E-mail: info.us@mtssensors.com http://www.mtssensors.com http://www.mtssensors.com Mailing and shipping address Mailing and shipping address MTS Sensors Technology Corporation MTS Systems Corporation 737 Aihara-cho, Machida-shi Sensors Division Tokyo 194-0211, Japan 3001 Sheldon Drive Cary, North Carolina, 27513, USA Technical support and applications Tel.: +81-42-775-3838...
Level Plus SoClean ® ® Operation Manual 2. Terms and definitions 6A Heavy Oils FOUNDATION™ fieldbus ‘Generalized Crude Oils’, Correction of Volume to 60 °F against API An all digital, serial, two-way communications system that serves as Gravity. the base-level network in a plant or factory automation environment. Developed and administered by the fieldbus FOUNDATION™.
Page 5
Level Plus SoClean ® ® Operation Manual Strap Table A table of measurement correlating the height of a vessel to the volume Mass that is contained at that height. The transmitter can contain up to 100 The property of a body that causes it to have weight in a gravitational points.
1 to item 4 below and only in conjunction with third-party phical installation and facility. Only install equipment that complies devices and components recommended or approved by MTS Sensors. with the types of protection relevant to the applicable classes, As a prerequisite of proper and safe operation, the product requires division, zones, category, gas group, and temperature code.
Level Plus SoClean ® ® Operation Manual 145 mm MTS is the inventor and purveyor of magnetostrictive technology and has (5.7 in.) been serving the level industry for over 35 years. 114 mm 109 mm (4.5 in.) (4.3 in.) Industries Pharmaceutical »...
Level Plus SoClean ® ® Operation Manual Outer pipe configurations Internal electronics The outer pipe is constructed of a variety of configurations. The All transmitters come with two electronic components of a sensing ® SoClean is available in a sanitary pipe. For other pipe options please element and a board set.
Level Plus SoClean ® ® Operation Manual 5.5 Model number identification (Order code) a Sensor model Process connection size S SoClean ® Level Transmitter 1 in. (DN25) 2 in. (DN50) Output 2 1/2 in. (DN65) M Modbus 3 in. (DN80) 4 in.
Page 10
Level Plus SoClean ® ® Operation Manual 5.5 Model number identification (continued) Gas group Group A Group B Group C Group D None n Unit of measure M Metric - Millimeters US customary - Inches o Length (no decimal spaces) X X Rigid Pipe: 12 to 300 in (code as 01200 to 30000) X X Rigid Pipe: 305 to 7620 mm (code as 00305 to...
Level Plus SoClean ® ® Operation Manual Threaded flange mounting 6. Installation and mounting ® In some applications, the SoClean transmitter can be mounted directly to the tank or flange via a NPT or BSPP threaded fitting, 6.1 Training assuming there is a proper threaded connection available. If the float will not fit through the flange opening when the flange is removed, Installation should only be conducted by qualified service personnel there must be some alternative means to mount the float on the...
Level Plus SoClean ® ® Operation Manual Bus with spurs 7. Electrical connections The bus with spurs topology has a main trunk cable that has each device connected via its own spur at a junction box as shown in Figure 9. The 7.1 Basic information bus with spurs and tree topologies can also be used together to form a ®...
Level Plus SoClean ® ® Operation Manual 7.6 Grounding 7.4 Cable recommendations Refer to ‘Table 2’ below for general requirements of cable types for ® ® 7.6.1 Safety grounding the Level Plus SoClean analog transmitter. Warning: Cable specifications Grounding the transmitter through a threaded conduit connection does Parameter Specification not meet the requirements as a grounding of the sensor for safety.
Level Plus SoClean ® ® Operation Manual 7.7 Safety barriers Refer to Table 3 for entity parameters and Table 4 for example safety barriers Entity parameters Digital supply Ui = 28 Vdc (1 per LT) Ii = 100 mA Ci = 0.0 µF Li = O mH Pi = 700 mW Digital...
Level Plus SoClean ® ® Operation Manual 8. Commissioning 8.4.2 HART ® 1. Consult Section 4.3 before starting 2. Remove level transmitter from shipping container. 8.1 Training 3. Remove bottom fixing nut, washer, spacer, and stop collar. Commissioning should only be conducted by qualified service personnel 4.
Level Plus SoClean ® ® Operation Manual 9.4.1 General purpose applications 10. Repair 9.4.1.1 10.1 RMA policy Perform Inspection suggested in section 9.3 Important: 9.4.1.2 Contact Technical Support or Customer Service for assistance if you No additional preventative maintenance is necessary. Preventative suspect that the transmitter is not working correctly.
Level Plus SoClean ® ® Operation Manual 10.5 Setup software 10.4 Troubleshooting MTS offers Setup Software that is shipped with the level transmitter and is also available for download from www.mtssensors.com. The Setup Symptom Possible cause Action 10.4 Troubleshooting Software is to be used for installation, commissioning, and troubleshoo- No power Check voltage at transmitter ting.
Level Plus SoClean ® ® Operation Manual 12.2 Certificates 12.3.2 Labels (cont‘d.) USE MTS LOGO Downloadable copies of all certificates are located at 8 POINT TEXT www.mtssensors.com and can be downloaded on the product specific ARTWORK SIZE landing page. If there is any difficulty in obtaining the certificates 10 POINT SIZE from the web contact MTS Technical Support and they will be sent electronically.
Level Plus SoClean ® ® USE MTS LOGO Operation Manual 8 POINT TEXT R3.3 ARTWORK SIZE 10 POINT SIZE 12.4 FMC (CEC) ® Level Plus Transmitter 12.4.1 Special conditions of safe use 4.5 POINT TEXT SIZE The apparatus enclosure contains aluminum and is considered to MTS Systems Corporation constitute a potential risk of ignition by impact or friction.
Level Plus SoClean ® ® Operation Manual USE MTS LOGO 8 POINT TEXT ARTWORK SIZE 12.5 ATEX and IECEx 10 POINT SIZE ® Level Plus Transmitter 12.5.1 Special conditions of safe use 4.5 POINT TEXT SIZE The apparatus enclosure contains aluminum and is considered to MTS Systems Corporation constitute a potential risk of ignition by impact or friction.
Level Plus SoClean ® ® Operation Manual 12.5.3 EC Declaration of Conformity EC Declaration of Conformity EC14.012B EG-Konformitätserklärung Déclaration CE de Conformité MTS Systems Corporation, Sensors Division, 3001 Sheldon Drive, Cary NC 27513, USA declares as manufacturer in sole responsibility that the products erklärt als Hersteller in alleiniger Verantwortung, dass die Produkte déclare en qualité...
Page 35
MTS, Temposonics and Level Plus are registered trademarks of MTS Systems Corporation MTS Systems Corporation MTS Sensor Technologie in the United States; MTS SENSORS and the MTS SENSORS logo are trademarks of MTS Sensors Division GmbH & Co. KG Systems Corporation within the United States. These trademarks may be protected in other 3001 Sheldon Drive Auf dem Schüffel 9...
Need help?
Do you have a question about the Level Plus SoCLEAN and is the answer not in the manual?
Questions and answers