Download
Share
Print this page
Team C GT8LE Service Manual
  1. Manuals
  2. Brands
  3. Team C Manuals
  4. Motorized Toy Car
  5. GT8LE
  6. Service manual

Team C GT8LE Service Manual

1:8 scale ep 4wd touring car
Hide thumbs

Advertisement

Quick Links

Download this manual
1:8 Scale EP 4WD TOURING CAR
Dimensions
Length
......................................................................................................630mm
Width
......................................................................................................320mm
Height
......................................................................................................160mm
GT8LE

Advertisement

loading

Related Manuals for Team C GT8LE

Summary of Contents for Team C GT8LE

  • Page 1 GT8LE 1:8 Scale EP 4WD TOURING CAR Dimensions Length …………………………………………………………………………………………630mm Width …………………………………………………………………………………………320mm Height …………………………………………………………………………………………160mm...

  • Page 2: Transmitter Preparation

    Transmitter Preparation Power Switch 27MHzTransmitter Crystal Antenna Transmitter crystal(TX) Receiver crystal(RX) Extend the antenna to the maximum Length for best performance The crystal can be replaced to change frequencies. Note : You must also change receiver crystals! Do not use AM crystals Battery Level Indicator Good Batteries Straight (neutral)

  • Page 3: Tools Required

    Transmitter Preparation A new Ni-MH battery must be charged before it is used.Refer to the charger instruction manual for charging. Set up the radio control system as indicated below. Motor Battery Electronic Speed Controller DIGITAL PROPORTIONAL RADIO CONTROL SYSTEM Switch Transmitter Servo Receiver...
  • Page 4 Servo Saver Turnbuckle Approx.27mm TG8019 3x45 Turnbuckle …………1 T08666 M3 T08759 …………2 TG8019 T08620 3x45 Turnbuckle T08760 ……………………2 T08760 …………………1 T08674 M3x14 Screw T08759 ………1 T08674 M3x14 Buffer T08674 M3x14 T08650 Approx.8mm T08650 T08666 M3 T08762 Servo Saver-Top T08762 T08651 Buffer Screw ……2 T02081 3x7x0.8 Washer T08651...
  • Page 5 Servo Saver Post/Side Plate TG8003 Side Plate-Right T08840 Chassis T08650 Servo Saver Post TG8003 Side Plate-Left T08674 M3x8 T08674 M3x8 T08674 M3x8 Screw …………7 T08674 M4x10 Screw …………2 T08674 Screw M4x10 Cement T08674 Buffer Screw M4x10 Cement T08674 M3x14 T08673 M3x5 T08674 T08828 Screw...
  • Page 6 Front/Rear Differential T08636 M3x12 T08633 20T Diff Gear T08633 T08633 20T Diff Gear 2.5x11.5 Pin T08633 T08633 4.1x12x0.2 10T Diff Gear T08633 T08633 T08669 6.1x11x0.2 2.5x11.5 Pin Diff Shaft T08600 T08669 6.1x11x0.2 Differential Pads T08600 5.8x1.9 T08636 5.8x1.9 10000# for Front 5000# for Rear T08600 T08636...
  • Page 7 Front Swaybar T08756 T08756 T08760 T08756 Screw M3x3 Cement T08674 M2.5x8 Screw ………………3 T08601/T08756 M3x3 Screw ……………………4 T08756 6.8 Ball stud …………………2 T08601 T08755 6.8 Ball stud Swaybar Mount ………………………2 T08760 6.8 Ball End T08647 T08674 M2.5x8 ………………2 Front Swaybar T08601 M3x3 Front Hub Carrie T08604...
  • Page 8 Front Hub Carrie T08675 M4x10 T08607 Front Hub Carrier Bushing T08675 M4x10 Screw ……………2 T08673 M4x16 T08607 Front Hub Carrier Bushing ………4 T08607 T08673 M4x16 Screw Front Lower Arm ……4 T08673 M4x16 Front Suspension T08645 4x73 Arm Pin ……2 T08673 M3x16 T08674 M3x35 Screw T08827 T08674 M3x15...
  • Page 9 Front Shock Tower T08862 Screw M3.5x28 Cement T08622 Ball stud T08842 T08674 M3x12 Front Shock Tower T08674 M3x12 Screw T08622 Shock cap ball T08862 M3.5x28 Screw ……4 ……2 ………2 Front Upper Turnbuckle Front Upper-Left 1:1 x1 Approx.32mm T08757 7.8 Ball stud T08778 5x58 Turnbuckle 1:1 x1...
