Pioneer DVH-P5900MP Service Manual
  1. Manuals
  2. Brands
  3. Pioneer Manuals
  4. Car Receiver
  5. DVH-P5900MP
  6. Service manual
Pioneer DVH-P5900MP Service Manual

Pioneer DVH-P5900MP Service Manual

Hide thumbs Also See for DVH-P5900MP:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Operating Manual
QQ
3 7 63 1515 0
DVD RDS RECEIVER
DVH-P5900MP
DVH-P590MP
This service manual should be used together with the following manual(s):
Model No.
TE
L 13942296513
CX-3212
Manufactured under license from Dolby Laboratories. "Dolby", "Pro Logic", and the double-D
symbol are trademarks of Dolby Laboratories.
www
.
PIONEER CORPORATION
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2007
http://www.xiaoyu163.com
Order No.
Mech.Module
CRT3896
MS5
x
ao
y
i
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
http://www.xiaoyu163.com
8
DVH-P5900MP/XN/EW5
/XN/RE
Q Q
3
6 7
1 3
DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
u163
.
2 9
9 4
2 8
Remarks
1 5
0 5
8
2 9
9 4
m
co
K-ZZA. APR. 2007 Printed in Japan
9 9
ORDER NO.
CRT3931
/XN/EW5
2 8
9 9

Advertisement

Table of Contents
loading

Related Manuals for Pioneer DVH-P5900MP

Summary of Contents for Pioneer DVH-P5900MP

  • Page 1 PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2007 K-ZZA.

  • Page 2: Safety Information

    1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer . 2. The triangular label is attached to the mechanism unit frame. L 13942296513 On the top of the player. u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 3 L 13942296513 CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions. u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 4 To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 5: Table Of Contents

    10.5 COMPOUND UNIT(A) AND COMPOUND UNIT(B) ................90 10.6 WAVEFORMS............................91 11. PCB CONNECTION DIAGRAM ........................94 11.1 TUNER AMP UNIT ..........................94 11.2 KEYBOARD UNIT...........................98 11.3 DVD CORE UNIT..........................100 11.4 COMPOUND UNIT(A) AND COMPOUND UNIT(B) ................104 12. ELECTRICAL PARTS LIST.........................105 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 6: Service Precautions

    Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 7: Specifications

    2. SPECIFICATIONS 3 7 63 1515 0 2.1 SPECIFICATIONS L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 8 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 9: Disc/Content Format

    2.2 DISC/CONTENT FORMAT 3 7 63 1515 0 is a trademark of DVD Format/Logo Licensing Corporation. L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 10: Panel Facilities

    2.3 PANEL FACILITIES 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 11 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 12 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 13 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 14 3 7 63 1515 0 BPZ20P080FTC L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 15: Connection Diagram

    2.4 CONNECTION DIAGRAM 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 16: Basic Items For Service

    For check items concerning image and voice, please refer to the followings: Check items concerning image Check items concerning voice t s i o i t L 13942296513 Distorted image (Image skip) High volume Low brig ges in level Too brig Color fading Partial discoloration u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 17: Pcb Locations

    Tuner Amp Unit Unit Number (EW5) Unit Name Keyboard Unit Unit Number (RE) Unit Name Keyboard Unit Unit Number YWX5005 Unit Name DVD Core Unit Unit Number CWX3154 Unit Name Compound Unit(A) Unit Number CWX3394 Unit Name Compound Unit(B) u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 18: Jigs List

    Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools DVD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 Portions to be cleaned Cleaning tools Fans Cleaning paper : GED-008 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 19 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 20: Block Diagram

