Page 1: Table Of Contents
TECH TIP HKTT2003-01........33 LEAKAGE TESTING....………..…....4 CIRCUIT DESCRIPTION........34 DPR1005 SPECIFICATIONS..………. …..5 D2 GR70/GR120 POWER MODULE………..35 DPR2005 SPECIFICATIONS..… ………...6 DPR1005 MECHANICAL PARTS LIST....51 FRONT PANEL CONTROLS..…..……...7 DPR1005 ELECTRICAL PARTS LIST....52 REAR PANEL CONNECTIONS..…….…..10 DPR2005 MECHANICAL PARTS LIST………..63 MAIN REMOTE CONTROL FUNCTIONS……….13 DPR2005 ELECTRICAL PARTS LIST....64 SMPS (Power Supply) Electrical Parts List……..75...
Page 2: Notices - Please Read First
Front-panel digital coaxial/optical jacks may be used as either Inputs or Outputs. Those same jacks on the 1005 are for Inputs only; therefore there is also a missing indicator light for this function. For an accurate explanation of these jacks, refer to the DPR1005 owner’s manual.
Page 3: Electrostatically Sensitive Devices
PR1005/DPR2005 harman/kardon Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field effect transistors and semiconductor "chip" components. The following techniques should be used to help reduce the incidence of component damage caused by static electricity.
Page 4: Leakage Testing
PR1005/DPR2005 harman/kardon Before returning the unit to the user, perform the following safety checks : 1. Inspect all lead dress to make certain that leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the unit.
Page 5: Dpr1005 Specifications
All features and specifications are subject to change without notice. Distortion Mono/Stereo 0.2/0.3% Stereo Separation 40dB @ 1kHz Harman Kardon, Power for the Digital Revolution and Logic 7 are registered trademarks of Selectivity ±400kHz, 70dB Harman International Industries, Incorporated. Image Rejection 80dB is a trademark of Harman International Industries, Incorporated (patent no.
Page 6: Dpr2005 Specifications
All features and specifications are subject to change without notice. Distortion Mono/Stereo 0.2/0.3% Stereo Separation 40dB @ 1kHz Harman Kardon, Power for the Digital Revolution and Logic 7 are registered trademarks of Selectivity ±400kHz, 70dB Harman International Industries, Incorporated. Image Rejection 80dB is a trademark of Harman International Industries, Incorporated (patent no.
Page 7: Front Panel Controls
PR1005/DPR2005 harman/kardon FRONT-PANEL CONTROLS FRONT-PANEL CONTROLS & NOTE: To make it easier to follow the instructions that refer to this illustration, a larger copy may be downloaded from the Product Support section for this product at www.harmankardon.com. The following controls and indicators are available on the DPR 2005’s front panel: 1 Standby/On Indicator 8 Input Source Selector % Speaker/Channel Input Indicators...
Page 8 PR1005/DPR2005 harman/kardon FRONT-PANEL CONTROLS to select a category such as Dolby or Logic 7, and Stereo mode. (See page 35 for more information on frequency and preset number, if any. then press this button to see the specific mode choices using the tuner.) &...
Page 9 PR1005/DPR2005 harman/kardon FRONT-PANEL CONTROLS H I J NOTE: To make it easier to follow the instructions that refer to this illustration, a larger copy may be downloaded from the Product Support section for this product at www.harmankardon.com. The following controls and jacks are located behind the front-panel door. To open the door, press the center of the door and gently swing it down towards you. A Main Power Switch E Digital Input Selector I Input/Output Indicators...
Page 10: Rear Panel Connections
PR1005/DPR2005 harman/kardon REAR-PANEL CONNECTIONS REAR-PANEL CONNECTIONS ¡ £ ∞ ¶ ª ⁄ ‹ ﬁ ‡ · ™ ¢ § ‚ › ﬂ ° • NOTE: To make it easier to follow the instructions that refer to this illustration, a larger copy may be downloaded from the Product Support section for this product at www.harmankardon.com.
Page 11 PR1005/DPR2005 harman/kardon REAR-PANEL CONNECTIONS ¡ Video 4 Inputs: Connect the left/right analog ﬁ 8-Channel Direct Inputs: These jacks are used The DPR 2005’s remote control has a VCR as the default for this input, but you may connect any video audio and composite or S-Video jacks of a video for connection to source devices such as DVD-Audio source such as a VCR, HDTV or cable set-top box,...
Page 12 Connect this jack to the “IR IN” jack on use, the brown and black terminals are the surround Harman Kardon (or other compatible) equipment. back left channel positive (+) and negative (–) con- nections and the tan and black terminals are the sur- A-BUS Connector: Connect this jack to an optional round back right positive (+) and negative (–) termi-...
Page 13: Main Remote Control Functions
PR1005/DPR2005 harman/kardon MAIN REMOTE CONTROL FUNCTIONS 0 Power Off Button 1 Power On Button 2 LCD Information Display 3 Input Selectors 4 AVR Selector 5 Test Button 6 DSP Surround Mode Selector 7 Logic 7 Mode Select Button 8 Direct Button 9 Clear Button A Numeric Keys B Tuning Mode Button...
