1. Manuals
  2. Brands
  3. Yamarin Cross Manuals
  4. Boat
  5. 64 Bow Rider
  6. Owner's manual

Yamarin Cross 64 Bow Rider Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Yamarin Cross 64 Bow Rider
Owner's manual

Advertisement

Table of Contents
loading

Related Manuals for Yamarin Cross 64 Bow Rider

Summary of Contents for Yamarin Cross 64 Bow Rider

  • Page 1 Yamarin Cross 64 Bow Rider Owner’s manual...
  • Page 2 Any craft, no matter how strong it may be, can be severely damaged if not used properly. Always adjust the speed and direction of the craft to prevailing weather conditions. We wish you enjoyable and relaxing times on board your Yamarin Cross boat! Konekesko Marine PO Box 145 FI-01301 VANTAA Tel.

  • Page 3: Table Of Contents

    Yamarin Cross 64 Bow Rider 3 (49) Table of contents 1 General 1.1 Declaration of conformity 2 Definitions 3 Warranty 4 Before use 4.1 Registration 4.2 Insurance 4.3 Training 5 Characteristics and use of your boat 5.1 General 5.2 Basic data 5.3 Maximum recommended number of passengers:...
  • Page 4 Yamarin Cross 64 Bow Rider 4 (49) 6 Servicing and maintenance 6.1 Washing and waxing the boat 6.2 Care instructions for seat cushions 6.3 Care instructions for the canopy 6.4 Care instructions for the windscreen 6.5 Care instructions for the stainless steel components 6.6 Care instructions for the remote control...
  • Page 5 Yamarin Cross 64 Bow Rider 5 (49) BEFORE YOU SET OFF Familiarise yourself with this owner’s manual. Always check at least the following items before leaving: Weather conditions and forecast − − − − Take the wind, waves and visibility into account. Are the design category, size and...

  • Page 6: General

    Yamarin Cross 64 Bow Rider 6 (49) General The owner’s manual will help you familiarise yourself with the properties and features of your new boat and with its care and maintenance. Separate manuals for installed equipment are attached and are referred to in many sections of the owner’s manual. You can supplement this owner’s manual by adding the manuals of devices which are installed...
  • Page 7 Yamarin Cross 64 Bow Rider 7 (49) DECLARATION OF CONFORMITY Recreational Craft Directives 94/25/EC and 2003/44/EY Manufacturer: Fenix Marin Oy Module used: B (EC Type Examination) ----------------------------------------------------------------------------------------------------------------- THIS DECLARATION IS PREPARED BY Marketer: Konekesko Oy Marine Address: Vanha Porvoontie 245...
  • Page 8 Yamarin Cross 64 Bow Rider 8 (49) Boat type: Deck: 01 sailboat 01 decked 02 inflatable 02 partly decked 03 other: motor boat/190> 03 open Hull type: Propulsion: 01 monohull 01 sails 02 multihull 02 petrol engine 03 other: 03 diesel engine...
  • Page 9 Yamarin Cross 64 Bow Rider 9 (49) Essential safety requirements in the Recreational Craft Inspection standards used Directive, by inspection group General requirements Basic information EN ISO 8666:2002 A2.1 Vessel identification ISO 10087:2006 A2.2 Builder’s plate RCD annex I, 2.2 A2.5...

  • Page 10: Definitions

    Yamarin Cross 64 Bow Rider 10 (49) 2 Definitions The warnings and cautions in this manual are defined as follows: Denotes an extreme intrinsic hazard that will result in a high probability DANGER! of death or permanent injury if proper precautions are not taken.

  • Page 11: Training

    Yamarin Cross 64 Bow Rider 11 (49) information about different insurance alternatives. Check who has insurance liability each time when having the boat lifted or transported! Training No one is a born sailor. There is plenty of boating literature available. Navigation courses are arranged by local yacht clubs or national boating associations where you can gain basic skills.

  • Page 12: Characteristics And Use Of Your Boat

    Yamarin Cross 64 Bow Rider 12 (49) Characteristics and use of your boat General The user manual is not meant to be a complete service or repair manual; it simply guides the user to use his/her boat in a proper way.
  • Page 13 Yamarin Cross 64 Bow Rider 13 (49) Model YAMARIN CROSS 64 Bow Rider Design category Overall length (swim 6.31 m ladder not included) Width 2.32 m Weight without engine, Approximately 880 kg fluids and equipment Weight on trailer with Approximately 1280 kg largest recommended Includes the boat (c.
  • Page 14 Yamarin Cross 64 Bow Rider 14 (49) Image: Boat’s water line. Water line: - at stern with a 115 HP engine 120mm up from chine 150 HP engine 130mm up from chine - at bow 400 mm down from chine along the bow...