    IC1021 PEG324A MSVDD5 TUN33 SYS+B NJM2885DL1-33 SWVDD FU1101 DPDT D/D CONVERTER Q1105 Q1103 FU1103 KYDT IC1101 MSVDD5 AN8011S DSENS u163 OUT2 ON/OFF VDCONT ROT1 ROT0 RESET Q1104 Q1102 FU1102 IC651 RESET VDD5V Q1101 BD4835G OUT1 DDCONF ILMPW VR1101 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 21 REMOTE CONTROL IC1801 SWVDD SENSOR PD6569A SWVDD5 SWVDD IC1802 SY_2_KY SYS_KY OPT IN GP1UX51RK KY_2_SY KY_SYS DSENS DSENS S1827 X1801 SWVDD 5MHz u163 ROT1 ROT1 LCD1801 ILM+B REG. ROT0 ROT0 Q1091 ILLUMI KEY MATRIX NATION Q1092 S1801,S1802,S1804-S1807, S1809-S1815,S1817-S1822, S1824,S1825,S1828,S1829 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 22 CN1951 VIN3RF VIN3 PR_A20 VIN4RF EXTRG1_SPD_SW VIN4 EXTRG1 SCLOCK SCLOCK VIN5 SDATA SDATA VIN6 EXTRG0 EXTRG0 CDMPD TRCCLK TRCCLK DVDMPD TRCD0 RFINN TRCDATA0 TRCD1 TRCDATA1 F+H_G+H TRCD2 TRCDATA2 E+G_E+F TRCD3 TRCDATA3 LPCO2 TRCST LPCO1 TRCST VCC33 VDD5 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 23 ACO1- ACO1+ CN1101 ACO2+ ACO2- TEMP 3.3V REG. IC1007 NJM2885DL1-33 VDD5 VCC33 CDMPD 78MD 1.2V REG. DVDMPD 65MD PU (DP8) IC1008 R1232D121B F+H_G+H F+H/G+H E+G_E+F E+G/E+F VCC12 Q1102 Q1104 LPCO2 LD(CD) Q1101 Q1103 u163 LPCO1 LD(DVD) VREF VCC5 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 24 Ground of audio block 23 L ch O L channel output FM stereo “L-ch” signal output or AM audio output 24 R ch O R channel output FM stereo “R-ch” signal output or AM audio output u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 25 - LCD(CAW1947) 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 26: Diagnosis

    Grille microcomputer may fail. Source keys If the time interval is not 300 msec, the oscillator operative may be defective. Source ON SYSPW ← H u163 46 pin Completes power-on operation. (After that, proceed to each source operation.) DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 27: Diagnosis Flowchart