Page 14 Logic 7 surround DPR 2005 and most Harman Kardon CD or DVD always return to full brightness when the DPR is turned modes. (See page 32 for the available Logic 7 players and cassette decks.
Page 15 Z Transport Play Buttons: These buttons have no R Macro Buttons: Press these buttons to store or Harman Kardon DVD players so that you may control direct function on the DPR 2005, but they are used recall a “Macro” , which is a preprogrammed sequence...
Page 16 PR1005/DPR2005 harman/kardon MAIN REMOTE CONTROL FUNCTIONS h 8-Channel Input Select: Press this button to then select another channel to configure. When all adjustments have been completed, press the Set select the device connected to the 8-Channel Direct Button q twice to exit the settings and return to Inputs .
Page 17: Installation And Connections
PR1005/DPR2005 harman/kardon INSTALLATION AND CONNECTIONS ohm twin-lead cable, you must use an optional round-right speakers, even if the speakers are a System Installation 300-ohm-to-75-ohm adapter to make the different distance from the DPR 2005. After unpacking the unit, locating it in a place with ade- connection.
Page 18: System And Power Connections
Component Video Inputs, make certain that the remote zone, connect the speakers for the remote the Remote IR Input jack on Harman Kardon or other audio and video inputs are properly configured in room location to the Surround Back/Multiroom the IN/OUT SETUP menu, as described compatible equipment.
Page 19: Installation/Connections
Product Support area of the Multiroom IR Input on the DPR 2005 and use Harman Kardon Web site at harmankardon.com. the Zone II remote to control the room volume. Alter- The physical connection to the DPR 2005’s RS-232...
Page 20: Operation
PR1005/DPR2005 harman/kardon OPERATION the Lower Display Line & . When the programmed Basic Operation The 6 CH DVD AUDIO input should be used when the SBR and SBL inputs are not sleep time has elapsed, the unit will turn off. Once you have completed the initial setup and configu- in use.
Page 21: Surround Mode Selection
PR1005/DPR2005 harman/kardon OPERATION Headphone Jack G behind the door @ on the To select a surround mode using the remote, press Dolby Digital the button for the surround mode group that includes Dolby Digital is a standard part of DVD, and is available front panel.
Page 22 PR1005/DPR2005 harman/kardon OPERATION Selecting a Digital Source The first number in the display message indicates how It is always a good idea to check the channel data to To utilize either digital mode, you must have properly many discrete front-channel signals are present. make certain that it matches the audio logo informa- connected a digital source to the DPR 2005.
Page 23 PR1005/DPR2005 harman/kardon OPERATION Display Line & will indicate that an MP3 bitstream an HDCD-encoded disc is playing and the CD available in 5.1 audio. The DPR 2005 will automatically player is connected using a digital connection, the sense changes to the bitstream and channel count is present, and the audio will begin playing.
Page 24 Then: 1. Press the AM/FM Button on the remote to the DPR 2005 offers Harman Kardon’s exclusive con- select the tuner as an input. The tuner may be figurable front-panel output-jack feature. For easy con- 1.
Page 25: Output Level Trim Adjustment
PR1005/DPR2005 harman/kardon OPERATION 4. Press the Set Button q and then press the Repeat the procedure as needed until all channels page 37, or you may control the brightness directly Navigation Button o so that the word requiring adjustment have been set. When all adjust- from the remote.
Page 26: Troubleshooting Guide
• Amplifier is in protection mode • Contact your local Harman Kardon service center due to internal problems No sound from surround or • Incorrect surround mode • Select a mode other than Stereo center speakers •...
Page 27: Unit Exploded Views
PR1005/DPR2005 harman/kardon...
Page 28 PR1005/DPR2005 harman/kardon...
Page 29: Exploded View Parts List
DPR1005/DPR2005 harman/kardon DPR1005/2005 Exploded View Parts List See Drawing Page 1 Ref # Part # Description H01-ZMC12S20A00-2 AL BADGE HARMAN/KARDON SILVER H01-ZMD03S00300-8 AL PANEL DOOR H01-ZVD03DWT434-7 TAPE AL PANEL DOOR H01-ZMD03S00200-6 AL DOOR H01-ZMD03S05A00-8 BKT MAGNET LEFT H01-ZPD0320GABK-8 DOOR HINGE-LEFT...
Page 30 DPR1005/DPR2005 harman/kardon Ref # Part # Description H01-ZMD04HS0400 HEATSINK AMP D2-GR00707-111 DPR1005 ASS'Y AMP MODULE GR0070-7 70W DR-GR01207-111 DPR2005 ASS'Y AMP MODULE GR0120-7 120W H01-ZMD03S21A00-0 BKT SHIELD AMP H01-ZMC12S19A00-2 BKT AC INLET H01-SOXA27014NN-9 JACK A/C INLET 7014-NGP AC05-4S020A H01-SOPA21275BK-3 JACK AC OUTLET 2P 110V FE 12.75MM 2 BK 0 0 A204D0043P...