  • Page 10 Steering Turnbuckle T08754 Steering-Left 1:1 x1 6.8 Ball stud Approx.32.5mm T08753 T08760 6.8 Ball stud Steering-Right 1:1 x1 6.8 Ball End-Steering Approx.32.5mm T08776 4x53 Turnbuckle T08760 6.8 Ball End-Steering T08776 4x53 Turnbuckle T08760 6.8 Ball End-Steering T08753 6.8 Ball stud T08754 6.8 Ball stud ………2 ……………2...
  • Page 11 T08674 M4x10 Front Suspension T08674 M3x18 T08674 M3x18 T08666 M4 Nylon Nut ………………1 T08674 M3x18 Screw T08666 M4 ……2 T08674 M4x10 Screw …………3 T08674 T08674 M4x14 Screw M4x14 T08829 Front Bumper Plate-Lower ………4 T08674 T08674 M4x14 M4x10 Solid Axle Gear Set T08853 Screw M5x4...
  • Page 12 Solid Axle Gear Set T08673 M3x10 Screw T08673 Screw M3x10 Cement …………4 T08865 Center Differential Plate T08686 Center Differential Mount-Rear T08686 Motor Mount Motor Motor T08686 Motor Mount Tighten the screws with one sheet of paper inserted between both gears. T08686 M3x12 Screw H396 ……1...
  • Page 13 Solid Axle Gear Set T08674 M3x8 Screw ………………2 T08674 M4x10 Screw ……………4 T08681 Motor Mount T08674 M4x10 T08674 M3x8 Rear Differential Case T08849 128mm Center Rear CVD T08849 Screw M5x4 Cement T08663 T08601 Differential Case 6x13x5 T08663 6x13x5 Ball Bearing T08304 ………2 13.1x15.9x0.2...
  • Page 14 T08756 Rear Swaybar T08755 Screw M3x3 Cement T08756 T08760 T08601/T08756 M3x3 Screw ……………………4 T08601 M2.5x8 Screw ………………3 T08756 6.8 Ball stud-Swaybar T08601 Swaybar Mount …………………2 T08601 M2.5x8 T08647 T08755 6.8 Ball stud-Swaybar Rear Swaybar T08601 ………………………2 M3x3 Rear Hub Carrie T08640 T08640 T08649...
  • Page 15 Rear Suspension T08674 M3x35 T08613 Rear Arm Mount-R T08613 T08608 +1 Degree Bushing-Right T08646 4x77 T08613 T08666 M4 Nylon Nut +1 Degree Bushing-Left ………………2 T08673 M3x16 Screw ……2 T08674 M3x12 Screw T08674 M3x12 T08613 0 Degree Bushing …………2 T08666 M4 T08613 T08674 M3x35 Screw Rear Arm Mount-F...
  • Page 16 Rear Upper Turnbuckle Rear Upper-Left 1:1 x1 T08760 7.8 Ball End-Rear Upper T08760 T08758 7.8 Ball End-Rear Upper 7.8 Ball stud 1:1 x1 T08778 5x40 Turnbuckle T08757 7.8 Ball stud T08778 5x40 Turnbuckle T08758 7.8 Ball stud T08757 7.8 Ball stud T08760 7.8 Ball End-Rear Upper ………2 ………4...
  • Page 17 Rear Suspension T08666 M3 T08666 M3 Nylon Nut ……………1 T08674 M3x10 Screw ………1 T08674 M3x12 Screw ……1 T08674 M3x10 T08674 M4x14 Screw T08674 M3x12 T08674 …4 M4x14 Shock T08627 2.75mm Plastic Washer T08844/T08625 …………………4 Shock Bottom cover T08845 M2.5 T08627 1mm Plastic Washer T08627 T08627 ……………………4...
  • Page 18 Shock T08844/T08625 18.5x1.5 O-Ring ……………4 T08844/T08625 Shock Top cover Front-Short T08628 Front Shock Spring-Short Rear-Long T08622 Rear Shock Spring-Long Diaphragm Front-Short Rear-Long Front-Short T08844/T08625 18.5x1.5 Rear-Long T08622 Spring Mount T08844/T08625 Spring Adjuster Front Shock T08622 Plastic Bushing T08670 3.5x9x1 T08666 M3.5 Nylon Nut …………………2 T08666 M3.5...
  • Page 19 Rear Shock T08622 Plastic Bushing T08670 3.5x9x1 T08666 M3.5 Nylon Nut …………………2 T08666 M3.5 T08622 Plastic Bushing ………………………2 T08670 3.5x9x1 Washer …………………2 T08673 M3x18 Screw T08673 M3x18 ……2 T08673 M3x8 Front Bumper T08829 Front Bumper Plate-Upper T08830 Front Bumper Sponge T08673 M3x8 Screw ………………1 T08674 M3x10...
  • Page 20 Rear Bumper Plate T08666 M4 T08832 Rear Bumper Plate T08674 M4x12 Screw …………4 T08666 M4 Nylon Nut T08674 M4x12 ………………2 Body Mount T08833 M2.5x14 Screw …………4 T08863 M2.5x15 Screw …………4 T08833 Body Washer T08833 Body Washer T08833 M2.5x14 T08833 M2.5x14 T08833 Body Column-Long T08833...