    Execute check 10. L 13942296513 Go to FE section check. Repair the defective part. Go to FE section check. Normal? FE section check. Go to FE related Is FE section repair process. normal? Replace the unit. Normal? u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 28 <Check> Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference. Specification value Check point Module No. Unit STANBY-DGND1 VCC33 V- 0.6 V or more Side A DGND1 STANBY L 13942296513 Fig 1.1: STANBY check point u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 29 Module No. Unit VDD5_3 - DGND1 5.0 ± 0.4 VCC33_3 - DGND1 3.3 ± 0.15 VCC12_1 - DGND1 1.2 ± 0.12 Side A L 13942296513 VDD5_3 VCC33 DGND1 VCC12_1 Fig 2.2: VDD5, VCC33, VCC12 voltage check points u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 30 <Check> Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference. Check point Module No. Specification value Unit 1 XRES-DGND1 VCC33 × 0.7 or more Side A DGND1 XRES L 13942296513 Fig 3.1: RESET check point u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 31 <Check> Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference. Specification value Check point Module No. Unit VSENS - DGND1 VCC33 × 0.7 or more Side A L 13942296513 DGND1 VSENS Fig 4.2: VSENS check point u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 32 Check point Module No. Specification value Unit 27 MHz 2 IC1501 169pin ± 50 ppm L 13942296513 Specification value Fig 5.2: Clock specification value Side A DGND1 IC1501 169pin u163 Fig 5.3: 27 MHz check point DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 33 Be careful as XCSM, XWE, XCAS, XRAS and XSCM of IC1481 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS, NCSM. IC1501 MA0~11 1481 DVD-LSI MDQ0~31 SDRAM XWE (NWE) XCAS (NCAS) XRAS (NRAS) XCSM (NCSM) DQM0 DQM1 DQM2 DQM3 Fig 6.1: SDRAM I/F L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 34 ± 5 % Ω DQM2 IC1481 28pin IC1501 26pin ± 5 % Ω DQM3 IC1481 59pin IC1501 27pin ± 5 % u163 Ω IC1481 22pin IC1501 8pin ± 5 % Ω IC1481 23pin IC1501 10pin ± 5 % DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 35 3 7 63 1515 0 Side B Check point 1 (IC1481) Side A L 13942296513 Fig 6.2: SDRAM I/F check point Check point 2 (IC1501) u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 36 Module No. Specification value Unit VD8_1 - PGND3 8.0 ± 0.4 VD - PGND3 8.0 ± 0.4 VCC5_1- AGND1 5.0 ± 0.1 Side A VD8_1 AGND1 L 13942296513 PGND3 VCC5_1 Fig 7.2: VD8, VCC5 voltage check points u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 37 Check with PGND and GNDAU being the reference. Check point Module No. Specification value Unit VD - PGND_3 8.0 ± 0.4 AVCC5 - GNDAU1 5.0 ± 0.1 Side A PGND3 GNDAU L 13942296513 AVCC5 Fig 8.2: VD8, AVCC5 voltage check points u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 38 33.8688 MHz±300 ppm Specification value 1 Specification Specification value 2 L 13942296513 value 3 Fig 9.2: Clock specification value Side A u163 Check point 2 (IC1501 172 pin) Check point 1 (stylus) Fig 9.3: 27 MHz, DACCLK check point DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 39 VCC33 V-0.6 V or higher 0.4 V or lower Waveform 3 L 13942296513 Specification value 2 Specification value 1 Fig 10.2: Serial 3 lines specification value Side A SRCK LRCK ADOUT3 u163 Fig 10.3: Serial 3 lines check points DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 40 Waveform 4 1 400 ± 150 mV Waveform 4 Specification value is the root-mean-square value (rms). Fig 10.4: Analog audio out (LO, RO) specification value. Side A GNDAU1 L 13942296513 Fig 10.5: Analog audio out check point u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 41 Specification value 2 Check point 1 (stylus) Specification value 1 Reference waveform 6 IEC VCC33 V-0.6 V or higher 0.4 V or lower Waveform 5 Side A L 13942296513 Fig 10.6: Digital audio signal (IECOUT) check point u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 42 AD3/DATA ADOUT3 DATA IEC/IPFLG IPFLG SBCK SBCK BMUTE BMUTE MCKENA High RIPP High EMPH EMPH EMPH Pins 1, 6, 8, 10, 12, 14, 16, 18, 20, 22 and 24 are GNDD. Fig 10.7: 6ch digital out/Ripping circuit u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 43 0.4 V or lower SBCK VCC33 V-0.6 V or higher 0.4 V or lower RIPP VCC33 V x 0.3 V or lower L 13942296513 Specification value 1 Specification value 2 Fig 10.8: 6ch digital out/Ripping specification value u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 44 3 7 63 1515 0 Side A SRCK LRCK ADOUT3 Side B L 13942296513 ADOUT2 ADOUT1 ADOUT0 RIPP MCKENA SBCK Fig 10.9: 6ch digital out/Ripping check point u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 45 Turn the volume (VR1671) to adjust the video level within the range of 1.0 ± 0.02 Vpp. The adjustment specification is 1.0 ± 0.02 Vpp. CN1901 AVCC5 HOST I/F IC1501 Q1701(NoMount) Video buffer circuit Video Q1702(NoMount) Video buffer circuit section Q1704(NoMount) Video buffer circuit Fig 11.3: Video circuit (component) u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 46 Cb signal Specification value BOTTOM PEAK Cr signal Specification value L 13942296513 BOTTOM 100% Color Bars signal Fig 11.4 Waveform for the case of component 100% Color Bars output Side A COMPO u163 Fig 11.5: VIDEO signal check point DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 47 (Refer to the FE test mode for the method of displaying the LD energizing time.) 2.If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life. Example: 0E000BB8 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 48 Waveform 7 G-> G-> L 13942296513 Waveform 2 Waveform 5 [WHITE 100IRE] CH1 : LRCK CH1 : COMPO Reference voltage: DGND2 1 V/div. 5 μsec/div Reference voltage: GNDV1 200 mV/div. 10 μsec/div G-> Waveform 6 Waveform 3 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 49: Error Code List

    *5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied discs can be identified. *6 Notice as an error status will not be given *7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card. (DVD VR DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 50: Connector Function Description

    5.4 CONNECTOR FUNCTION DESCRIPTION 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 51: Service Mode

    In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again FEMIN level before F close. ASMAX level ENVMAX level FE normalization coefficient Spindle gain coefficient TEMAX level indication TEMIN level indication u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 52 Power_OFF Error occurrence at Power_OFF [Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again. Error display u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 53 [Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours. [Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory. DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 54: Disassembly