Page 32: Bulletin Hk2005-03
DPR1005/2005 harman/kardon harman/kardon Service Bulletin Service bulletin # HK2005-03 January 2005 Warranty labor rate: Does Not Apply To: All harman/kardon Service Centers Model: DPR2005 Subject: Noise and Software Upgrade In the event you receive a DPR2005 with the complaint: “there is noise in the right front channel when using the Speaker Optimizer function in either the 4 or 6 ohm impedance choice* ”...
Page 33: Tech Tip Hktt2003-01
Front PCB D709 and 1N4148 diode #2058322101 * After approximately two weeks of being disconnected from AC supply, even a normally functioning receiver may lose any programmed settings and switch to default settings. (Four weeks for the DPR1005 & 2005)
Page 34: Circuit Description
PR1005/DPR2005 harman/kardon CIRCUIT DESCRIPTION Digital Out U – COM 8CH DVD In 8MB Flash ROM, 16MB SDRAM Coax Digital In Coax Analog In Speaker out Pre out...
Page 35: D2 Gr70/Gr120 Power Module
PR1005/DPR2005 harman/kardon NOTE ON D2 POWER MODULE GR70 (DPR1005) AND GR120 (DPR2005) Description of Normal LED Operation on the D2 Power Module: If the speaker impedance is too low for the amplifier and the individual channel's output current exceeds the safe operating point, the channel will shut down on current peaks and the LED will flicker RED.
Page 36 PR1005/DPR2005 harman/kardon GR70 (DPR1005) DATA SHEETS Complete Class-D Amplifier Module • Dynamic range compression and output limiting • Standard 2-wire serial interface controlled via micro • Digital switching controller, driver & MOSFET output controller or remote PC GUI stage, output filter stage •...
Page 37: Specifications
PR1005/DPR2005 harman/kardon SPECIFICATIONS CONSUMER ABSOLUTE MAXIMUM RATINGS Operation at or beyond the Absolute Maximum Ratings may result in permanent damage. Normal operation outside of the limits defined in this specification is not implied. Parameter Condition Unit High Voltage Supply (HV) +38V DC Supply Low Voltage Supply (LV) +12V DC Supply...
Page 38 PR1005/DPR2005 harman/kardon PER FORMANCE CHARACTERISTICS Resistance load = 8Ω, HV=38V, LV=12V, SV=7.5V CONSUMER Specification Condition Unit Output Power All channels driven, FTC Frequency Response 20 Hz to 24 kHz, at 1W output power -0.5 Dynamic Range -60 dB input @ 1kHz 20 Hz to 24 kHz, at 1W output power, Output Distortion (THD+N) 0.12...
Page 39 PR1005/DPR2005 harman/kardon SWITCHING CHARACTERISTICS - SERIAL AUDIO PORT = 25°C, HV=38V, LV=12V, SV=7.5V, Ground = 0V CONSUMER Symbol Description Unit SCLK SCLK frequency 12.5 SCLK SCLK pulse width (high and low LRCLK LRCLK setup to SCLK rising LRCLK LRCLK hold from SCLK rising SDI setup to SCLK rising SDI hold from SCLK rising SDO1-4 delay from SCLK falling...
Page 40 PR1005/DPR2005 harman/kardon SWITCHING CHARACTERISTICS - CONTROL PORT = 25°C, HV=38V, LV=12V, SV=7.5V, Ground = 0V CONSUMER Symbol Description Unit fSCL SCL frequency Bus free time between transmissions SCL clock low SCL clock high Setup time for a (repeated) Start Start condition Hold time SDA hold from SCL falling (see note) SDA setup time to SCL rising SDA delay time from SCL falling...
Page 41 PR1005/DPR2005 harman/kardon PER FORMANCE PLOTS The following graphs show the amplifier’s performance. All inputs are driven with the same input signal, all outputs are mapped to CONSUMER their respective input with unit gain. The output channels are tested one at a time and only the output channel being measured has a load.
Page 42 PR1005/DPR2005 harman/kardon 3.7.3 THD+N VS. OUTPUT POWER (8Ω LOAD) Conditions: Typical supplies, Room temperature, 1kHz digital input CONSUMER 0.48 0.46 0.44 0.42 0.38 0.36 0.34 0.32 0.28 0.26 0.24 0.22 0.18 0.16 0.14 0.12 0.08 0.06 0.04 0.02 100m 200m 500m FIGURE 5: THD+N vs.
Page 43: Top View
PR1005/DPR2005 harman/kardon MODULE PINOUT CONSUMER GR70 SCLKO SDO1 SDO2 SDO3 SDO4 LRCLKO CH1_OUT+ CH1_OUT- CH2_OUT+ CH2_OUT- MCLK CH3_OUT+ DGND CH3_OUT- SCLK LRCLK CH4_OUT+ DGND CH4_OUT- SDI1 SDI2 +40VDC SDI3 SDI4 +40VDC DGND +40VDC Z2_MCLK Z2_SCLK +40VDC Z2_LRCLK PWR_GND Z2_SDI PWR_GND PWR_GND /PWRDWN /RESET...
