Related Manuals for Echo SRM-22GES
Summary of Contents for Echo SRM-22GES
- Page 1 OPERATOR’S MANUAL GRASS TRIMMER/ BRUSHCUTTER SRM-22GES WARNING READ INSTRUCTIONS CAREFULLY AND FOLLOW RULES FOR SAFE OPERATION. FAILURE TO DO SO COULD RESULT IN SERIOUS INJURY.
-
Page 2: Table Of Contents
INTRODUCTION ECHO Grass Trimmers/Brushcutters are lightweight, high- Feature of this model: “ES” START performance, petrol engined units designed for weed “ES” START generates enough revolving power to rotate control, grass trimming and light brush cutting in areas crankshaft up to a speed to ignite the engine and bring difficult to control by any other means. -
Page 3: Decals And Symbols
Make sure the decal is legible and that you understand and illustration found in the “DESCRIPTION” section will help follow the instructions on it. If a decal cannot be read, a new you locate them. one can be ordered from your ECHO dealer. Part Number 890617-43130 SRM-22GES... -
Page 4: Rules For Safe Operation
MATERIAL BEING CUT. READ THESE “RULES FOR SAFE OPERATION” WITH CARE. FOLLOW INSTRUCTIONS IN THE OPERATOR’S MANUAL. • If you have any questions or problems, please contact your ECHO dealer. Do not permit operation without proper training and protective equipment. - Page 5 PHYSICAL CONDITION You should be in good mental and physical health. Do not operate if you are under the influence of alcohol or any medication or substance which could affect your vision, dexterity or judgement. SRM-22GES...
- Page 6 Manual gives instruction. Do not try to repair the unit without proper instruction. The unit should be serviced only by trained ECHO dealer servicemen with the proper tools. Be sure that : a) Engine does not leak fuel.
- Page 7 ECHO servicing dealer Keep feet and hands on a timely basis. away until rotation stops All required service or repair must be done only by ECHO servicing dealer. Never attempt to use an incomplete or one fitted with unauthorized modification. SRM-22GES...
- Page 8 • Do exercises to strengthen hand and arm muscles. • See a doctor if you feel tingling, numbness or pain in your fingers, hands, wrists or arms. The sooner RSI is diagnosed, the more likely permanent nerve and muscle damage can be prevented. SRM-22GES...
- Page 9 Cut on this side WARNING USE ONLY FLEXIBLE, NON-METALLIC LINE RECOMMENDED BY KIORITZ CORPORATION. SRM-22GES...
- Page 10 RECOMMENDED BY KIORITZ CORPORATION. WARNING EXCESSIVE NYLON LINE BEYOND CUT OFF KNIFE COULD FLY OFF WHEN THE NYLON LINE CUTTER STARTS ROTATING AFTER ADJUSTMENT OF NYLON LINE LENGTH. WARNING USE ONLY NYLON LINE. DO NOT USE ANY TYPE OF METAL BLADE. SRM-22GES...
-
Page 11: Description
7 FRONT (LOOP) HANDLE Light weight, suitable for Nylon line trimmer only. 17 SPARK PLUG 8 IGNITION SWITCH ”Slide Switch” mounted on top of 18 SAFETY DECAL Part Number 8910617-43130 the Throttle Trigger Housing, move switch forward to RUN, backward to STOP position. SRM-22GES... -
Page 12: Assembling
3. Thread line head onto shaft by turning it anticlockwise until head is tight against upper plate. 4. Remove head locking tool. CAUTION Fasten output shaft using locking tool securely in order to avoid the possibility of output shaft Locking tool rotating when mounting nylon line head. SRM-22GES... - Page 13 • Cut off knife on the shield adjusts cutting swath to 40 cm automatically by cutting nylon lines evenly when attachment starts rotating. • When operating with less than maximum cutting swath (40 cm), cut two nylon lines in equal lengths. CAUTION Use only flexible, non-metallic line recommended by KIORITZ CORPORATION. SRM-22GES...
- Page 14 MAKE SURE EACH OUTER PERIPHERY OF PAWLS OF HOUSING SPREADS ALMOST FULLY UP TO THE OUTER PERIPHERY OF RESPECTIVE WINDOW OF COVER. IF THEY ARE LOOSELY FITTED AND THE CUTTING HEAD IS TURNED, COVER OR INSIDE COMPONENTS CAN FLY OFF WHICH IS DANGEROUS. SRM-22GES...
-
Page 15: Fuel
10 % of ethyl alcohol. • Recommended mixture ratio; 50 : 1 (2 %) for ISO-L-EGD Standard (ISO/CD 13738), JASO FC grade and ECHO Premium 50 : 1. - Do not mix directly in engine fuel tank. -
Page 16: Operation
• Place ignition switch in “STOP” position. WARNING IF ENGINE DOES NOT STOP, CLOSE CHOKE TO STALL ENGINE. HAVE YOUR ECHO DEALER INSPECT AND REPAIR IGNITION SWITCH BEFORE USING THE UNIT. Always disconnect the spark plug wire from the spark plug to ensure the engine cannot be started before you work on the unit or leave it unattended. -
Page 17: Maintenance And Care
MAINTENANCE AND CARE • If you have any questions or problems, please contact your ECHO dealer. Air filter CLEANING AIR FILTER • Close choke and remove air cleaner cover. • Remove air filter (air filter is located inside air cleaner cover). - Page 18 170 kgf•cm). ANGLE TRANSMISSION • Remove plug from angle transmission. Angle transmission • Add grease, if necessary, using low pressure pump. • Reinstall plug. NOTE Use good quality lithium multi grease. DO NOT overfill housing. Grease tube Plug (Bolt) SRM-22GES...
- Page 19 Cut off Knife Inspect/Clean • Fuel System Inspect • Screws, Bolts and Nuts Inspect, Tighten/Replace • IMPORTANT Time intervals are maximum. Actual use and your experience will determine the frequency of required maintenance. Or 50 hours, whichever occurs first. SRM-22GES...
-
Page 20: Trouble Shooting
• Fuel filter clogged • Clean or replace cranks carburettor at carburettor • Fuel line clogged • Clean • Carburettor • Ask your ECHO dealer Fuel at No fuel at • Carburettor • Ask your ECHO dealer cylinder cylinder Silencer wet •... -
Page 21: Storage
• If this operator’s manual has become illegible through impairment or is lost, please purchase a new one from your ECHO dealer. • When renting or lending this machine to a person who will operate it, always include this operator’s manual, which provides explanation and instructions. -
Page 22: Specifications
10 % of ethyl alcohol. Two stroke, air-cooled engine oil. 50 : 1 for ISO-L- EGD Standard (ISO/CD 13738), JASO FC grade and ECHO Premium 50 : 1 oil. ratio 50 : 1 (2 %) fuel consumption at maximum engine power 0.62... - Page 23 MEMORANDUM SRM-22GES...
- Page 24 7-2 SUEHIROCHO 1-CHOME, OHME, TOKYO 198-8711, JAPAN PHONE: 81-428-32-6118. FAX: 81-428-32-6145. X771-000 72 1 X771 227-700 1 © 2006...