    DVD Mechanism Module Release the two latchs and then remove the Grille Assy. Removing the DVD Mechanism Module (Fig.1) Remove the four screws. Disconnect the two connectors and then remove the DVD Mechanism Module. u163 Grille Assy Fig.1 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 55 3 7 63 1515 0 Removing the Tuner Amp Unit (Fig.2) Remove the screw. Remove the screw. Remove the screw. Straighten the tabs at four locations indicated and then remove the Tuner Amp Unit. Tuner Amp Unit Fig.2 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 56 7. Disconnect the connector of the 8-12 detection flexible PCB from the PCB. Fig 4 Module PCB Short Connector Connector (8-12 detection flexible) (pick up flexible) u163 Solder land (load motor, lead wire of the clamp SW.) Connector (SPDL flexible) Fig 5 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 57 Furthermore, make sure to hang the main shaft holding spring permanently. Holding plate spring Main shaft PU unit Main shaft holding spring Sub shaft Fig 7 CRG chassis temporary hanging section u163 Temporary hanging Permanent hanging DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 58: Each Setting And Adjustment

    Attention) L 13942296513 Test mode starting procedure Reset start while pressing the 4 and 6 keys together. Test mode stopping procedure Reset or ACC OFF-ON. u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 59 Symptom in case the adjustment is not adequate: Worsening of the error rate 10 (Normally 10 or less.) Large RF jitter RF waveform distortion Tracking drawing/Unstable servo u163 * Caution: Do not look into the laser light during adjustment. DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 60 11. Turn the power OFF in the test mode, and after confirming that the disc has stopped, eject the disc. u163 12. Apply adhesive for fixing the SKEW and lock the screw. Refer to the illustration below for the adhesion points. DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 61 Cross section of R-SKEW adhesive locations. * Caution: Make a cross link to both the resin section and the sheet metal section. u163 Adhesive application locations * Caution: Make a cross link to both the case section and the sheet metal section. DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 62 * Caution: Do not touch the shaded section in the drawing below. RF level adjustment section L 13942296513 Do not touch the optical parts. Do not touch the springs. Hologram (be careful for the static electricity) GRT adjustment section u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 63: Tuner Amp Unit Adjustment

    3 7 63 1515 0 - Adjustment Point +14.4 V BACK UP DC Regulated Power Supply TUNER AMP UNIT(SIDE A) CN751 VR571 TC501 IC504 C518 CN101 IC601 VR1101 L 13942296513 TUNER AMP UNIT(SIDE B) VOUT MSVDD OUT2 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 64 TUNER Source plate of Adjust to bring the source TC501 Adjust by displaying TUNER plate to the screen center. such as on AVX-7650. L 13942296513 Adjusted by TC501 Source plate Circumference of monitor liquid crystal AVX-7650 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 65: System Microcomputer Test Program

    The frequency of the clock signal is 468.750 kHz that is one 32th of the fundamental frequency. The clock signal should be 468.750 kHz(± 19 Hz). If the clock signal is out of the range, the X'tal (X601) should be replaced with new one. L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 66: Exploded Views And Parts List

    Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 67 CXB3520 Remote Control Assy CXC7605 15-2 Owner's Manual See Contrast table(2) 15-3 Owner's Manual See Contrast table(2) (2) CONTRAST TABLE DVH-P5900MP/XN/EW5 and DVH-P590MP/XN/RE are constructed the same except for the following: Mark Description DVH-P5900MP/XN/EW5 DVH-P590MP/XN/RE 15-1 Owner's Manual CRB2390 CRB2402...

  • Page 68: Exterior(1)

    9.2 EXTERIOR(1) 3 7 63 1515 0 DVH-P5900MP/XN/EW5 1/2 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 69 CAC9946 Button(UP) CAC9947 Panel YNS5191 Button(DOWN) CAC9948 IC(IC1802) GP1UX51RK Button(EJECT) CAC9949 (2) CONTRAST TABLE DVH-P5900MP/XN/EW5 and DVH-P590MP/XN/RE are constructed the same except for the following: Mark Description DVH-P5900MP/XN/EW5 DVH-P590MP/XN/RE Label CAN5448 Not used L 13942296513 Detach Grille Assy CXC8565 CXC8566...

