Vehicle Dismantling Manual - Mahindra THAR 2010 Vehicle Dismantling Manual

Vehicle Dismantling Manual

Vehicle Dismantling Manual
Caution
Provide additional support when a vehicle is on a hoist in the following ways:
• Before removing parts, support the opposite end. This helps to prevent the vehicle
slipping off.
• Before removing the major components, chain the vehicle frame to the hoist pads at the
same end as the removal, this helps to avoid a tip-off.
Disconnect the battery prior to fluid removal and dismantling in order to reduce risk of fire
and personal injuries.
Always wear safety goggles when working with fuel inn order to protect the eyes from
splash.
Fuel vapors are highly flammable. A fire could occur if an ignition source is present. Never
drain or store fuel in an open container, due to the possible of any fire or explosion. Have a
dry chemical (Class B) fire extinguisher nearby always.
Relieve the fuel system pressure before dismantling fuel system component in order to
reduce the risk of fire accident and personal injuries.
Drain the fuel completely from the system like fuel injector nozzle, the fuel pump, fuel pipe
lines and the fuel tank. Draining the fuel will reduce the risk of fire accident and personal
injury.
Provide proper ventilation, when working with fuel in enclosed areas where fuel vapors can
collect. The lack of adequate ventilation may result in personal injuries.
While performing disassembly on or near the Airbag (SRS) components or the wiring point of
those components, cautions to be followed are listed below (
).
SRS system
Note: If fail to follow these cautions could cause airbag deployment or some personal
injuries.
• Be careful when handling the SRS sensor.
• Do not Strike or jolt a SRS sensor.
• Do not carry the inflator module by the wires or the connector on the inflator module.
• Make sure the airbag opening points away from your side.
• Follow the airbag (SRS) deployment procedure available before carrying out
the vehicle dismantling.
• Provide free space for the airbag to expand in case of an accidental deployment.
Thar
Applicable only on the models having
1