Volvo 2001 S60 Manual page 103

EMISSION SYSTEM MAINTENANCE
Engine
1
Fuel line filter
PCV nipple (orifice)/hoses, clean
Battery (check charge and electrolyte level)
Brakes
Inspect brake pads, replace components as necessary
2
Brake fluid level - check
Steering/suspension
3
Tires , check pressure, wear and condition
Check power steering fluid level
Body
Power antenna (clean)
Trunk/hood, hinges and latches
Cabin air filter (see page 167
1) Replace at 105,000 miles (168,000 km)
2) Brake fluid should be changed at owner request every second year or 30,000 miles (48,000 km). The fluid
should be replaced once a year or every 15,000 miles (24,000 km) when driving under extremely hard
conditions (mountain driving, etc.).
3) Rotate tires at owner request.
The following items should be checked weekly by the driver (it takes only a few minutes):
Engine oil level, brake fluid level, radiator coolant level, operation of all lights, horns, windshield wipers, tire
pressure (all five tires), windshield washer fluid level
The following should also be carried out at regular intervals:
Washing (check all drain holes), polishing, cleaning
pg. 167 Maintenance Schedule
Air cleaner
Replace the air cleaner cartridge with a new one every 30,000 miles (48,000 km). The cartridge should be replaced
more often when driving under dirty and dusty conditions. The filter cannot be cleaned and therefore should always
be replaced with a new one.
Timing belt
For proper functioning of the vehicle and its emission control systems, the timing belt must be replaced every 105,000
miles (168,000 km). Engine damage will occur if the belt fails.
Fuel filler cap, tank and lines and
connections The effectiveness of the fuel system to contain hydrocarbons is dependent largely on a leak- free system.
Check for proper sealing of the fuel filler cap which contains "O" ring type seals. NOTE: If the fuel filler cap is not
closed tightly or if the engine is running when the car is refueled, the Malfunction Indicator Lamp (" Check Engine")
may indicate a fault. However, your vehicle's performance will not be affected. Use only Volvo original or approved
fuel filler caps.
(thousand km) (12) (24) (36) (48) (60) (72) (84) (96) (108) (120) (132) (144)
)
I I I I I I
I I I I I
I I I
I I I I I I
I I I
L L L
L L
R R R
I
I I I I I
I I I I I
I I
I I I I I
I I
L L
L
R R
I
I
I
I
I
I
L
L
R