  • Page 21 Front Body Mount T08673 M3x12 Screw M3x12 …………2 T08673 M3x12 Rear Body Mount T08673 M3x12 T08673 M3x12 Screw M3x12 …………2...
  • Page 22 Receiver/Servo T02087 T08674 M3x8 T08673 M3x8 Antenna Pipe T08614 Receiver Cover T02081 3x7x0.8 Washer ……………………4 Receiver T08673 M3x8 Screw ……………1 T08793 M3x15 Screw T08675 M3x5 …………4 T08674 M3x8 Screw ……………1 T08793 T08675 M3x5 Screw M3x15 …………………1 T02081 3x7x0.8 T08614 Receiver Box T08616 Servo Servo Mount...
  • Page 23 Battery T08821 Velcro Tape Battery T08821 Battery Mount Battery T08674 M3x8 Screw ………………8 T08674 M3x8 Must be purchased separately Assemble as many times as specified...
  • Page 24 Electronic speed controller Electronic speed controller T02087 Double-sided tape Tyre T08838 Tyre T08838 Right Sponge T08838 T08837 Tyre T08838 Sponge T08837 Left Must be purchased separately Assemble as many times as specified...
  • Page 25 Tyre Left Right Tyre T08649 17mm Hex Nut ……4 T08648 17mm Hex Nut Assemble as many times as specified Assemble both Left and Right...
  • Page 26 Body T08839 Body-Lexan Car Light / Wing T08839 Car Light T08839 Wing...
  • Page 27 Body T08839 Mask sticker Mask sticker the windows from the inside. Body Paint the body shell from the inside using spray colors.
  • Page 28 Car Light / Wing Paint the car light and wing from the inside using spray colors. Car Light Car Light Wing Mount T08839 M3x6 T08839 M3x6 T08839 T08839 Wing Adjust Wing Adjust T08839 Wing Mount Right T08839 M3x6 Screw Left M3x6 T08839 Wing Mount...
  • Page 29 Wing T08839 M3x6 T08839 M3x6 Screw T08839 ………………8 Wing T08839 M3x6 Body T08660 Mid Clip ……4 T08660 Mid Clip T08660 Mid Clip...
  • Page 31 Parts list for GT8LE 1/8 EP 4WD Touring Car-1 T08824 T08827 T08830 T08828 T08829 Buffer Plate-Plastic 1pcs 1pcs 1pcs 1pcs 1pcs Arm Mount Front-R Front Bumper Sponge Front Bumper Plate 1pcs 46T Gear Aluminium Buffer Plate-Black 1pcs T08833 T08835 T08837...
  • Page 32 Parts list for GT8LE 1/8 EP 4WD Touring Car-2 TG8019 T08603 TG8030 H396 T08600 King Pin Bushing 4pcs 1pcs 1pcs M3x6 Screw Differential Housing Differential Pads 3x45 Turnbuckle 1pcs 1pcs 8pcs 2pcs 16T Pinion Gear M4x4 Screw O-ring Front Hub Carriers 12 Degree...
  • Page 33 Parts list for GT8LE 1/8 EP 4WD Touring Car-3 T08663 T08664 T08665 T08666 M2.5 Nylon Nut M3.5 Nylon Nut M4 Nylon Nut 13x19x4 Ball Bearing 6x13x5 Ball Bearing 8x16x5 Ball Bearing M3 Nylon Nut 6pcs 6pcs 6pcs T08669 T08670 T08667...
  • Page 34 Parts list for GT8LE 1/8 EP 4WD Touring Car-4 T08760 T08759 T08762 T08763 1pcs 7.8 Ball End-Rear Upper 2pcs Rear Chassis Stiffener Mount 2pcs 6.8 Ball End-Swaybar 6.8 Ball End-Steering Top 1pcs 2pcs Left 1pcs Arm Mount Front-F 1pcs Bottom 5.8 Ball Stud-Steering Servo...
  • Page 35 Parts list for GT8LE 1/8 EP 4WD Touring Car-5 M3x12 Cap Head Screw TU0801 TU0802 TU0807 83001 M3x12 M3x14 Cap Head Screw T08219 2pcs 2pcs M3x18 Cap Head Screw T08220 M3x18 Mid Clip 511129 2pcs 2pcs Aluminium Motor Washer 4MM...
  • Page 36 Parts list for GT8LE 1/8 EP 4WD Touring Car-6 TU0879 H395 H397 H398 H399 Servo Saver Shaft-Aluminium M4x4 Screw M4x4 Screw 18T Pinion Gear 19T Pinion Gear M4x4 Screw M4x4 Screw 17T Pinion Gear 15T Pinion Gear 2pcs 1pcs 1pcs...
  • Page 37 GT8LE Driver Track / City Event Date SETUP SHEET for the TeamC GT8LE Track Condition Smooth Bumpy Low traction Med traction High traction Sandy Soft dirt Grass Hard soil Clay Dusty Other Front Suspension Front Shocks Shock Mounting&Camber link Anti-roll bar: Camber °...