Page 44 PR1005/DPR2005 harman/kardon PIN DESCRIPTIONS CONSUMER Pin # Pin Name Description SCLKO Output Shift Clock SDO1 Channel 1,2 I S Output Data SDO2 Channel 3,4 I S Output Data SDO3 Channel 5,6 I S Output Data SDO4 Channel 7,8 I S Output Data LRCLKO Output Left / Right Clock MCLK...
Page 45 PR1005/DPR2005 harman/kardon Pin # Pin Name Description CONSUMER CH2- Channel 2 Minus Speaker Output CH2+ Channel 2 Plus Speaker Output CH1- Channel 1 Minus Speaker Output CH1+ Channel 1 Plus Speaker Output TABLE 10: Speaker Output Pins Pin # Pin Name Description 8, 11, 16, 27 DGND...
Page 46: Digital Audio Outputs
PR1005/DPR2005 harman/kardon Right Left CONSUMER Right Left Right Left Right TABLE 13: SDI Input to Channel Mapping (Continued) 4.2.3 ZONE 2 DIGITAL INPUTS Z2_MCLK Zone 2 Master System Clock This pin is the master clock input for Zone 2. The master clock must be an integer multiple of the Z2_LRCLK frequency.
Page 47: Control Outputs
PR1005/DPR2005 harman/kardon Right CONSUMER Left Right Left Right TABLE 15: SDO Output to Channel Mapping 4.2.5 CONTROL INPUTS Serial Control Data and Address This pin is the bidirectional Serial Data and Address line for the 2-wire serial control interface. The pin is pulled internally high to 3.3 volts via a 10 kΩ...
Page 48: Amplifier Operation
PR1005/DPR2005 harman/kardon Z2_EN MD[1,0] Configuration Access CONSUMER Only second zone control Only primary zone control Illegal Table 16: MD Input Control of Configuration Access 4.2.8 SPEAKER OUTPUTS CH[7:1]+,- Speaker Channel Outputs These pins provide the Power Amplifier Outputs. Each channel of the amplifier is a full-bridge output configuration.
Page 49 PR1005/DPR2005 harman/kardon ACTIVATING THE AMPLIFIER The GR70 does not maintain control register settings when power is off. After reset the GR70 amplifier is in a passive state, all CONSUMER registers are in their reset state, which results in the outputs being muted. The following procedure activates the amplifier: •...
Page 50 PR1005/DPR2005 harman/kardon • SET MDO CONSUMER POWER SUPPLY AND POWER ON RESET During the power on sequence, the reset line must be active during the high voltage supply ramp period. It must be held for a minimum of 500ms after the supply reaches 95% of its nominal value. The power on rise time of the 46V Power supply MUST NOT exceed a rise time rate faster than 20V / second.
Page 51: Dpr1005 Mechanical Parts List
DPR1005/DPR2005 harman/kardon DPR1005 MECHANICAL PARTS LIST REF NO. PARTS NO. DESCRIPTION TYPE 3SA-3150US-BC00-1-1 AC MECH BOM DPR1005 HARMAN OEM H01-ZVD03DWT434-7 TAPE AL PANEL DOOR H01-ZMB01S00100-5 BKT HEADPHONE JACK H01-ZMC12S19A00-2 BKT AC INLET H01-ZMC12S20A00-2 BADGE AL HARMAN/KARDON SILVER H01-ZMD03MAGN00-2 MAGNET H01-ZMD03S00200-6...
Page 52: Dpr1005 Electrical Parts List
XYEM501K000-2 SPECIALTY LUBRICANTS GREASE,#EM-50L,W=1KG @G ZWM803305PZ-1 WASHER PLAIN 3 XY2N450M0DW-6 GLUE,TAPE,#9070,W=24MM,L=50,DOUBLE-SIDE,WHITE. @METER 3SA-3150US-FCMI-1-5 AC EMBD IMA FRONT BD DPR1005 3SA-3151US-FCAA-1-0 AC ESABD IAA FRONT BD DPR2005 R906 907 RC3DI0471IN-0 RCF 470R0 OHM +5% 250MI0W L800 901 H01-LAINB0470CR-2 LF 47U0H +10% 5.8 OHM 500MI0A PBD07KFCI20-A PCB SINGLE FRONT DPR2005 397MM*163MM*1.6t FR-4...
Page 53 CAP ELEC 220UF 16V M5X11 ELITE H01-CEMGA0108AH-1 CE KMG 1000UI0F M 25V 10X20 105C +-20% 3SA-3151US-AMST-1-2 AC ESABD SMD AMP BD DPR1005 C22 23 24 25 28 29 32 CZZFI0104BF-8 CAP CHIP 100N0F +80% -20% 16.0V Y5V 0603 33 34 35 36 43 48 49...
