Weber 300 Owner's Manual

Weber 300 Owner's Manual

Lpg gas grill
Hide thumbs Also See for 300:

Advertisement

Quick Links

GAS BARBECUE
LPG Gas Grill Owner's Guide
Assembly - Pg. 9
YOu muSt READ thIS OWNERS GuIDE
bEfORE OPERAtING YOuR GAS bARbECuE.
m DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
m WARNING:
1. Do not store spare LPG cylinder within
10 feet (3m) of this appliance.
2. Do not store or use petrol or other
flammable liquids or vapors within
25 feet (8m) of this appliance.
PLACE STICKER HERE
Register your barbecue online at www.weber.com
m WARNING: follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOtICE tO INStALLER: these instructions
must be left with the owner and the owner
should keep them for future use.
thIS GAS APPLIANCE IS DESIGNED fOR
OutDOOR uSE ONLY.
m WARNING: Do not try to light this
appliance without reading the Ignition
Instructions section of this manual.
#59752
®
59752 07/31/12 LP
AU - AUSTRALIA
NZ - NEW ZEALAND

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 300 and is the answer not in the manual?

Questions and answers

Summary of Contents for Weber 300

  • Page 1 GAS BARBECUE LPG Gas Grill Owner’s Guide Assembly - Pg. 9 #59752 PLACE STICKER HERE Register your barbecue online at www.weber.com ® YOu muSt READ thIS OWNERS GuIDE m WARNING: follow all leak-check bEfORE OPERAtING YOuR GAS bARbECuE. procedures carefully in this manual prior to barbecue operation.
  • Page 2: Warnings

    Although your LPG cylinder may appear to be empty, attempting to relight, using the lighting instructions. gas may still be present, and the LPG cylinder should be m Do not use charcoal or lava rock in your Weber ® transported and stored accordingly.
  • Page 3: Table Of Contents

    CLEANING ............30 WEBER SPIDER/INSECT SCREENS .
  • Page 4: Exploded View - Q300

    EXPLoDED VIEW - Q300 Q300 Q300_AU_071312...
  • Page 5: Exploded View List - Q300

    25. Right Leg Outside burner tube 16. tank Skirt 26. Wheel Cover Inside burner tube tank base 27. hubcap Electrode Assembly 18. bottom Rack 28. Wheel front Cradle frame 19. Lid 29. Axle 10. Igniter 20. Rear Cradle frame WWW.WEBER.Com ®...
  • Page 6: Exploded View - Q320

    EXPLoDED VIEW - Q320 Q320 Q320_AU_071312...
  • Page 7: Exploded View List - Q320

    Outside burner tube 16. tank Skirt 26. Wheel Cover Inside burner tube tank base 27. hubcap Electrode Assembly 18. bottom Rack 28. Wheel front Cradle frame 19. Lid 29. Axle 10. Ignition button/ Ignition module 20. Rear Cradle frame WWW.WEBER.Com ®...
  • Page 8: Parts List

    PARTS LIST tOOLS NEEDED: WOOD bLOCK ¼-20 x 1¼” ¼-20 x 1" ¼-20 x 2¼" tRuSS hEAD tRuSS hEAD PAN hEAD SCREW PhILLIPS SCREW PhILLIPS SCREW (bLACK) (bLACK) Q320...
  • Page 9: Assembly

    ASSEmBLY WWW.WEBER.Com ®...
  • Page 10 ASSEmBLY m Place wheel frame on the right.
  • Page 11 ASSEmBLY WWW.WEBER.Com ®...
  • Page 12 ASSEmBLY...
  • Page 13 ASSEmBLY WWW.WEBER.Com ®...
  • Page 14 ASSEmBLY...
  • Page 15 ASSEmBLY WWW.WEBER.Com ®...
  • Page 16 ASSEmBLY A) Uncoil the hose and regulator of the Weber ® ® 300/320. B) Remove leg screw and secure hose and retention clip (1) to cart leg. m WARNING: the hose must be secured to the cart leg by the hose retention clip. failure to do so...
  • Page 17 ASSEmBLY WWW.WEBER.Com ®...
  • Page 18 ASSEmBLY...
  • Page 19 ASSEmBLY 17 Q320 WWW.WEBER.Com ®...
  • Page 20: Warranty

