Polaris Sportsman 500 Touring Quadricycle Owner's Manual page 130

TROUBLESHOOTING
Engine Does Not Rotate
Possible Cause
Low battery voltage
Loose battery connections
Loose solenoid connections
Engine Rotates, Fails to Start
Possible Cause
Out of fuel
Clogged fuel filter
Water is present in fuel
Old or non-recommended fuel
Fouled or defective spark plug(s)
No spark to spark plug
Water or fuel in crankcase
Low battery voltage
Mechanical failure
Engine Backfires
Possible Cause
Weak spark from spark plug
Incorrect spark plug gap or heat range
Old or non-recommended fuel
Loose ignition connections
Water present in fuel
Incorrectly installed spark plug wires
Incorrect ignition timing
Mechanical failure
128
Solution
Recharge the battery to 12.8 VDC
Check all connections and tighten
Check all connections and tighten
Solution
Refuel
Replace the filter
Drain the fuel system and refuel
Replace with fresh recommended fuel
Inspect plugs and replace if necessary
Inspect plugs, verify stop switch is on
Immediately see your Polaris dealer
Recharge the battery to 12.8 VDC
See your dealer
Solution
Inspect, clean and/or replace spark
plug(s)
Set gap to specs or replace plugs
Check all connections and tighten
Replace with fresh recommended fuel
See your dealer
See your dealer
See your dealer