Bradley Stand-On Compact Mower Owner’s Manual NOTICE!!! This symbol means: Unauthorized modifications may present extreme ATTENTION! safety hazards to operators and bystanders and could also result in product damage. Your safety and the safety of others is involved. Havener Enterprises, Inc. strongly warns against Signal word definitions: rejects and disclaims any modifications, add-on accessories or product alterations that are not...
Bradley Stand-On Compact Mower Owner’s Manual SAFETY INFORMATION Read This Manual Carefully and Thoroughly Before Operating Your Mower! Carefully and thoroughly read the owner's manual. Allow adequate time to fully understand the controls and operation of the equipment. Never allow anyone to operate the mower that has not read and fully understood the owner's manual.
Page 5
Bradley Stand-On Compact Mower Owner’s Manual OPERATION OF EQUIPMENT DANGER: Gasoline is highly flammable and explosive. Do not add fuel while engine is running or is hot. Keep open flames,sparks,and heat away from the fuel and store fuel in containers specifically designed for that purpose.Add fuel outdoors only and if the fuel is spilled, Do not start the engine.
Bradley Stand-On Compact Mower Owner’s Manual OPERATING THE MOWER It is recommended that before you operate the mower, you allow adequate time to fully understand the controls and operation of the equipment. When reading this manual, it is recommended that you do so with the equipment nearby for quick orientation, to reference the controls, and understand maintenance adjustments.
Page 7
Bradley Stand-On Compact Mower Owner’s Manual STARTING THE ENGINE (Make Sure Battery Is Fully Charged) DANGER: Do not operate the engine in a confined space where dangerous carbon monoxide fumes can collect .Carbon monoxide is odorless,tasteless,and can be fatal . After going through the steps on pages 3 and 4, you are ready to start the engine.
Page 8
Bradley Stand-On Compact Mower Owner’s Manual STOPPING THE MOWER Gently let the Left and Right Control Levers return to their neutral, at rest position. If the operator is leaving the operator position for any reason, disengage the blades, shut off the engine, engage the parking brake, and remove the key.
Bradley Stand-On Compact Mower Owner’s Manual TOOLS REQUIRED FOR ASSEMBLY Metal saw Ratchets: 3/8".e Sockets: 9/6", 3/4" Wrenches: 3/8", 9/6", 3/4" Straight edge Tire pressure gauge Blocks (for deck leveling) NOTE: All references below to the "right" or "left" are with respect to an operator at the controls. 1.
Page 10
Bradley Stand-On Compact Mower Owner’s Manual 5. FINAL PREPARATIONS Check the engine and hydraulic oil levels. Top up with the correct oil if necessary. Use SAE 10W30 motor oil for the engine. Use fresh, clean SAE 20W50 motor oil for the hydraulic system. After running for one hour, let hydraulic system oil cool.
Bradley Stand-On Compact Mower Owner’s Manual Maintenance is an ongoing job. These intervals are maximum times between maintenance operations. Perform more often under severe conditions. MAINTENANCE OPERATION BEFORE EVERY EVERY EVERY EVERY FIRST 5 EACH YEARLY HOURS HOURS HOURS HOURS HOURS ENGINE Consult the engine manual for additional information and instructions...
Bradley Stand-On Compact Mower Owner’s Manual NOTES GENERAL DATE DATE DATE DATE DATE DATE Check Tire Pressures Lubricate All Points Check Nuts & Bolts ENGINE Check Oil Level Change Oil Clean Air Cleaner Element Clean Cooling Fans Replace Air Cleaner Element Clean &...
Bradley Stand-On Compact Mower Owner’s Manual CHECK DAILY Operator Presence Interlock System 一 Start Operation For the engine to crank, the parking brake must be ON, the PTO (blades) OFF. Stand on the operator platform and check, one by one, if the engine will crank with the parking brake OFF or the PTO (Blades) Operator Presence Interlock System 一...
