Page 1
VCSD-04 User Guide Vax Commercial Careline: (UK) 0330 026 4275 vaxcommercial.co.uk A leading brand from one of the world’s VCSD-04 largest floor care manufacturers.
2. Before using the machine, make sure that each part is in the correct position. 3. Do not use charger if the cable is damaged. Contact Vax Commercial Careline: (UK) 0330 026 4275. 4. The machine should only be used by personnel who have received appropriate training.
Page 3
(e.g. petrol, fuel oil, etc.); never vacuum flaming or incandescent objects. 11. Do not use the machine on slopes or ramps steeper than 2%. 12. Never park the machine on a slope. Vax Careline: (UK) 0330 026 4275...
Page 4
General safety information 13. Never leave the machine unattended with the key in the ignition, to prevent any accidental movements. If necessary, disconnect the electrical power supply using the connection underneath the driver’s seat. 14. Make sure there are no other persons, children in particular, in the area where the machine is being used.
Page 5
30. Operations: dispose of them in accordance with current legal provisions. 31. IMPORTANT: Remove the battery from the appliance before recycling. For further information please contact your local waste management centre. Vax Careline: (UK) 0330 026 4275...
Page 6
Machine overview VCSD-04 Dirty water tank 12. Brush lever 2. Dirty water tank cover 13. Squeegee height lever 3. Clean water tank 14. Water flow control 4. Front opening 15. Battery security connector 1. Clean water filling point 16. Dirty water tank drain hose 2.
Preparation PLEASE READ ‘GENERAL SAFETY INFORMATION’ BEFORE USE Charging the machine: • If the machine is used regularly: Always keep the batteries connected to the battery charger when the machine is not being used. • If the machine is not used for extended periods: Charge the battery during the night after the last work period, then disconnect the battery from the battery charger.
Page 9
Detaching the brush Battery Place the brush on floor. Lower the brush by releasing Line up and centre the brush height lever. the brush with the brush plate. Vax Careline: (UK) 0330 026 4275...
Operation Line up and centre Lower the brush by releasing the brush with the the brush height lever. brush plate. Squeegee frame IMPORTANT: Check squeegee blades are clean and not worn before fitting squeegee to the machine. A. Bumper wheel B.
• Ensure sponge is replaced point into the tank. before starting machine. IMPORTANT: Only use Vax Commercial recommended detergents. The use of other chemical products may not allow the machine to perform at its optimum capabilities. Vax Careline: (UK) 0330 026 4275...
Page 12
Operation WARNING: To disable during operation, pull the battery security connector to disconnect all power to machine. Operating the machine Battery Insert the battery Insert the ignition key Activate the brush motor Lower the squeegee lever. security connector. and turn on switch on and suction motor.
NOTE: • The machine should be emptied and cleaned after each use. • Do not leave the machine with dirty water in the tank as can cause blockages and potentially create bad odours. Vax Careline: (UK) 0330 026 4275...
Page 14
Maintenance Cleaning of the suction motor filter and float Lift to remove the dirty water Remove the suction filter Separate the filter and casing tank cover. and rubber casing. and rinse under water. 24hr Leave to dry for 24 hours or Use an allen key to undo Remove any dirt/debris, rinse until fully dry before placing...
Pull to remove the water situated below dirty anticlockwise to remove. filter from the flow tap. water tank. Remove any dirt/debris, Push and refit the water filter. rinse under water. Twist flow tap clockwise to refit. Vax Careline: (UK) 0330 026 4275...
Page 16
IMPORTANT: All work on the electrical system as well as all maintenance and repair operations (especially those not explicitly described in this user guide) should be carried out only by Vax authorised technical personnel who are experts in the sector and in the pertinent safety regulations.
To avoid damaging the floor and brushes. and the machine, carefully check if debris, such as metallic parts, screws, chips, cords or similar items, have become lodged in the brushes. Vax Careline: (UK) 0330 026 4275...
Page 18
Maintenance Cleaning the suction hose • This will prevent blockages affecting the machines performance and will reduce odour build up. • It is recommended that the suction hose is cleaned at regular intervals (weekly) or whenever performance is reduced. • Detach the suction hose from the squeegee. •...
Page 19
The machine has over heated. Check what may have caused the malfunction (high slope, brush or squeegee blockage). Wait 30 minutes and try to avoid the same incorrect process. If the problem persists, contact Vax Commercial Careline: (UK) 0330 0264275.
Page 20
Check there is no damage to the battery charger cable. If damaged do not use. Contact Vax Commercial Careline:(UK) 0330 026 4275 for more assistance. Vax Commercial CANNOT solve problems caused by using batteries and battery chargers that were not directly supplied by the manufacturer.
9.00am to 5.00pm Any queries or concerns about using your Vax, call the Vax Commercial Careline. Calls are charged at the UK local rate. Please make a note of the serial number and model number of the vacuum cleaner before calling. For the nearest Service Agent, please call the Vax Commercial Careline or visit vaxcommercial.co.uk...
Page 24
COMMERCIAL Vax Ltd., Plot 302, Stonebridge Cross Business Park, Hampton Lovett, Droitwich, WR9 0LW, UK email: info@vaxcommercial.co.uk website: vaxcommercial.co.uk A leading brand from one of the world’s Version 1 largest floor care manufacturers.