Page 1
Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
10.2 10.4 10.5 11.4 50PFL3008T/12 4.3.2 7.1.3 10.2 10.4 10.5 11.4 Note: The given Model Numbers are subject to change. Directions for Use Directions for use can be downloaded from the following websites: http://www.philips.com/support http://www.p4c.philips.com back to 2013-Jul-19 div. table...
Page 3
Technical Specs, Diversity, and Connections VES.2.2E LA EN 3 Connections 5 Optional 19420_100_130312.eps 130326 Figure 2-1 Connection overview (..H/12 series) SAT. 19421_001_130514.eps 130514 Figure 2-2 Connection overview (..K/12 series and ..T/12 series) back to 2013-Jul-19 div. table...
Page 4
Technical Specs, Diversity, and Connections EN 4 VES.2.2E LA Note: The following connector colour abbreviations are used 8 - HDMI 1: Digital Video, Digital Audio - In (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow. 10000_017_090121.eps 2.3.1 Side Connections...
Page 5
Technical Specs, Diversity, and Connections VES.2.2E LA EN 5 - Function Select 0 - 2 V: INT 16 - Status/FBL 0 - 0.4 V: INT 1 - 3 V: EXT / 75 4.5 - 7 V: EXT 16:9 9.5 - 12 V: EXT 4:3 17 - Ground Video - Ground Green 18 - Ground FBL...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 7
Precautions, Notes, and Abbreviation List VES.2.2E LA EN 7 result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 8
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 9
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions EN 10 VES.2.2E LA 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly Cable Dressing 19420_101_130312.eps 130312...
Page 11
Mechanical Instructions VES.2.2E LA EN 11 19421_101_130429.eps 130507 Figure 4-2 Cable dressing (39" 3000 series) 19421_102_130429.eps 130507 Figure 4-3 Cable dressing (40" 3000 series) back to 2013-Jul-19 div. table...
Page 12
Mechanical Instructions EN 12 VES.2.2E LA 19421_103_130429.eps 130429 Figure 4-4 Cable dressing (50" 3000 series) Service Positions 3. Remove the screw [1] that secures the power cable. For easy servicing of a TV set, the set should be put face down 4.
Page 13
Mechanical Instructions VES.2.2E LA EN 13 4 × 12 M4 × 12 M4 × 6 3 × 12 19420_201_130312.eps 130312 Figure 4-6 Rear cover removal 4.3.3 Speakers 6. Take out the SSB together with its shielding. 7. Remove the screw near the L/R audio connectors. 8.
Page 14
Mechanical Instructions EN 14 VES.2.2E LA 4.3.7 LCD Panel 1. Remove the SSB as described earlier. 2. Remove the PSU as described earlier. 3. Remove the stand as described earlier. 4. Release the IR/LED board cable from its clamps and unplug the IR/LED board cable.
Service Modes and Fault Finding VES.2.2E LA EN 15 5. Service Modes and Fault Finding Index of this chapter: versions). Numbering will go from 00 - 99. 5.1 Test Points - If the sub version number changes, the new version 5.2 Service Modes number is written in the NVM.
Page 16
It is possible for the user to upgrade the main software via the USB port. This allows replacement of a software image in a stand alone set. A description on how to upgrade the main software can be found in the DFU or on the Philips website. 5.3.2 Introduction Philips continuously tries to improve its products, and it’s...
Page 17
Service Modes and Fault Finding VES.2.2E LA EN 17 Note: 5.4.3 No Picture via HDMI input • Do not remove the USB flash drive during the software update. Check if HDCP key is valid. This can be done in CSM. •...
Alignments EN 18 VES.2.2E LA 6. Alignments Index of this chapter: 6.1 General Alignment Conditions 6.2 Hardware Alignments 6.3 Software Alignments 6.4 White Point Alignments General Alignment Conditions Perform all electrical adjustments under the following conditions: , 50/ 60 3 Hz. •...
7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction VES2.2E LA main board is driven by MStar SOC. This IC is a 7.2 Power Supply single chip IDTV solution that supports channel decoding, 7.3 Power Management MPEG decoding, and media-centre functionality enabled by a 7.4 Circuit Description...
Page 20
Circuit Descriptions EN 20 VES.2.2E LA 7.1.2 SSB Cell Layout (..H/12 series) DC-DC CI Socket NAND Flash LVDS Sockets Serial Flash Main IC Supplies Tuner Supplies HDMI Side Sockets Tuner Audio Amp 19420_204_130315.eps 130315 Figure 7-1 SSB layout cells (top view) back to 2013-Jul-19 div.