Page 54 REF NO. PARTS NO. DESCRIPTION TYPE N602 H01-WG03SB80700-6 WIRE ASS'Y 2.0MM 3P 70MM UL1007#26 RED 3SA-3151US-FCAA-1 AC ESABD IAA FRONT BD DPR1005 R906 907 RC3DI0471IN-0 RCF 470R0 OHM +5% 250MI0W L901 H01-LAINB0470CR-2 LF 47U0H +10% 5.8 OHM 500MI0A R941 942...
Page 55 H01-WN06AB00001-4 CNT PLUG BD'BD SOCKET 2.0mm 35237-0610 P818 H01-WN06SB01000-9 CNT PLUG BD'BD PLUG 2.0mm 35336-0610 6P 3SA-3150US-OUMI-1-6 AC ESABD IMA OUT BD DPR1005 PBD04KOUI20-4 PCB SINGLE DPR2005 OUT 174MMX144MM*1.6t FR-1 C401 402 403 CCMPA0472NA-2 CAPACITOR CERAMIC 0.0047UF 400V M NJ41...
Page 56 CE 100UF 16V M 5X11 SHL P2.5MM C573 574 CEMHC0107NN-3 CE 100UF 35V M 6.3X11 C550 551 552 553 575 H01-CEMFC0477AH-A CE 470UF 16V M 8X11.5 SHL 576 577 C253 254 H01-CEMFC0337NN-5 CE 330UF 16V M 8X11.5 SHL 3SA-3150US-POSB-1-7 AC ESABD SMD BOT PROCESSOR BD DPR1005...
Page 57 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE C1 100 164 166 168 CZJII0101BE-2 CCCFMIC 100P0F +5% -5% 50.0V NP0 0603 169 178 2 201 202 206 207 211 213 214 217 218 220 221 223 230 231 232 233 236 237...
Page 58 RMGCFMIC 9K1 OHM +5% 62MI5W R470 471 RS3AD0272NA-0 RMGCFMIC 2K7 OHM +5% 62MI5W 3SA-3151US-POST-1-A AC ESABD SMD TOP PROCESSOR BD DPR1005 C17 238 239 258 462 CZJII0101BE-2 CCCFMIC 100P0F +5% -5% 50.0V NP0 0603 515 516 541 580 581 582 583...
Page 59 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE C101 104 105 112 117 CZZFI0104BF-8 CAP CHIP 100N0F +80% -20% 16.0V Y5V 0603 121 124 132 179 181 182 187 188 227 228 267 268 273 278 282 283 284 285 286...
Page 60 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE R1 120 123 145 150 RS3AD0102NA-3 RMGCFMIC 1K0 OHM +5% 62MI5W 253 254 255 439 442 445 447 448 505 506 507 508 520 521 522 546 547 548 568 575 582 6 617...
Page 61 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE 3SA-3150US-POMI-1-6 AC EMBD IMA PWR SW BD DPR1005 P821 H01-WN02SE00000-6 CON 3.96MM PITCH HEADER 2 POS MOLEX 35328-0210 P820 H01-WN02SB00000-9 CONN 2.0MM 2 MA ST NAT GT201-2P-TS SW80 H01-SWE4A21PDA%-5 SWITCH POWER SDKVB10100 5A 250V 4P...
Page 62 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE R100 104 105 112 117 RS3AD0103NA-1 RMGCFMIC 10K0 OHM +5% 62MI5W 118 122 126 127 158 159 163 165 179 199 201 210 211 212 213 214 215 238 R185 188 RS3AD0105NA-8...
Page 63: Dpr2005 Mechanical Parts List
DPR1005/DPR2005 harman/kardon DPR2005 MECHANICAL PARTS LIST REF NO. PARTS NO. DESCRIPTION TYPE 3SA-3151US-BC00-1-9 AC MECH BOM DPR2005 HARMAN OEM H01-ZVD03DWT434-7 TAPE AL PANEL DOOR H01-ZMB01S00100-5 BKT HEADPHONE JACK H01-ZMC12S19A00-2 BKT AC INLET H01-ZMC12S20A00-2 BADGE AL HARMAN/KARDON SILVER H01-ZMD03MAGN00-2 MAGNET H01-ZMD03S00200-6...
Page 64: Dpr2005 Electrical Parts List
DPR1005/DPR2005 harman/kardon DPR2005 MECHANICAL PARTS LIST DPR2005 ELECTRICAL PARTS LIST REF NO. PARTS NO. DESCRIPTION TYPE ZWF793008PO-5 WASHER FIBER 3 0.8T H01-ZMD03S10A00-1 SHIELD AMP DPR2005 H01-ZUD0301AABK-A SPONGE-UL 30X30X12T BK DPR2005 ZQB0101AA00-4 SHIELD FOAM GASKET (WOORI) ZSMWM3008BZ-7 SCREW M.S M3X8 W/H ZN PLATED ZSTWM3006BY-1 SCREW S.T 3X6 W/H YELLOW ZINC PLATED...
