Table Of Contents - TOTALINE TOC009DS Installation Manual

READ BEFORE INSTALLATION
This product has been det ermined t o be in compliance wit h t he Low Volt age Direct ive ( 2006/95/EC),
and t he Elect romagnet ic Compat ibilit y Direct ive ( 2004/108/EC) of t he European Union.
(Waste Electrical & Electronic Equipment)
(When using this air conditioner in European countries, the following guidance must be followed)
- This marking shown on the product or its literature, indicates that waste electrical and eletrical equipment (WEEE as in
directive 2002/96/EC) should not be mixed with general household waste.
It is prohibited to dispose of this appliance in domestic household waste.
For disposal, there are several possibilities:
1. The municipality has established collection systems, where electronic waste can be disposed of at least free of charge to
the user.
2. When buying a new product, the retailer will take back the old product at least free of charge.
3. The manufacture will take back the old appliance for disposal at least free of charge to the user.
4. As old products contain valuable resources, they can be sold to scrap metal dealers.
Wild disposal of waste in forests and landscapes endangers your health when hazardous substances leak into the
ground-water and find their way into the food chain.
Indoor Unit Dimension(IDU)
T
OC009DS 730x192x291
T
OC012DS 812x192x300
T
OC018DS 973x218x319
T
OC024DS 1082x225x338
This product contains fluorinated gases covered by the Kyoto Protocol
Chemical Name of Gas
Global Warming Potential (GWP) of Gas
CAUTION
1. Paste the enclosed refrigerant label adjacent to the charging
and/or recovering location.
2. Clearly write the charged refrigerant quantity on the refrigerant
label using indelible ink.
3. Prevent emission of the contained fluorinated gas. Ensure
that the fluorinated gas is never vented to the atmosphere
during installation, service or disposal. When any leakage
of the contained fluorinated gas is detected, the leak shall
be stopped and repaired as soon as possible.
01
The manufacturer reserves the right to change any product specifications without notice.
Correct Disposal of This Product
Outdoor Unit Dimension(ODU) Rated Voltage & Hz
T
T O U009DS 700x275x550
T
T O U012DS 770x300x555
220-240V~, 50/60Hz
T
T O U018DS 800x333x554
T
T O U024DS
845x363x702
R410A
2088
4. Only qualified service personnel are allowed to access and
service this product.
5. Any handling of the fluorinated gas in this product, such as
when moving the product or recharging the gas, shall comply
under (EC) Regulation No. 842/2006 on certain fluorinated
greenhouse gases and any relevant local legislation.
6. If the system has a leak-detection system installed, it must be
checked for leaks at least every 12 months
7. When the unit is checked for leaks, proper record-keeping of all
checks is strongly recommended.
CONTENTS
1. PREPARING FOR INSTALLATION ····································································
1.1 Safety Percautions
·······················································································
1.2 Accessories ·······························································································
1.3 Installation Site Choosing ···············································································
2. INDOOR UNIT INSTALLATION ·········································································
2.1 Indoor Unit Mounting Plate
··············································································
2.2 Installation Process ······················································································
3. OUTDOOR UNIT INSTALLATION ····································································
3.1 Outdoor Unit Mounting Dimension ····································································
·································································
3.2 Space Requirement For Outdoor Unit
··············································································
3.3 Outdoor Wire Connection
···············································································
3.4 Install The Outdoor Unit
3.5 Install The Drain Pipe For Outdoor Unit ·······························································
4. REFRIGERANT PIPING WORK ········································································
4.1 Flaring
····································································································
4.2 Piping Work
·······························································································
4.3 Refrigerant Pipe ·························································································
··························································································
4.4 Air Evacuation
····························································································
4.5 Leakage Test
5. WIRING ········································································································
6. FINAL CHECK AND TRAIL OPERATION ··························································
6.1 Final Check List ··························································································
6.2 Manual Operation ························································································
6.3 Trail Operation ····························································································
3
3
4
5
6
6
6
8
8
8
9
9
9
10
10
10
11
11
11
12
13
13
13
13
02