  • Page 70: Exterior(2)

    9.3 EXTERIOR(2) 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 71 CEF1050 Main Chassis Assy See Contrast table(2) Pin Jack(CN281) CKB1082 Screw BMZ26P100FTB Plug(CN751) CKM1370 (2) CONTRAST TABLE DVH-P5900MP/XN/EW5 and DVH-P590MP/XN/RE are constructed the same except for the following: Mark Description DVH-P5900MP/XN/EW5 DVH-P590MP/XN/RE Chassis CNA2996 CNA3202 Tuner Amp Unit CWN2384 CWN2373...

  • Page 72: Dvd Mechanism Module

    9.4 DVD MECHANISM MODULE 3 7 63 1515 0 L 13942296513 (A) : GEM1045 (B) : GEM1043 (C) : GEM1024 u163 (D) : GEM1050 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 73 Screw JFZ20P018FTC Frame CND2250 Washer YE20FTC Holder CND2251 Pickup Unit(Service) CXX2118 Screw IMS20P030FTC Holder CND3936 Sheet CNM6883 Collar CNV9570 Sheet CNM8697 Shaft CLA4771 Sheet CNM9658 Guide Unit CXC8572 Sheet CNM9407 u163 CNV7156 Clamper CNV7158 Roller CNV7165 Rack CNV7175 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 74: Schematic Diagram

    Therefore, when replacing, be sure to use parts of > > identical designation. : The power supply is shown with the marked box. Guide page > Detailed page CN1901 L 13942296513 DVD/CD:+5.1dBs IP-BUS:+2.2dBs TUNER(30%)(EW5):-20dBs TUNER(30%)(RE):-24dBs u163 AUX:+2.2dBs CN1801 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 75 TUNER(RE):-5.66dBs IP-BUS:+9.54dBs DVD/CD:+9.44dBs AUX:+9.54dBs TUNER(EW5): -23dBs TUNER(RE): -27dBs IP-BUS: -0.8dBs DVD/CD:+0.1dBs L 13942296513 AUX: -0.8dBs TUNER(EW5): -0.9dBs TUNER(RE): -4.9dBs IP-BUS:+10.3dBs DVD/CD:+10.2dBs AUX:+10.3dBs > > > CEK1136 B.UP B.G.SENS B.REM 1K(1/2W) TELM u163 TUNER(EW5):+25.1dBs TUNER(RE):+21.1dBs BACK IP-BUS:+36.3dBs DVD/CD:+36.2dBs AUX:+36.3dBs DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 76 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 77 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 78 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 79 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 80: Keyboard Unit

    10.2 KEYBOARD UNIT 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 81 3 7 63 1515 0 KEYBOARD UNIT AUX IN SOURCE VOLUME CN701 AUX:+2.2dBs L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 82: Dvd Core Unit(1/2)(Guide Page)

    10.3 DVD CORE UNIT(1/2)(GUIDE PAGE) 3 7 63 1515 0 RF SIGNAL FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE L 13942296513 u163 CWW1434 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 83 3 7 63 1515 0 DVD CORE UNIT L 13942296513 M2,M3 u163 CWW1435 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 84 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 85 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 86 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 87 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 88: Dvd Core Unit(2/2)

    10.4 DVD CORE UNIT(2/2) 3 7 63 1515 0 L 13942296513 CN301 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 89 3 7 63 1515 0 DVD CORE UNIT L 13942296513 CN101 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 90: Compound Unit(A) And Compound Unit(B)

    10.5 COMPOUND UNIT(A) AND COMPOUND UNIT(B) 3 7 63 1515 0 COMPOUND UNIT(A) Q1299 R1298 R1299 CPT231SCTD S1205 CSN1070 CN1301 DISC SENS DISC SENS S1203 CSN1069 CSN1070 S1204 S1202 CSN1069 12cm S1201 CSN1069 L 13942296513 COMPOUND UNIT(B) CLAMP CSN1067 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 91: Waveforms

