Table of Contents
Advertisement
Quick Links
Owner's Manual
for Assembly, Operating & Maintenance of
Model A2TS Built-In Gas Grill
YOU MUST READ THIS OWNER'S MANUAL
BEFORE OPERATING YOUR GAS GRILL.
DANGER
IF YOU SMELL GAS:
1. SHUT OFF GAS TO APPLIANCE
2. EXTINGUISH OPEN FLAMES
3. OPEN LID (IF APPLICABLE)
4. IF ODOR CONTINUES, KEEP AWAY FROM THE
APPLIANCE AND IMMEDIATELY CALL YOUR
GAS SUPPLIER OR FIRE DEPARTMENT.
LEAKING GAS MAY CAUSE FIRE, EXPLOSION,
PERSONAL INJURY, DAMAGE TO PROPERTY, AND
DEATH.
THIS GAS GRILL IS DESIGNED FOR OUTDOOR USE ONLY.
P: 814-359-2755
526 EAST ROLLING RIDGE DRIVE, BELLEFONTE, PA 16823
F: 814-359-2621
WARNING: Follow all leak-check
procedures listed in this manual carefully
prior to operation of this unit. Do this
even if the grill was assembled by a
professional.
WARNING: Do not ignite this grill without
reading the LIGHTING INSTRUCTIONS
first.
WARNING: DO NOT store or use
gasoline or other flammable liquids/
vapors in the vicinity of this grill.
An LP Cylinder not connected for use
should not be stored in the vicinity of this
unit.
sales@bigjohngrills.com
www.bigjohngrills.com
1
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for BIG JOHN A2TS
Summary of Contents for BIG JOHN A2TS
- Page 1 Owner’s Manual for Assembly, Operating & Maintenance of Model A2TS Built-In Gas Grill www.bigjohngrills.com YOU MUST READ THIS OWNER’S MANUAL WARNING: Follow all leak-check BEFORE OPERATING YOUR GAS GRILL. procedures listed in this manual carefully prior to operation of this unit. Do this...
-
Page 2: Table Of Contents
TABLE OF CONTENTS 1. PROPANE SAFETY - GENERAL Page 3 2. PROPANE SAFETY - CYLINDER Page 4 3. GENERAL INFORMATION Page 5 4. ASSEMBLY INSTRUCTIONS Page 6 5. SET-UP INSTRUCTIONS Page 7 6. OPERATING INSTRUCTIONS Page 8 7. CLEANING & CARE INSTRUCTIONS Page 9 8. -
Page 3: Propane Safety - General
All tanks used on Big John Grills equipment must be a minimum of 30 lb. size. Tanks larger than 100 lbs. in size may require a POL for connection. Please call a Big John Cus- tomer Service Representative if you are using a 100 lb. propane tank. -
Page 4: Propane Safety - Cylinder
PROPANE SAFETY - CYLINDER DISCONNECTING AND TRANSPORTING PROPANE CYLINDERS FOR REFILLING Turn off all control knobs and close the main cylinder valve. Disconnect regulator with QCC. Place cylinder valve plug snugly in the main cylinder valve outlet. Only use the cylinder valve plug ... -
Page 5: General Information
GENERAL INFORMATION Thank you for purchasing a Big John Commercial Built-In Gas Grill! We take pride in producing and selling equipment made right here in America and are pleased that you recognized the quality and dura- bility of our products. Your new grill is a commercial grade, outdoor piece of cooking equipment. With this unit, you will be able to cook a variety of foods quickly and easily. -
Page 6: Assembly Instructions
ASSEMBLY INSTRUCTIONS This unit ships 90% assembled and we make sure the instructions for the rest are easy to follow and perform. Please follow the instructions below to ensure your grill is properly assembled for safe opera- tion. Please remember this is a commercial piece of equipment and therefore the materials used to build it are of the best quality. -
Page 7: Set-Up Instructions
SET-UP INSTRUCTIONS 1. Ensure unit is properly installed in structure and gas connections have been tested and approved by the professional installing the unit. 2. Once properly installed, remove cooking grates and empty one bag of lava rock in each section - di- rectly on top of the burner tubes and burner insert pan. -
Page 8: Operating Instructions
OPERATING INSTRUCTIONS 1. DO NOT ATTEMPT TO LIGHT UNIT WITHOUT REMOVING THE WEATHER COVER OR OPEN- ING THE STAINLESS STEEL HOOD. Gas can accumulate and cause RAPID IGNITION. Always be sure unit is lit before closing the hood. 2. Ensure all control valves are in the CLOSED position (parallel to the work shelf with all knob ends turned to the left). -
Page 9: Cleaning & Care Instructions
CLEANING & CARE Remember, open flame cooking can cause significant splatter that can bake onto surfaces . Unlike oven or top burner cooking, the meat is not in a pot or pan and grease laden smoke will reach all surfaces. More cleaning is necessary to keep stainless steel components, like the front work shelf, bright and new. -
Page 10: Parts List
Stainless Steel Drip Tray (17.5”L x 14.75”W x 0.375”H) 301045 Set of 4 Drip Tray Locks If you are in need of additional parts not found on this list, please call Big John Grills Customer Service at 800-326-9575 or 814-359-2755. -
Page 12: Accessory List
ACCESSORIES Item # Description 301091A FA-2 Stainless Steel Fits-All Hood 301138 2” Temperature Gauge for Stainless Steel Hood 301113 SG-3; 16” x 40” Steel Griddle with Grease Trap (Elevated Above Cooking Grates) 301110 SG-2; 15” x 30” Steel Griddle with 2 Handles (Sits Directly on Cooking Grates) 301106 SG-1;... -
Page 13: Troubleshooting Guide
TROUBLESHOOTING GUIDE At any point in time, if you are experiencing problems with your grill call your local Gas Service or Appli- ance Service and have them inspect and clean your equipment. -
Page 14: Warranty Information
WARRANTY INFORMATION Big John Corporation provides a warranty, to the original purchaser, for all Big John finished units for a period of 1 year from the date of sale. Any unit, or part thereof returned, freight prepaid, to our Sales &... -
Page 15: Warnings
If you wish to change your unit from LP to NG or vice versa, Do not store extra liquid propane cylinders within the vicinity please call a Big John Customer Service Agent to obtain of this product. required parts.
Need help?
Do you have a question about the A2TS and is the answer not in the manual?
Questions and answers