  • Page 15: Maximum Recommended Number Of Passengers

    Yamarin Cross 64 Bow Rider 15 (49) Maximum recommended number of passengers: The maximum recommended number of passengers on board this boat is 8 persons. WARNING! Do not exceed the maximum recommended number of passengers. Regardless of the number of passengers, the total weight of people and equipment must never exceed the maximum recommended load (please refer to ‘Loading’).
  • Page 16 Yamarin Cross 64 Bow Rider 16 (49) Image: Seats on the boat. NOTE! If you load the boat from stern to bow, you will have better fuel economy.

  • Page 17: Loading

    Yamarin Cross 64 Bow Rider 17 (49) Loading The boat’s maximum permitted load is 690 kg. This load includes the following weights: a) the total weight of passengers, 600 kg (the default weight of an adult is assumed to be 75 kg and that of a child 37.5 kg);...
  • Page 18 Yamarin Cross 64 Bow Rider 18 (49) The boat is equipped with an electric bilge pump. The switch of the bilge pump is dual-action: automatic action manual action When the bilge pump is running, the switch is lit. NOTE! Always keep the switch set to automatic action.
  • Page 19 Yamarin Cross 64 Bow Rider 19 (49) transom only prevents water from entering the boat when reversing! 1. Shut-off flap 2. Drain plug 3. Open deck space shut-off valve (the rainwater drainage valves) Image: Locations of through fittings and drainage valves.

  • Page 20: Stability And Buoyancy

    Yamarin Cross 64 Bow Rider 20 (49) 5.6.2 Stability and buoyancy Please note that stability is reduced by any weight added high up. Any change in the distribution of weight on board may significantly affect the stability, trim and performance of your craft.
  • Page 21 Yamarin Cross 64 Bow Rider 21 (49) Image: Location of the fire extinguisher. Ensure that fire-fighting equipment is readily accessible even when the boat is loaded. Inform members of the crew about the location and operation of fire-fighting equipment. Remember: Never hinder access to safety equipment, for instance the switches to the electric system.

  • Page 22: Main Power Switch And Fuses

    Yamarin Cross 64 Bow Rider 22 (49) Main power switch and fuses Electric circuit fuses are located on the panel of the main power switch. Do not change the circuit breaker amperages or install any components that exceed the nominal amperage of the circuit in the electric system.

  • Page 23: Operation

    Yamarin Cross 64 Bow Rider 23 (49) All fuses on the boat are automatic circuit breakers. In the event of a fault current, the circuit breaker will trip. You can reset the circuit breaker by pushing it back in. If the circuit breaker immediately trips again, there is a short-circuit somewhere in the electrical system or in a component.

  • Page 24: Gearshift And Throttle

    Yamarin Cross 64 Bow Rider 24 (49) important that the boat will come to a halt in the event that the driver, for whatever reason, loses his/her balance and is flung from the helm. NOTE! Never take control of the boat without having attached the emergency switch to yourself.
  • Page 25 Yamarin Cross 64 Bow Rider 25 (49) (bow up), as there is a risk of sudden heeling when the propeller hits the water again after a flight in heavy waves. Likewise, do not drive at high speed with the engine completely trimmed down (bow down) since this can cause the boat to pitch unexpectedly when the bow hits the water.

  • Page 26: Starting The Engine

    Yamarin Cross 64 Bow Rider 26 (49) 5.9.5 Starting the engine 1. Switch the power on using the main power switch. 2. Lower the engine to the driving position by pressing the Power Trim button on the gear/throttle handle. 3. Check that the gear/throttle handle is in the neutral position and that the emergency switch is attached to the bottom of the remote control.

  • Page 27: Approaching And Leaving The Dock

    Yamarin Cross 64 Bow Rider 27 (49) When running at low speed, a planing boat's directional stability is poorer than at higher speeds. So be careful in narrow passages and, particularly, when meeting other boats. You must learn the rules of traffic on sea lanes and follow the international regulations on how to avoid collisions at sea, COLREG.

  • Page 28: Using The Canopy

    Yamarin Cross 64 Bow Rider 28 (49) way to depart is to first push the stern as far away from the dock as possible, and then slowly reverse away from the dock into open water. The propeller is designed to have the best grip in forward gear. Therefore, propeller performance is weaker in reverse.

  • Page 29: Proper Use - Other Recommendations And Guidelines

    Yamarin Cross 64 Bow Rider 29 (49) 5.10 Proper use – other recommendations and guidelines 5.10.1 Man overboard It is always a serious situation when someone falls overboard. Rescue procedures should be practised in advance during good weather, because it is too late for practice when someone has actually fallen into the water.

  • Page 30: Anchoring And Mooring The Boat

    Yamarin Cross 64 Bow Rider 30 (49) more residences. Docking at a private dock owned by someone else or landing on a shore where there are residences is also not allowed without permission. Please make sure to familiarise yourself with the International Convention for the Prevention of Pollution From Ships (MARPOL) and respect it to the greatest possible extent.