Page 14
Bradley Stand-On Compact Mower Owner’s Manual LUBRICATION Every 50 hours of operation, lubricate the following points (1-3) with grease: 1. Deck lift pivots (4 points) 2. Pull arm pivots (4 points) 3. Deck idler pivot (1 point) 4. The pedal pivots (2 points) Every 500 hours or once a year: 5.
Bradley Stand-On Compact Mower Owner’s Manual ENGINE OIL Do not perform engine maintenance without the engine off, spark plug wires disconnected and PTO disengaged. AFTER FIRST FIVE HOURS While the engine is warm: Release the oil drain hose assembly from the engine clip J.
Bradley Stand-On Compact Mower Owner’s Manual TRANSAXLES WARNING Inattention to proper safety, operation, or maintena- nce procedures could result in personal injury, or damage to the equipment. Perform transaxle maintenance with the engine off, spark plug wires disconnected and PTO disengaged .
Page 17
Bradley Stand-On Compact Mower Owner’s Manual the other bypass control rod. Start engine, PURGING TRANSAXLES slowly move the control levers in both forward Due to the effects air has on efficiency in hydrosta- and reverse directions 5 to 6 times. As air is tic drive applications, it is critical that it be purged purged from the unit, the oil level will drop.
Page 19
Bradley Stand-On Compact Mower Owner’s Manual BLADE REMOVAL BLADE BALANCE Blade balance must be maintained at 5/8 oz-in Follow these instructions to prevent injury during (1 9.4 g-cm) or less. Failure to keep blades blade removal : balanced causes excess vibration, wear, and Loosen with box wrench or socket and long shortened life of most components of the breaker bar.
Page 20
Bradley Stand-On Compact Mower Owner’s Manual BELTS All belts are tensioned by spring loaded idlers. No adjustment is required. DECK LEVELING Park the machine on a smooth, level surface. Raise the deck to the transport position. Lower the deck onto a set of equal height blocks A under the rear corners of the deck.
Page 21
Bradley Stand-On Compact Mower Owner’s Manual DECK ROLLERS The rear outside deck rollers are adjustable up and down to provide improved deck flotation and scal- ping protection at various heights of cut. They are not intended to ride continuously on the ground. Adjust no closer than 3/8"...
Bradley Stand-On Compact Mower Owner’s Manual Note: Use belts designed for commercial mowers. CUTTERDECK BELT Remove center, left and right belt guards. Set the cutterdeck in a middle height-of-cut position. Loosen bolt on belt guide so belt guide can be moved to remove the belt.
Page 23
Bradley Stand-On Compact Mower Owner’s Manual POWER UNITS ENGINES: NET WEIGHT: Construction: Aluminum block with cast-in cast iron 48SC: 923 Ibs (420 kg) sleeves. Aluminum head. 52SC: 945 Ibs (430 kg) Configuration: 4-stroke, vertical shaft, V-twin cylinder, overhead valve, air-cooled...
Bradley Stand-On Compact Mower Parts List FUEL TANK & BATTERY ASSEMBLY...
Page 45
Bradley Stand-On Compact Mower Parts List ITEM PART NO. DESCRIPTION 601-109 Fuel Return Line 601-110 Fuel Line 601-111 Fuel Line Clamp 601-083 Frame 601-113 Fuel Tank 601-114 Fuel Tank Strap 600-001-0645 Bolt M6*45 600-301-0006 Plain Washer 6 600-201-0006 Nylon Nut M6 601-115 Tank Pad 601-116...
Page 46
Bradley Stand-On Compact Mower Parts List FUEL TANK & BATTERY ASSEMBLY CONTINUED ITEM PART NO. DESCRIPTION 601-216 Pick Up Tube 601-217 Grommet 601-218 ROV with Grommet 601-219 Fuel Tank Cap 601-220 Fuel Tank Body 601-221 Black Battery Cable 601-222 Black Terminal Protector 601-223 Red Terminal Protector 601-224...
Need help?
Do you have a question about the 48SC and is the answer not in the manual?
Questions and answers