Page 65 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE C22 23 24 25 28 29 32 CZZFI0104BF-8 CAP CHIP 100N0F +80% -20% 16.0V Y5V 0603 33 34 35 36 43 48 49 C15 17 20 31 CZIKI0104DC-3 CAP CHIP 100NF 100V X7R 10% 1206 CZKII0332BC-1 CAP CHIP 3N3F +10% -10% 50.0V X7R...
Page 66 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE R906 907 RC3DI0471IN-0 RCF 470R0 OHM +5% 250MI0W L901 H01-LAINB0470CR-2 LF 47U0H +10% 5.8 OHM 500MI0A R941 942 RC3DI010AIN-1 RCF 1R0 OHM +5% 250MI0W L900 H01-LAINB047ACR-3 LF 4U7H +10% 1.7 OHM 190.0A...
Page 67 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE 3SA-3151US-FCAA-1-0 AC ESABD CON3 BD DPR2005 C501 502 503 504 CCZID0104NA-2 CC 100N0F +80% -20% 50.0V F C505 506 CCKID0681NN-3 CC 680P0F +10% -10% 50.0V 2B4 P815 H01-WN11AB00000-0 CONN 2.0MM 11 MA R NAT SOCKET MOLEX 35237-1110 0 0...
Page 68 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE H01-OSCEM12M2RU-9 OSCILLATOR 12.288MHz 3.3V FG1 2 3 4 6 7 8 H01-ZMB01S02200-9 SPRING PLATE GND C5212 0.2T H01-WS3262105FN-9 WIRE ASS'Y 2.0MM 3P 210MM UL2547#26 RED STR W100 H01-WC1220305C1-0 WIRE ASS'Y UL1007 #22 TC30MM 1P BLK H01-WS0263805FN-6 WIRE ASS'Y UL2547/1007#26 380MM 2.0MM 10P RED...
Page 69 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE C106 107 108 109 11 CZJII0330BE-9 CCCFMIC 33P0F +5% -5% 50.0V NP0 0603 110 118 12 15 16 183 184 189 190 22 23 240 243 269 270 420 423 548 564 565 572...
Page 70 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE R224 246 247 260 261 RS3AD0471NA-5 RMGCFMIC 470R0 OHM +5% 62MI5W 265 266 274 275 30 31 36 37 38 39 40 41 44 45 48 49 52 53 54 55 60 61 62 63 66 67 86...
Page 71 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE IC12 13 16 17 18 19 2 H01-ICLM02068D2-A IC-OPERAMP NJM2068M DUAL SOP8 20 25 27 28 29 3 30 31 32 33 34 35 36 37 38 39 4 40 41 42 46...
Page 72 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE R292 293 294 295 296 RS3AD0331NA-A RMGCFMIC 330R0 OHM +5% 62MI5W 297 298 299 344 345 346 347 349 351 352 353 555 556 557 558 R472 481 525 533 536 RS3AD0332NA-8...
Page 73 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE C102 215 CEMFC0226NN-9 CAP ELEC 22UF 16V M ELITE C154 172 174 179 222 CEHFC04765E-3 CE47UF +20% 16.0V D5XL11 P5MM 85C 235 241 C195 204 208 213 CEHIC01055E-6 CE 1UF +20% 50V D5XL11 P5MM 85C...
Page 74 DPR1005/DPR2005 harman/kardon REF NO. PARTS NO. DESCRIPTION TYPE R101 102 103 106 107 RS1AD0750NA-6 RES CHIP 75OHM 1% 1/16W 0603 108 109 110 111 119 120 121 128 129 130 131 132 133 R225 RS3AD0820NA-6 RMGCFMIC 82R0 OHM +5% 62MI5W...
Page 75: Smps (Power Supply) Electrical Parts List
DPR1005/2005 SMPS (Power Supply) Electrical Parts List NOTE: Ordinarily the DPR1005/2005 SMPS Power Supply module is supplied only as a complete unit. Supplied Schematic and Parts list are included only for reference when the above part is not available and/or repair to component level is necessary.
Page 76 DPR1005/DPR2005 harman/kardon DPR1005/2005 SMPS (Power Supply) Electrical Parts List DPR2005US DPR1005US TOROIDAL IRON13￠ T203 T203 Kyusan Telecom TRANSFORMER EE1927(KJP-10013 T3) T201,202 Kyusan Telecom TRANSFORMER EE1927(KJP-7013 T3) T201,202 Kyusan Telecom LINE FILTER 38PHI(15T*15T) LF101.LF102 WooJin elecom LINE FILTER 38PHI(19T*19T) LF101.LF102 WooJin elecom...
Page 77 DPR1005/DPR2005 harman/kardon DPR1005/2005 SMPS (Power Supply) Electrical Parts List DPR2005US DPR1005US M.O.R RESISTOR 1W 22 R213.214 R213.214 DI-Electronics Hanbu M.O.R RESISTOR 1W 100K R106.107,109® R106.107,109® DI-Electronics Hanbu R108® R108® M.O.R RESISTOR 1W 220K DI-Electronics Hanbu M.O.R RESISTOR 2W 4.7K R203...
