http://www.xiaoyu163.com SPECIFICATIONS 3 7 63 1515 0 TUNER GENERAL FM tuning range: 87.5 MHz to 108 MHz Power requirements: 120 V AC, 60 Hz FM usable sensitivity(IHF): Power consumption: 22 W 13.2 dBf Power consumption in standby mode: FM antenna terminals: 75 ohms (unbalanced) With ECO mode on: 1.6 W AM tuning range:...
http://www.xiaoyu163.com PROTECTION OF EYES FROM LASER BEAM DURING SERVICING 3 7 63 1515 0 CAUTION This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing. Use of controls or adjustments or performance of proce- dures other than those specified herin may result in WARNING!! hazardous radiation exposure.
http://www.xiaoyu163.com LCD DIAGRAM 3 7 63 1515 0 SEGMENT SIDE L 13942296513 COMMON SIDE u163 – 22 – http://www.xiaoyu163.com...
Page 23
http://www.xiaoyu163.com IC DESCRIPTION IC, LC877256V-5V22 3 7 63 1515 0 Pin No. Pin Name Description 1 ~ 4 Not connected. I-WRQ CD WRQ input. I-DRF CD DRF input. I-CDDO CD sub code input. O-VOL CTL Volume control output. O-AON Main power ON/OFF control output. O-CKSFT Clock shift.
Page 24
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description VSS3 GND. VDD3 Power supply. O-P.ON Power ON/OFF control. O-MUTE Mute ON/OFF control output. O-TUON Tuner ON/OFF control output. O-CDON CD ON/OFF control output. O-CDDATA CD data output. O-CDCE CD enable output.
Page 25
http://www.xiaoyu163.com IC, LA9241ML 3 7 63 1515 0 Pin No. Pin Name Description Connects to the pickup's photo diode; adding this pin to pin FIN1 generates RF signal, FIN2 and subtracting it generates FE signal. FIN1 Connects to the pickup's photo diode. Connects to the pickup's photo diode;...
Page 26
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description CV– Input for CLV error signal from DSP. RFSM Output for RF. RFS– For setting RF gain and 3T compensation constant together with RFSM. SLICE LEVEL CONTROL; output for controlling the data slice level of DSP with RF waveform.
Page 27
http://www.xiaoyu163.com IC, LC78622NE 3 7 63 1515 0 Pin No. Pin Name Description DEFI Defect detection signal (DEF) input. Test input. A pull-down resistor is built in. Must be connected to 0V. External VCO control phase comparator output. VVSS – Internal VCO ground.
Page 28
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description LCHO Left channel one-bit D/A converter output. LVSS – Left channel one-bit D/A converter ground. (Must be connected to 0V) RVSS – Right channel one-bit D/A converter ground. (Must be connected to 0V) RCHO Right channel one-bit D/A converter output.
Page 29
http://www.xiaoyu163.com ADJUSTMENT – 1 <TUNER / FRONT> < TUNER SECTION > 3 7 63 1515 0 1. Clock frequency Check 8. Output Level Check Settings : • Test point : TP3 (CLK) <AM> Method : Set to AM 1710 kHz and check that the test point is Settings : •...
Page 30
http://www.xiaoyu163.com ADJUSTMENT – 2 (CD) 3 7 63 1515 0 CD C.B (PATTERN SIDE) R402 RF SM VREF FOCUS BIAS L 13942296513 u163 – 30 – http://www.xiaoyu163.com...
Page 31
http://www.xiaoyu163.com 3 7 63 1515 0 CD Adjustment Method • Perform the adjustments after the machine enters the test mode. • Place the CD mechanism horizontally level. • Equipment and tools required Measuring equipment: Oscilloscope (Use the probe of 10:1) Digital VOM (Use it in the DC Volt range.) Jitter meter (Kikusui 6235 or equivalent) Test disc:...
http://www.xiaoyu163.com CD TEST MODE 3 7 63 1515 0 1. How to Start the CD Test Mode While pressing the FUNCTION button, insert the AC plug to the power outlet. When the test mode is started, the message [CD TEST] is displayed. 2.
Page 33
http://www.xiaoyu163.com MECHANICAL EXPLODED VIEW 1 / 1 3 7 6 3 1 5 1 5 0 HT-SINK, MAIN HT-SINK, SUB DA11B3 1 3 9 4 2 2 9 6 5 1 3 LCD101 WIRE,BINDER CHAS, MAIN w w w u 1 6 3 –...
http://www.xiaoyu163.com CD MECHANISM EXPLODED VIEW 1 / 1 3 7 63 1515 0 L 13942296513 PIN 3 CD MECHANISM PARTS LIST 1 / 1 REF. NO. PART NO. KANRI DESCRIPTION 1 M8-AZK-M90-070 DA11B3 2 S2-121-A28-400 COVER GEAR 3 S2-511-A21-000 GEAR MIDDLE 4 S2-511-A21-100 GEAR,DRIVE A S1-PN2-03R-OSE...
Page 36
http://www.xiaoyu163.com SPEAKER DISASSEMBLY INSTRUCTIONS 3 7 63 1515 0 Remove the four screws with Allen wrench. Remove the four screws and remove the speaker. Remove the screw and remove the foot. Press the two claws and remove the PWB. L 13942296513 u163 –...
Page 37
http://www.xiaoyu163.com SPEAKER PARTS LIST (SX-LM313<YJSM>) 3 7 63 1515 0 REF. NO. PART NO. KANRI DESCRIPTION REF. NO. PART NO. KANRI DESCRIPTION 1 8B-CJ7-007-010 CABI,SPKR FR U 2 8B-CJ7-008-010 CABI,SPKR REAR U 3 8B-CL7-019-010 NET,SPKR ASSY (L) 4 8B-CJ7-009-010 FRAME,NET U 5 8B-CL7-018-010 NET,SPKR (L) 6 8B-CJ7-026-010...
Page 38
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:03 (3827) 3111 9820572 921338 Printed in Singapore http://www.xiaoyu163.com...