Related Manuals for JAYLINE SS280PW
Summary of Contents for JAYLINE SS280PW
- Page 1 JAYLINE SS280PW FREESTANDING WOOD FIRE INSTALLATION & OPERATION INSTRUCTIONS Please leave this information with the appliance APRIL 2017...
-
Page 2: Product Registration
RETAIL LINKS LTD PO BOX 9056 ANNESBROOK, 7044 NELSON NAME: ________________________________________________________________________ ADDRESS: ____________________________________________________________________ ______________________________________________________________________________ ______________________________________________________________________________ EMAIL: ________________________________________ PHONE: ________________________ MODEL: ______________________________________________________________________ SERIAL NUMBER: ______________________________________________________________ DATE PURCHASED: ____________________________________________________________ PURCHASED FROM: ____________________________________________________________ DATE INSTALLED: ______________________________________________________________ INSTALLED BY: ________________________________________________________________ www.jayline.co.nz page 2 APRIL 2017... -
Page 3: Installation
Keep this booklet as a reference guide. INSTALLATION OF YOUR JAYLINE WOOD FIRE Jayline recommends you use a suitably quali ed installation technician to install your re. Your dealer or heating specialist will be able to help with recommendations as well as advise on permits/consents required for the installation in your area. - Page 4 6mm x 50mm dynabolts. BAFFLE Before lighting your appliance for the rst time, make sure the ba e is in the correct position being as far to the rear as possible. www.jayline.co.nz page 4 APRIL 2017...
- Page 5 WATER BOOSTER INSTALLATION (Installation Instructions supplied separately with Booster) WATER BOOSTER GENERAL Please check the Speci cation sheet for this model regarding the Water Booster. A Jayline SS280 PW 3.1kW Water Booster (#302838) must be used with this model to comply with the clean air requirements and the warranty (if non rural).
- Page 6 4. CAUTION: CRACKED AND BROKEN COMPONENTS, E.G. GLASS PANELS OR CERAMIC BRICKS MAY RENDER THE INSTALLATION UNSAFE. 5. THE JAYLINE SS280PW SHOULD NOT BE USED WITHOUT THE WATER BOOSTER (#30283), AS IT MAY CAUSE A SAFETY HAZARD. Any variation from these installation instructions or any doubts about them must be checked against the requirements of the AS/NZS 2918:2001.
- Page 7 CORRECT OPERATION OF YOUR JAYLINE WOOD FIRE Simply by burning your Jayline re correctly, you can improve e ciency, reduce fuel consumption and minimise air pollution. STARTING A NEW FIRE Please note: If lighting the re for the rst time, dust re, glass, trim and ue before ring to avoid particles sticking or discolouring.
- Page 8 7 (loaded front to back). Try to avoid smothering the re with the new pieces. Placing the pieces on the burning kindling can help prevent smothering. Your Jayline heater requires approximately 45-60 minutes to preheat the steel rebox before it can e ectively emit heat into the room.
- Page 9 AS VIEWED FROM DOOR Fire in cycles: Don’t expect perfectly steady heat output from your Jayline heater. Solid fuel heaters burn in cycles. A cycle is the time between the ignition of a load from charcoal and the consumption of the load back to a coal bed.
- Page 10 Correctly installed and operated, Jayline solid fuel heaters do not spill smoke into the house. There are three main reasons why some woodstoves smoke: Bad installation design: Incorrect ue installation, resulting in low ue temperatures and low draught, can make a wood heater more likely to spill smoke.
- Page 11 During the summer, as warm breezes ow through the stacks, carrying away the evaporating water, the moisture content of the wood will fall to around 20 per cent. At this moisture content the wood is ready for burning. www.jayline.co.nz page 11 APRIL 2017...
-
Page 12: Burning Coal
General maintenance checks should include the following:- ASH REMOVAL - Due to the high e ciency of your Jayline re, ash removal should only be necessary every few weeks. Ashes can be removed easily through the re door when the re is at its lowest, such as rst thing in the morning, or when it is completely out. - Page 13 Flue pipes can deteriorate very quickly with incorrect ring. CONSUMABLES Some parts of your Jayline re are considered consumable. They are designed to be replaced as they will degrade over time. The life of the consumables will vary depending on;...
- Page 14 WARNINGS Below is a list of warnings to ensure e cient and safe operation of your Jayline wood re: • WARNING: DO NOT USE FLAMMABLE LIQUIDS OR AEROSOLS TO START OR REKINDLE THE FIRE. • WARNING: DO NOT USE FLAMMABLE LIQUIDS OR AEROSOLS IN THE VICINITY OF THIS APPLIANCE WHEN IT IS OPERATING.
- Page 15 We select only certain companies to act as our Jayline dealers. They must have high standards and be able to provide a total service both pre and post sale to you the customer. Therefore we have every con dence that our dealers will be able to answer your questions or x any problem that may occur.
- Page 16 All claims (in the rst instance) should be directed to the store of purchase. Any repairs undertaken without the manufacturer’s authority will render the guarantee void. Water boosters must be a Jayline model speci ed with the re to be covered; this guarantee applies to the original purchaser only.