Page 78 DPR1005/DPR2005 harman/kardon DPR1005/2005 SMPS (Power Supply) Electrical Parts List DPR2005US DPR1005US CN203 CN203 CONNECTOR-HDR 35313-0810 8PIN MOLEX CONNECTOR-HDR VL6.2mm 3PIN CN101 CN101 RELAY ALE15B12 RL101 RL101 NAIS JUMPER J109 J109 JUMPER 7.5mm JUMPER 10mm J102,103,111,1,2,7,8,10,11,16 10 J102,103,111,1,2,7,8,10,11,16 JUMPER 11mm J108,22...
Page 79: Semiconductor Data
PR1005/DPR2005 harman/kardon IC BLOCK DIAGRAMS 1.M74HCU04 DSP PART IC701.702 2.CS42528 DSP PART IC700...
Page 80 PR1005/DPR2005 harman/kardon TC9273F 4.TOTX179L DSP PART NJ76 TORX179L DSP PART NJ74.NJ75 SUPPLY PART NJ79...
Page 81 PR1005/DPR2005 harman/kardon 5.NJM6324 DSP PART IC803 NJU6324XE 6.NJM4566AM PROCESSOR PART IC22 NJM4556AM NJM4556AD NJM4556AM NJM4556AV 7.AT492V8192A DSP PART IC804...
Page 82 PR1005/DPR2005 harman/kardon 8.UPD70F3033BGF DSP PART IC600...
Page 83 PR1005/DPR2005 harman/kardon DPR1005/2005 MICOM PORT ASSIGN V850 NAME RECEVIER NAME IN/OUT Discription P14/SO1/TXD0 RS-232 TX UART TX PORT P15/SCK1/ASCK0 VPP_CONTROL VPP CONTROL FOR FLASH UPGRADE P20/SI2/SDA1 D2AUDIO -RST D2AUDIO RESET P21/SO2 6dB VOLUME UP FOR HDCD P22/SCK2/SCL1 FL STB FL RESET...
Page 84 PR1005/DPR2005 harman/kardon CLKOUT CLKOUT OPEN P90/LBEN/WRL P91/UBEN P92/RW/WRH HP MUTE HEADPHONE MUTE P93/DSTB/RD I2C DATA I2C-SDA (EEPROM, DDX8228, D2A) P94/ASTB I2C CLK I2C-SCL (EEPROM, DDX8228, D2A) VOL ST P95/HLDAK 9459 VOLUME IC STROB P96/HLDRQ 4094 CE 4094 CHIP ENABLE 4094 CLK 4094 CLK 4094 DATA 4094 DATA...
Page 85 PR1005/DPR2005 harman/kardon P81/ANI9 P82/ANI10 PROTECTION PROTECTION IN(Normal-high) P83/ANI11 P00/NMI STANDBY MAIN POWER ON/OFF P01/INTP0 POWER DOWN INTP0 POWER DOWN CHECK : RISING EDGE P02/INTP1 RDS_CLOCK INTP1 RDS_CLOCK P03/INTP2 RDS_DATA RDS_DATA P04/INTP3 COAX_INOUT SEL CS42528 MUTEC P05/INTP4/ADTRG SYNC pluse check Pal,ntsc pulse width check P06/INTP5/RTPTRG Sync in/out check Sync in,off check P07/INTP6...
Page 86 PR1005/DPR2005 harman/kardon 9.BU4094BCF DSP PART IC602 VIDEO PART IC19.IC20 FRONT PARRT IC101 10.VCOX 24M576HZ DSP PART Y800 11.BA033T MAIN PART IC53...
Page 87 PR1005/DPR2005 harman/kardon 12.NJM2296M VIDEO PART IC10.11.12 13.MM1505 VIDEO PART IC13.15.23 14.MM1501 VIDEO PART IC14,25,26 15.MM1511 VIDEO PART IC27...
Page 88 PR1005/DPR2005 harman/kardon 16.PHOTOCOUPLER PC-17T1 VIDEO PART IC40.51.52 17.TC9162AF PROCESSOR PART IC14 18.TC9163AF PROCESSOR PART...
Page 89 PR1005/DPR2005 harman/kardon 19.TC9482F PROCESSOR PART IC19 20.TC9481F PROCESSOR IC28 TC9481F 21.KIC9459F PROCESSOR IC2, 18...
Page 90 PR1005/DPR2005 harman/kardon 22.TSH95 VIDEO PART IC17 23.MPD4721 VIDEO PART IC50...
Page 91 PR1005/DPR2005 harman/kardon 24.K4S161622D-TC80 DSP PART IC805...
Page 92 PR1005/DPR2005 harman/kardon 25.M24C04 DSP PART IC603 26.74VHC2441A 74VHCT24A DSP PART IC802 DSP PART IC801...
Page 93 PR1005/DPR2005 harman/kardon 27.2C74763M VIDEO PART IC22 28.FL HCA-18LL03 FRONT PART DP10...
Page 94 PR1005/DPR2005 harman/kardon 3.PROCESSOR APRT IC6.IC10...