    Inner peripheral Peripheral DVDRF(x 1.3 ZCAV) DVDRF(x 5 CAV DVDRF(x 5 CAV L 13942296513 100 μs/div 2TD1 100 μs/div 2TD1 100 μs/div 0.5 V/div 0.1 V/div 0.1 V/div DVDRF(BD1 mm) Interval FWD Interval REV 2.2 V VHALF VHALF u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 92 Play TD Focus Close ID search Inside t Outside VHALF VHALF 5FD1 5FD1 500 μs/div 5FD1 500 μs/div 0.5 V/div 20 ms/div 0.5 V/div 0.5 V/div Play FD Focus Jump L0tL1 Focus Jump L1tL0 VHALF VHALF VHALF u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 93 3 7 63 1515 0 L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 94: Pcb Connection Diagram

    C1114 L102 C235 R1123 C104 L1103 R1121 C103 R1125 C236 IC103 IC231 R171 R1132 R172 Q1103 Q1105 R173 C234 C232 C233 D1105 D1103 C231 R232 R231 R1127 C1115 L1061 C238 C239 FU1101 C1061 CN701 C1102 L1101 u163 CN1801 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 95 C235 C236 IC231 C1101 C1037 D1032 C1063 C234 C232 C1036 C233 C1035 C231 Q1061 R232 R231 R1031 R1061 Q1034 C238 C239 Q1033 C604 D704 D703 R647 Q1092 Q1091 BZ601 u163 R1093 C1091 D701 D702 R1092 C1092 R1094 FRONT DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 96 R623 R619 R618 R215 R617 R217 R670 R220 R218 R216 R613 R602 R622 R672 R616 IC101 L101 C101 C605 C1071 C1062 Q1071 R1063 R1036 R1038 L601 R1071 R1045 R1035 R1037 R1095 R709 R1072 R708 C1095 R706 u163 R707 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 97 C201 IC102 R1101 R126 R1126 R1114 R1113 R1118 R1117 D1104 C1108 R127 IC1101 C105 Q1102 C1107 C1109 C1110 R1120 R1119 C1111 C1113 OUT2 R1124 C1112 C1122 C1121 L1102 R709 R708 R706 u163 R707 D234 D235 D232 D233 D231 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 98: Keyboard Unit

    11.2 KEYBOARD UNIT 3 7 63 1515 0 KEYBOARD UNIT SIDE A L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 99 3 7 63 1515 0 KEYBOARD UNIT SIDE B L 13942296513 CN701 CN1801 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 100: Dvd Core Unit

    11.3 DVD CORE UNIT 3 7 63 1515 0 DVD CORE UNIT PICKUP UNIT (SERVICE) M2, M3 L 13942296513 u163 CN301 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 101 3 7 63 1515 0 SIDE A CN101 UNIT L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 102 3 7 63 1515 0 DVD CORE UNIT L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 103 3 7 63 1515 0 SIDE B L 13942296513 u163 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 104: Compound Unit(A) And Compound Unit(B)

    11.4 COMPOUND UNIT(A) AND COMPOUND UNIT(B) 3 7 63 1515 0 COMPOUND UNIT(A) COMPOUND UNIT(B) Q1299 R1298 CLAMP R1299 S1205 S1204 DISC SENS S1203 DISC SENS S1202 L 13942296513 12cm S1201 u163 CN1301 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