  • Page 31: Towing

    Yamarin Cross 64 Bow Rider 31 (49) NOTE! It is the owner’s / user’s responsibility to make sure that the boat’s mooring and anchoring equipment is suitable for the boat’s intended use. 5.10.5 Towing When towing another boat, use a floating line that is strong enough for the task. Begin towing slowly, avoid jerks, and do not overload the engine.
  • Page 32 Yamarin Cross 64 Bow Rider 32 (49) Clean the supports of sand and dirt so that they will not scratch the bottom of the boat. Double-check that the trailer is securely coupled to the trailer tow hitch! The place for lifting the boat out of the water should be sheltered, and the ramp should extend deep enough into the water.

  • Page 33: Docking

    Yamarin Cross 64 Bow Rider 33 (49) NOTE! If your boat is equipped with a Water skiing bracket (an accessory), please ensure that the engine will not tilt, with the engine casing hitting the bracket, during transport. When letting the boat down from the trailer, remember to fasten the bow rope to the boat beforehand so that you can release the cable from the trailer hook as soon as the boat is in the water.

  • Page 34: Servicing And Maintenance

    Yamarin Cross 64 Bow Rider 34 (49) When the boat is being lifted, the lines must be placed under the boat and the boat must remain horizontal during lifting. NOTE! Do not lift the boat by its bollards. DANGER! Never stand under a boat that is suspended from a crane.

  • Page 35: Washing And Waxing The Boat

    Yamarin Cross 64 Bow Rider 35 (49) Washing and waxing the boat Cleaning fibreglass surfaces Normally it is sufficient to just wash and wax the deck. Special boat cleaning agents are most suitable for the purpose. Do not use strong solvents; they can cause glossy surfaces to fade.

  • Page 36: Care Instructions For Seat Cushions

    Yamarin Cross 64 Bow Rider 36 (49) Protecting the aluminium hull When the aluminium hull is completely clean and dry, it can be protected against oxidation. Spray Star brite Aluminium Polish on the surface to be treated and spread it out with a soft, lint-free cloth.

  • Page 37: Care Instructions For The Canopy

    Yamarin Cross 64 Bow Rider 37 (49) NOTE! To keep the seat cushions in good condition over the winter, they must be stored in a dry and well-ventilated place. NOTE! Wet cushions should not be placed in storage, because they gather mould easily.

  • Page 38: Care Instructions For The Remote Control

    Yamarin Cross 64 Bow Rider 38 (49) 6.6 Care instructions for the remote control Normally, the remote control needs no other maintenance apart from greasing and calibration during winter servicing. If the remote control becomes stiff for any reason, it needs to be serviced immediately.

  • Page 39: Winter Storage

    Yamarin Cross 64 Bow Rider 39 (49) WARNING! Be careful when handling the hardening agent. If the hardening agent vessel / bottle leaks, or some agent drops onto a dirty floor or rag, there is a very high risk of the surface catching fire. Do not throw into the rubbish bin any rags or vessels containing topcoat / hardening agent mixture.

  • Page 40: Inspections Before Launching The Boat

    Yamarin Cross 64 Bow Rider 40 (49) the ropes in fresh water. Replace any worn ropes. Leave bushing valves open. Remove the drain plug for the winter. Electronic instruments are best protected against oxidation and theft by detaching them and removing them to a dry indoor environment for the winter.

  • Page 41: Lay-Out

    Yamarin Cross 64 Bow Rider 41 (49) Perform the necessary service procedures required for the engine according to the engine manual. Check the functioning of electric equipment and remove any oxidation from fuse connectors etc. Remember that petrol goes stale over time, and you must always start the engine with fresh petrol in the spring.

  • Page 42: Fuel System

    Yamarin Cross 64 Bow Rider 42 (49) 1. Trim unit (accessory) 5. Main power switch 2. Rain water drainage valve 6. Switches for trim tabs (accessory) 3. Switchboard and fuse panel 7. Fire extinguisher 4. Battery (not standard equipment) Image: General lay-out.

  • Page 43: Steering System

    If you replace any component in the steering system, please note that all components must conform to the ISO 10592 standard and carry the CE mark. Electrical system The Yamarin Cross 64 BR electrical system contains the following main components: 1. Wire harness 2. Main power switch...
  • Page 44 Yamarin Cross 64 Bow Rider 44 (49) 3. Windscreen wiper 4. 3 switches 5. 2 pcs 12V power outlets 6. Navigation lights In addition, the engine is an essential part of the boat’s electrical system; it both generates and consumes power.

  • Page 45: Wiring Diagram

    Yamarin Cross 64 Bow Rider 45 (49) Wiring diagram...
  • Page 46 Yamarin Cross 64 Bow Rider 46 (49)
  • Page 47 Yamarin Cross 64 Bow Rider 47 (49)
  • Page 48 Yamarin Cross 64 Bow Rider 48 (49)
  • Page 49 Yamarin Cross 64 Bow Rider 49 (49) Image: Wiring diagram...

Table of Contents