Page 95 PR1005/DPR2005 harman/kardon 29.NJM2068M DSP PART IC100~IC111.IC116.IC117.IC400.IC401.IC402.IC403.IC404 PROCESSORR PART IC1.IC4.IC7.IC8.IC9.IC11.IC12.IC13.IC15.IC16.IC17.IC20 IC21.IC23.IC24.IC25.IC26.IC27 MAIN PART IC22 VIDEO PART IC901~904 NJM2068M 30.KIA78R08API DSP PART IC601 1.Vin 2.VO 3.GND 4.Vdis 31.RPM6938-RSIP-A3 FRONT PART RM100...
Page 96 PR1005/DPR2005 harman/kardon 32.BU4053BF VIDEO PART IC16 33.CS5361 DSP PART IC112.IC113.IC114.IC115...
Page 97 PR1005/DPR2005 harman/kardon CS49400 DSP PART IC800...
Page 98 PR1005/DPR2005 harman/kardon TRANSISTOR BLOCK 1.KRC107M MAIN PART Q443 VIDEO PART Q400.501.502 DTC114YS VIDEO PART Q107.110 2.2SA1145Y MAIN PART Q309.310.411.412 SURROUND PART Q305.405.505...
Page 99 PR1005/DPR2005 harman/kardon 13.KIA7915 MAIN PART IC52 KIA7905 MAIN PART IC56 14.DTC114Y DSP PART Q600.601.604.605.606.607.608.609.612.613.700 FRONT PART Q102.103.801.802.803.804.805 PROCESSOR PART VIDEO PART Q105.106.113...
Page 100 PR1005/DPR2005 harman/kardon 15.DTA114Y DSP PART Q402.403 PROCESSOR PART Q20.3.13.14.17.23.25.32.34.35.37.41.43.50.52 VIDEO PART Q102.103 16.KTD1304N DSP PART Q400.401 FRONT PART Q800 PROCESSOR PART Q4.7.8.9.10.11.12.15.16.51.53.58.59...
Page 101 PR1005/DPR2005 harman/kardon...
Page 102 PR1005/DPR2005 harman/kardon IF¤uey¤—ssignment †ref ¤¤E¤volt—ge¤divider¤method ¤¤¤¤¤¤¤mi™om @UUA uey•inI @UVA uey•inP ƒPHH ƒPII „uneF¤wode ƒt—nd˜y¤onGoff ƒPIP ƒPHI ƒour™e¤…p ƒurrF¤wode ƒPH ƒPIQ „est¤„one ƒurrF¤hown¤ƒele™t¤…p ƒPHQ ƒPIR ƒpe—ker¤edjustment ƒurrF¤…p¤ƒele™t¤hown ƒPHR ƒPIS „unning¤hown gh—nnel¤edjustment ƒPIT ƒPHS „unning¤…p higit—l¤ƒele™t ƒPIU ƒPHT hel—y¤edjustment ewGpw@fexhA ƒPIV ƒPHU ƒele™t¤hown@™h—nge €reset¤hown —djustmentA...
Page 103: Pcb Drawings
PR1005/DPR2005 harman/kardon O U TLET B O AR D (TO P VI EW )
Page 104 PR1005/DPR2005 harman/kardon O U TLET B O AR D (B O TTO M VI EW )
Page 105 PR1005/DPR2005 harman/kardon VI D EO B O AR D (TO P VI EW )
Page 106 PR1005/DPR2005 harman/kardon VI D EO B O AR D (B O TTO M VI EW )
Page 107 PR1005/DPR2005 harman/kardon PR O C ESSO R B O AR D (TO P VI EW )
Page 108 PR1005/DPR2005 harman/kardon PR O C ESSO R B O AR D (B O TTO M VI EW )
Page 109 PR1005/DPR2005 harman/kardon FR O N T B O AR D (TO P VI EW )
Page 110 PR1005/DPR2005 harman/kardon FR O N T B O AR D (B O TTO M VI EW )
Page 111 PR1005/DPR2005 harman/kardon AM P B O AR D (TO P VI EW )
Page 112 PR1005/DPR2005 harman/kardon AM P B O AR D (B O TTO M VI EW )
Page 113: Schematics
PR1005/DPR2005 harman/kardon NOTE: Ordinarily the DPR1005/2005 SMPS Power Supply module is supplied only as a complete unit. Supplied Schematic and Parts list are included only for reference when the above part is not available and/or repair to component level is necessary.
Page 124 PR1005/DPR2005 harman/kardon 出圖 (株)光星電子...
Page 125 PR1005/DPR2005 harman/kardon 出圖 (株)光星電子...
Page 127: Packaging
DPR1005/DPR2005 harman/kardon...

This manual is also suitable for:

Dpr2005

Harman Kardon DPR1005 Service Manual

Quick Links

SERVICE MANUAL

Related Manuals for Harman Kardon DPR1005

Summary of Contents for Harman Kardon DPR1005

This manual is also suitable for:

Table of Contents