  • Page 105: Electrical Parts List

    NJM2794RB2 Q 1061 (A,121,21) Chip Transistor 2SA1576A IC 251 (A,95,137) IC PAL007C Q 1071 (B,136,22) Transistor UMF23N IC 301 (A,10,124) IC TC7WT125FU Q 1081 (A,136,95) Transistor 2SD1664 IC 401 (A,144,120) IC NJM2794RB2 Q 1082 (A,142,90) Chip Transistor DTC124EUA DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 106 L 401 (B,163,92) Inductor LCTAW220J2520 R 139 (A,143,101) RS1/16S102J R 151 (A,26,125) RS1/16S750J L 402 (A,153,127) Inductor LCTAW2R2J3225 R 152 (A,26,123) RS1/16S101J L 403 (A,158,109) Chip Coil LCTAW1R0J2520 R 153 (A,25,123) RS1/16S101J L 404 (B,159,115) Chip Coil LCTAW100J2520 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 107 (B,19,124) RS1/16S102J R 614 (B,151,46) RS1/16S104J R 403 (B,164,109) RS1/16S681J R 615 (B,148,46) RS1/16S104J R 404 (B,164,108) RS1/16S681J R 616 (B,146,42) RS1/16S473J R 405 (B,164,106) RS1/16S681J R 617 (B,141,49) RS1/16S104J R 406 (B,164,105) RS1/16S681J R 618 (B,141,51) RS1/16S104J DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 108 R 714 (A,122,56) RS1/16S472J R 1127 (A,31,22) RS1/16S0R0J R 715 (A,74,18) RS1/16S101J R 1131 (B,27,47) RS1/16S0R0J R 731 (A,125,93) RS1/16S473J R 1132 (A,51,27) RS1/16S471J R 732 (A,122,89) RS1/16S103J R 733 (A,120,89) RS1/16S103J CAPACITORS R 734 (A,117,86) RS1/16S103J DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 109 (A,71,21) CKSRYB472K50 C 508 (A,33,88) CCSRCH100D50 C 239 (A,74,21) CKSRYB472K50 C 509 (A,45,84) CKSRYB105K6R3 C 251 (B,80,120) CKSRYB105K10 C 510 (A,47,84) CKSRYB105K6R3 C 252 (B,80,116) CKSRYB105K10 C 511 (B,51,81) CCSRCH560J50 C 253 (B,80,117) CKSRYB105K10 C 512 (A,54,84) CKSRYB105K10 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 110 (A,90,8) CKSRYB104K16 R 1809 (B,25,22) RS1/4SA821J C 1101 (A,98,26) 2 200 µF/16 V CCH1383 R 1810 (B,22,26) RS1/4SA821J C 1102 (A,31,14) CEHAZL471M16 C 1103 (B,28,42) CCSRCH101J50 R 1811 (B,136,15) RS1/4SA102J C 1104 (A,23,43) CKSQYB475K10 R 1812 (B,136,11) RS1/4SA102J DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 111 (A,70,52) D/A Converter PCM1753DBQ D 1821 (A,40,31) LED CL-197HB1-D(CDE) Q 1101 (B,62,50) Transistor 2SC4081 D 1822 (A,115,4) LED CL-195SR-CD Q 1102 (B,68,50) Transistor 2SC4081 D 1823 (A,136,4) LED CL-195SR-CD Q 1103 (B,60,45) Transistor 2SB1260 D 1824 (A,147,5) LED CL-195SR-CD DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 112 (B,26,18) RS1/16SS3R9J R 1526 (A,36,10) RS1/16SS270J R 1212 (B,27,18) RS1/16SS3R9J R 1528 (A,43,14) RS1/16SS101J R 1214 (B,28,18) RS1/16SS3R9J R 1529 (B,53,22) RAB4CQ560J R 1215 (B,29,18) RS1/16SS3R9J R 1530 (A,43,15) RS1/16SS105J R 1216 (B,30,18) RS1/16SS3R9J R 1531 (B,50,22) RAB4CQ560J DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 113 (A,74,56) RS1/16SS821J C 1483 (B,67,5) CKSSYB104K10 R 1805 (A,72,61) RS1/16SS104J C 1484 (B,63,5) CKSSYB104K10 R 1806 (A,74,61) RS1/16SS104J R 1903 (A,89,52) RS1/16SS0R0J C 1485 (B,56,5) CKSSYB104K10 C 1486 (B,53,5) CKSSYB104K10 R 1904 (A,90,59) RS1/16S0R0J C 1487 (B,51,5) CKSSYB104K10 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...
  • Page 114 C 1610 (A,53,39) CCSSCH101J50 u163 Pickup Unit(Service) CXX2118 C 1611 (A,53,37) CKSSYB562K25 Motor Unit(LOADING) CXC4912 C 1612 (A,55,36) CKSSYB224K6R3 Motor(STEPPING) CXM1364 C 1613 (A,55,37) CKSSYB224K6R3 Motor(SPINDLE) CXM1362 C 1614 (A,56,37) CKSSYB333K16 C 1615 (A,41,30) CKSRYB105K10 C 1616 (A,48,36) CKSSYB104K10 DVH-P5900MP/XN/EW5 http://www.xiaoyu163.com...

This manual is also suitable for:

Dvh-p590mp

Table of Contents