Page 21
Circuit Descriptions VES.2.2E LA EN 21 7.1.3 SSB Cell Layout (..K/12 series and ..T/12 series) DC-DC Nand Flash LVDS socket Tuner supplies Main IC Satellite Tuner HDMI Side Sockets Tuner Audio Amplifier 3-way switch 19421_200_130507.eps 130507 Figure 7-2 SSB layout cells (top view) back to 2013-Jul-19 div.
This part is available in the regular market. The SOC has two input port for USB, therefore air mouse, Consult the Philips Service web portal for the order codes of the internal wi-fi interface and USB2 are combined with HUB. This boards.
IC Data Sheets VES.2.2E LA EN 23 8. IC Data Sheets This chapter shows the internal block diagrams and pin electrical diagrams (with the exception of “memory” and “logic” configurations of ICs that are drawn as “black boxes” in the ICs).
IC Data Sheets EN 24 VES.2.2E LA Diagram 10-3-4 B04, Tuner, USB, WiFi, TPS2553-1 (IC U2) Block diagram Reverse Voltage Comparator Current Sense Charge Pump Current Driver Limit FAULT (Note A) UVLO Thermal Sense ILIM Pinning information TPS2552/TPS2553 (TOP VIEW) ILIM FAULT 19421_302_130516.eps...
Page 25
IC Data Sheets VES.2.2E LA EN 25 Diagram 10-3-5 B05, Power, APL5910 (IC U5) Block diagram TPS65251 AGND ROSC INTERNAL SYNC VOLTAGE RAILS 12V DC Supply BST1 Vout BUCK1 VIN1 BUCK1 from enable logic COMP1 Rlim1 BST2 Vout BUCK2 VIN2 BUCK2 from enable logic COMP2...
Page 26
IC Data Sheets EN 26 VES.2.2E LA Diagram 10-3-5 B05, Power, TPS54528 (IC U9) Block diagram TPS65251 AGND ROSC INTERNAL SYNC VOLTAGE RAILS 12V DC Supply BST1 Vout BUCK1 VIN1 BUCK1 from enable logic COMP1 Rlim1 BST2 Vout BUCK2 VIN2 BUCK2 from enable logic COMP2...
Page 27
IC Data Sheets VES.2.2E LA EN 27 Diagram 10-3-5 B05, Power, TPS65251 (IC U19) Block diagram TPS65251 AGND ROSC INTERNAL SYNC VOLTAGE RAILS 12V DC Supply BST1 Vout BUCK1 VIN1 BUCK1 from enable logic COMP1 Rlim1 BST2 Vout BUCK2 VIN2 BUCK2 from enable logic COMP2...
Page 28
IC Data Sheets EN 28 VES.2.2E LA Diagram 10-3-7 B07, Audio, Headphone, TAS5719 (IC U35) Block diagram OUT_A 2 HB FET Out Serial OUT_B Order SDIN Audio Noise Port (DAP) Shaper OUT_C 2 HB FET Out OUT_D Protection Logic MCLK Control SCLK Autodetect...
Page 29
IC Data Sheets VES.2.2E LA EN 29 Diagram 10-3-7 B07, Audio, Headphone, DRV632 (IC U16) Block diagram DRV632 +INL +INR Line Line Driver –INL Driver –INR OUTL OUTR Click and Pop Short-Circuit Suppression Protection Mute Bias Circuitry Pinning information DRV632 +INR +INL –INR...
Page 30
IC Data Sheets EN 30 VES.2.2E LA Diagram 10-4-7 B07, Audio, Headphone, M88DS3002 (IC U29) Block diagram Pinning information 19421_301_130516.eps 130516 Figure 8-8 Internal block diagram and pin configuration back to 2013-Jul-19 div. table...
Block Diagrams VES2.2E LA EN 31 9. Block Diagrams Wiring diagram 3000 series 32" WIRING DIAGRAM 32" (3000 series) Board Level Repair Component Level Repair Only for authorized workshops (M2) MAIN POWER SUPPLY (M3) TV ANTENNA CVBS R/L Audio SPDF OUT...
Page 32
Block Diagrams VES2.2E LA EN 32 Wiring diagram 3000 series 39" WIRING DIAGRAM 39" (3000 series) Board Level Repair Component Level Repair Only for authorized workshops to Panel CN500 MAIN POWER SUPPLY (M3) (M2) CVBS R/L Audio TV ANTENNA SPDF OUT...
Page 33
Block Diagrams VES2.2E LA EN 33 Wiring diagram 3000 series 40" WIRING DIAGRAM 40" (3000 series) Board Level Repair Component Level Repair Only for authorized workshops to panel CN500 MAIN POWER SUPPLY (M3) (M2) Satellite * CVBS TV ANTENNA R/L Audio...
