crossover mode to LP (low pass). TROUBLESHOOTING SYMPTOM LIKELY CAUSE...
Page 7
CS Series 60.4 MAIN AMP MODE HP/FLAT/LP BOOST FRONT L BALANCED VARIABLE LPF/HPF 2 ohm/4 ohm VARIABLE INPUT INPUT (UNIT GAIN) 32Hz--320Hz/12dB 0dB--6dB/45Hz FRONT L 10 320 10 50 SPEAKER AUX OUT FRONT L+ REAR L MAIN AMP MODE HP/FLAT/LP BOOST BALANCED VARIABLE LPF/HPF...
Page 12
CS Series 60.4 CS 60.4 Electrical Parts List Part Number Description Qty Reference Designator Note on Numbering Sequence, all components: "D1~7" (tilde mark) means D1,2,3,4,5,6,7. but "D136-D436" (hyphen) means D136,236,336,436" Main PCB Semiconductors Q2 Q4 Q5 Q16 Q17,Q138-Q438,Q140-Q440 124TN4401 Transistor TR MOTOROLA 2N4401 NPN Q135-Q435 Q143 124TN4403...
Page 13
CS Series 60.4 Part Number Description Qty Reference Designator Note on Numbering Sequence, all components: "D1~7" (tilde mark) means D1,2,3,4,5,6,7. but "D136-D436" (hyphen) means D136,236,336,436" Main PCB 220880243 RESISTOR RD 1/8W 24K R123 R223 220880272 RESISTOR RD 1/8W 2.7K 220880302 RESISTOR RD 1/8W 3K R9 R18 R39 R38...
Page 14
CS Series 60.4 Part Number Description Qty Reference Designator Note on Numbering Sequence, all components: "D1~7" (tilde mark) means D1,2,3,4,5,6,7. but "D136-D436" (hyphen) means D136,236,336,436" Main PCB 401T25815 COPPER BAR φ2.5*81.5m/m H=20 410T21004 BUSS BAR 4P2.1*55.5m/m JP134 571T20070 CONNECTOR W/WIRE 1015# 20AWG 70m/m 572TB6012 CONNECTOR W/WIRE...