    Customer Service Representative in your area using the contact information on our website. If Weber confirms the defect and approves the claim, Weber will elect to replace such parts without charge. If you are required to return defective parts, transportation charges must be prepaid.
  • Page 21: General Instructions

    The Weber ® gas barbecue is portable so you can easily change its location in your yard or on your patio. Portability means you can take your Weber gas barbecue with, if ® you move. Propane gas supply is easy to use and gives you more cooking control than charcoal fuel.
  • Page 22: Gas Instructions

    GAS INSTRUCTIoNS PuRChASE A fuLL CYLINDER Of GAS fROm YOuR GAS DEALER The LPG cylinder must always be installed, transported and stored in an upright position. Never allow the cylinder to drop or be handled carelessly. Never store cylinder where temperatures can exceed 51° C (too hot to hold by hand). For example, do not leave the cylinder in your car on hot days.
  • Page 23: Connecting The Lpg Cylinder

    You will need: LPG cylinder, a soap and water solution and a rag or brush to apply it. A) Connect the hose (2) and regulator (3). Turn the LPG cylinder so the opening of the valve is either to the front, side or rear of the Weber gas barbecue.
  • Page 24: Refilling The Lpg Cylinder

    If leak does not stop, contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com . Do ®...
  • Page 25: Before Using The Barbecue

    WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber authorized replacement hose. Contact ®...
  • Page 26: Ignition & Usage

    IGNITIoN & USAGE IGNItION m DANGER failure to open the lid while igniting the barbecue’s burners, or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up which can cause serious bodily injury or death. Note - The ignition system ignites the burners with a spark from the igniter electrode inside the ignition chamber.
  • Page 27: Manual Ignition

    G) After the outside burner is lit you can turn on the inside burner (7). The inside burner is ignited by the outside burner. ◆ tO EXtINGuISh Push in and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source. ◆ StARt/hI mEDIum WWW.WEBER.Com ®...
  • Page 28: Grilling Tips & Helpful Hints

    Small whole chicken Don’t forget to regularly brush off your cooking grate and clean out the drip pan under the barbecue. for more barbecuing tips and recipes, visit www.weber.com ® ◆ mEDIum...
  • Page 29: Troubleshooting

    IS NOt A DEfECt. If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® WWW.WEBER.Com...
  • Page 30: Maintenance

    Catch pan - Check the catch pan for grease build-up each time you use your grill. m DANGER Remove excess grease with a plastic scraper. Wash the catch pan with warm, soapy water and rinse with water. Disposable Weber ® drip pans are available that fit the catch failure to correct the above mentioned symptoms may result pan.
  • Page 31: Burner Tube Cleaning Or Replacement

    CLEANING OR REPLACEmENt You will need a flathead screwdriver. A) Your Weber ® gas barbecue must be OFF and cool. B) Turn gas OFF at source. C) Open lid and remove the cooking grates. burner tube Removal A) Remove the 1/4 x 20 inch screw that holds the burner tube to the cookbox (1).
  • Page 32: Push-Button Ignition System Operations (Q300)

    • Make sure the Electronic Ignition button is working by listening and looking for sparks at burner. If the Electronic Ignition System still fails to light, contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® ◆...
  • Page 33: Annual Maintenance

    Insect screen and burner is clean, replace the burner. If the Spider/Insect screen becomes damaged or cannot be cleaned, contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® main burner flame Pattern...
  • Page 34 mEmo...
  • Page 35 WWW.WEBER.Com ®...
  • Page 36 AttENtION: this product has been safety tested and is only certified for use in a specific country. Refer to country designation located on outer carton. These parts may be gas carrying or gas burning components. Please contact Weber-Stephen Products LLC Customer Service Department for genuine Weber-Stephen Products LLC replacement part(s) information.

This manual is also suitable for:

320

Table of Contents