Multi-cd control high power cd player with fm/am tuner (83 pages)
Summary of Contents for Pioneer DEH-P250
Page 1
PIONEER ELECTRONICS (USA) INC. P.O.Box 1760, Long Beach, CA 90801-1760 U.S.A. PIONEER EUROPE NV Haven 1087 Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE.LTD. 253 Alexandra Road, #04-01, Singapore 159936 C PIONEER CORPORATION 2002 K-ZZA. OCT. 2002 Printed in Japan http://www.xiaoyu163.com...
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. DEH-P250/XM/UC http://www.xiaoyu163.com...
Unplugging and plugging the connectors dur- ing power-on mode may damage the ICs inside the unit. u163 2. To protect the pickup unit from electrostatic dis- charge during serviving, take an appropriate treat- ment(shorting-solder) by referring to "the DISAS- SEMBLY" on page 45. DEH-P250/XM/UC http://www.xiaoyu163.com...
3 7 63 1515 0 (2) CONTRAST TABLE DEH-P250/XM/UC, DEH-P250/XN/UC, DEH-P2500/XM/UC, DEH-P2500/XN/UC, DEH-P25/XM/UC and DEH-P25/XN/UC are constructed the same except for the following: Part No. Mark No. Symbol and Description DEH-P250/XM/UC DEH-P2500/XM/UC DEH-P25/XM/UC 17 Carton CHG4958 CHG4959 CHG4960 18 Contain Box...
Page 9
87 Grille Unit See Contrast table(2) 43 Spring CBH2653 2SD2375 Transistor(Q752, 901, 911) 44 Spring CBL1512 89 IC(IC301) PAL007A 45 Holder CND1254 90 IC(IC1902) TSOP4840SB1 u163 91 Holder See Contrast table(2) 92 Screw See Contrast table(2) 93 Choke Coil(L981) CTH1280 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 10
3 7 63 1515 0 (2) CONTRAST TABLE DEH-P250/XM/UC, DEH-P250/XN/UC, DEH-P2500/XM/UC, DEH-P2500/XN/UC, DEH-P25/XM/UC and DEH-P25/XN/UC are constructed the same except for the following: Part No. Mark No. Symbol and Description DEH-P250/XM/UC DEH-P2500/XM/UC DEH-P25/XM/UC 16 Panel CNS6935 CNS7309 CNS7309 35 Holder Unit...
Note: When ordering service parts, be sure to refer to “EXPLODED VIEWS AND PARTS LIST” or “ELECTRICAL PARTS LIST”. Large size SCH diagram Guide page Detailed page FM:-31.0dBs AM:-31.0dBs R4721 IP-BUS:+2.2dBs CD:0dBs CD:0dBs CN701 IP-BUS:+2.2dBs IP-BUS L 13942296513 R9101 FM(30%):-30.0dBs AM(30%):-30.0dBs R9403 EJECT CN1901 u163 PANEL UNIT DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 17
Decimal points for resistor u163 No differentiation is made between chip resistors and and capacitor fixed values discrete resistors. are expressed as : Symbol indicates a capacitor. ← No differentiation is made between chip capacitors and ← 0.022 R022 discrete capacitors. DEH-P250/XM/UC http://www.xiaoyu163.com...
For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams WIRED Capacitor Connector IP-BUS REMOTE SIDE A SIDE B Chip Part P.C.Board L981 L 13942296513 R9101 R4721 CN701 u163 DETACH SENSE DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 29
3 7 63 1515 0 SIDE A IC,Q PRE OUT ANTENNA L 13942296513 u163 CN1950 FRONT DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 30
3 7 63 1515 0 TUNER AMP UNIT IC,Q L 13942296513 u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 31
3 7 63 1515 0 SIDE B L 13942296513 u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
4.3 KEYBOARD UNIT 3 7 63 1515 0 SIDE A KEYBOARD UNIT SIDE B KEYBOARD UNIT IC,Q IC,Q CN1951 ↓ L 13942296513 u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
4.4 CD MECHANISM MODULE 3 7 63 1515 0 SIDE A CD CORE UNIT(S10) LOADING /CARRIAGE MOTOR SPINDLE MOTOR L 13942296513 CN721 CN??? HOME PICKUP UNIT (SERVICE)(P10) u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 35
3 7 63 1515 0 SIDE B CD CORE UNIT(S10) 12EJ DSCSNS CLAMP L 13942296513 u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
• The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. • Hint Reloading the disc changes the clamp position and may decrease the "wobble". u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 43
3 7 63 1515 0 Ech → Xch 20mV/div, AC Grating waveform Fch → Ych 20mV/div, AC 0° 30° 45° 60° L 13942296513 75° 90° u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Grille Assy Fig.1 Removing the Tuner Amp Unit (Fig.2) Remove the screw. Remove the three screws. Straight the tabs at three locations indicated. Remove the screw and then remove the Tuner Amp Unit. u163 Tuner Amp Unit Fig.2 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 46
4. While releasing from the hook of the inner holder, lift the end of the feed screw. Feed Screw Caution: In assembling, move the planet gear to the load/eject position before setting the feed screw in the inner holder. u163 Inner Holder Planet Gear DEH-P250/XM/UC http://www.xiaoyu163.com...
CD : LSI reset control output u163 xstb CD LSI strobe output ASENBO IP-BUS : Slave power supply control output EMUTE E.VOL : Mute control output TEST TUNER : Signal level input STRKEY1 Steering remote controller input DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 49
PLL chip enable output Beep tone output L 13942296513 * PE5341C IC's marked by * are MOS type. Be careful in handling them because they are very liable to be damaged by electrostatic induction. Format Meaning CMOS BD4834G Vref u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 51
25,26 KDT2,3 Key data input Not used KST4 Key strobe output 29-32 Not used 33-55 SEG35-13 LCD segment output Power supply 57-64 SEG12-5 LCD segment output *PD6340A L 13942296513 TSOP4840SB1 Control Input Circuit Band Demodu- lator Pass u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 52
Output of focus drive PWM Output of tracking drive PWM Output of tracking drive PWM u163 Output of thread drive PWM Output of thread drive PWM Output of spindle drive PWM Output of spindle drive PWM DGND Ground for digital circuits DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 53
Connected to the capacitor for output of REFOUT Reversal input of FE L 13942296513 Output of FE ADCIN TEST Reversal input of TE Output of TE AGND Ground for the analog system PWMSW Servo PWM mode switching * UPD63712GC u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 54
Input pin for preamplifier for thread OPOUT3 CH3 preamplifier output pin OPIN3(-) Input pin for inverting input for CH3 preamplifier OPIN3(+) Input pin for non-inverting input for CH3 preamplifier L 13942296513 PREVCC PreVcc BA5996FP NJM2391DL1-33 VREF Over current Thermal protector Shutdown u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
Page 55
Ground of audio block 23 L ch O L channel output FM stereo “L-ch” signal output or AM audio output 24 R ch O R channel output FM stereo “R-ch” signal output or AM audio output u163 DEH-P250/XM/UC http://www.xiaoyu163.com...
In case of the above signal, the communication with Grille microcomputer may fail. Source keys If the time interval is not 300msec, the oscillator operative may be defective. Source ON SYSPW←H u163 Pin 21 Completes power-on operation. (After that, proceed to each source operation) DEH-P250/XM/UC http://www.xiaoyu163.com...
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 L 13942296513 u163 DEH-P250/XM/UC http://www.xiaoyu163.com...