Page 34
Block Diagrams VES2.2E LA EN 34 Wiring diagram 3000 series 50" WIRING DIAGRAM 50" (3000 series) Board Level Repair Component Level Repair Only for authorized workshops MAIN POWER SUPPLY (M3) to panel (M2) Satellite * CVBS TV ANTENNA R/L Audio...
Page 35
Block Diagrams VES2.2E LA EN 35 Block diagram 3000 series MB95S platform 1V5_VCC 2x6W POWER DDR3 RAM (64Mx16bit or BLOCK 128Mx16bit) (1600 MT/s) 3V3_VCC 1V8_VCC_TUNER 24V_VCC LM1117 TAS5719 Audio Amp (6W) & 5V_VCC 3V3_VCC_TUNER LM1117 2Vrms Amp 1V2_VCC 12V_VCC TPS6251...
Page 36
Block Diagrams VES2.2E LA EN 36 Block diagram 3000 series MB95 platform 1V5_VC C 1V5_VC C 2x6W or 2x8W 2x2.5W DDR 3 R AM DDR 3 RAM 24V_VCC (64Mx 16bit or (64Mx 16bit or 12V_VCC 128Mx16bit) 128Mx16bit ) 3V3_ VCC...
Circuit Diagrams and PWB Layouts VES2.2E LA EN 37 10. Circuit Diagrams and PWB Layouts 10.1 A 17ips19-5 26" to 40" LED Slim Integrated Power Supply 10-1-1 26" to 40" Slim Integrated Power Supply 2011-05-02 26" to 40" Slim Integrated...
Page 38
Circuit Diagrams and PWB Layouts VES2.2E LA EN 38 10-1-2 26" to 40" Slim Integrated Power Supply 2012-08-06 26" to 40" Slim Integrated 17IPS19-5 Power Supply 19420_501_130311.eps 130311 back to 2013-Jul-19 div. table...
Page 39
Circuit Diagrams and PWB Layouts VES2.2E LA EN 39 10-1-3 Layout top 2012-08-06 PSU Layout Top 17ips19-5 19420_502_130311.eps 130311 back to 2013-Jul-19 div. table...
Page 40
Circuit Diagrams and PWB Layouts VES2.2E LA EN 40 10-1-4 Layout bottom 2012-08-06 PSU Layout Bottom 17ips19-5 19420_503_130311.eps 130311 back to 2013-Jul-19 div. table...
Page 41
Circuit Diagrams and PWB Layouts VES2.2E LA EN 41 10.2 A 17ips20-5p 50" LED Power Supply 10-2-1 50" Power supply S119 C127 D105 D103 R110 R115 R117 R118 R131 C131 C548 +400V R126 1N4148 1N4148 C126 R124 Q101 C112 C116...
Page 43
Circuit Diagrams and PWB Layouts VES2.2E LA EN 43 10-2-3 Layout top 2012-08-06 PSU Layout Top 17ips20-5p 19421_513_130507.eps 130508 back to 2013-Jul-19 div. table...
Page 44
Circuit Diagrams and PWB Layouts VES2.2E LA EN 44 10-2-4 Layout bottom 2012-08-06 PSU Layout Bottom 17ips20-5p 19421_514_130508.eps 130508 back to 2013-Jul-19 div. table...
Styling Sheets VES2.2E LA EN 68 11. Styling Sheets 11.1 3000 series 32" 3000 series 32" Pos No. Description Remarks LCD panel SSB (Small Signal Board) PSU (Power Supply Unit) Loudspeaker IR Board Front Cabinet Back Cabinet Remote Control Not displayed...
Page 69
Styling Sheets VES2.2E LA EN 69 11.2 3000 series 39" 3000 series 39" Pos No. Description Remarks LCD panel SSB (Small Signal Board) PSU (Power Supply Unit) Loudspeaker IR Board Front Cabinet Back Cabinet Remote Control Not displayed Detachable AC Cord...
Page 70
Styling Sheets VES2.2E LA EN 70 11.3 3000 series 40" 3000 series 40" Pos No. Description Remarks LCD panel SSB (Small Signal Board) PSU (Power Supply Unit) Loudspeaker IR Board Front Cabinet Back Cabinet Remote Control Not displayed Detachable AC Cord...
Page 71
Styling Sheets VES2.2E LA EN 71 11.4 3000 series 50" 3000 series 50" Pos No. Description Remarks LCD panel SSB (Small Signal Board) PSU (Power Supply Unit) Loudspeaker IR Board Front Cabinet Back Cabinet Remote Control Not displayed Detachable AC Cord...
Page 72
Styling Sheets VES2.2E LA EN 72 back to 2013-Jul-19 div. table...