Page 1
E : Europe X : Australia Figure is DVF-5400 (E) KENWOOD Corp. certifi es this equipment conforms to DHHS Regu- In compliance with Federal Regulations, following are reproduction lations No.21 CFR 1040. 10, Chapter 1, subchapter J. of labels on, or inside the product relating to laser product safety.
Page 2
Ensure that is displayed. TOKYO, JAPAN e Wait a few seconds, and then switch the system OFF. KENWOOD CORP. CERTIFIES THIS EQUIPMENT CONFORMS TO DHHS REGULATIONS NO. 21 CFR 1040.10, CHAPTER 1, SUBCHAPTER J. Operation to reset The microprocessor may fall into malfunction (impossibility to operate erroneous display, etc.) when the power cord is...
Page 3
DVF-5400 PARENTAL LOCK / DISASSEMBLY FOR REPAIR hole A (L3) FIG. 1-1 How to Reset Parental Lock 1. Connect the TV set to DVF-5400. FIG. 2-2 2. Push the power switch of DVF-5400 to be on. 3. Check the display of DVF-5400 shown “NO DISC”. 4.
Page 4
DISC V33A HDMI5V V33A IC603 IC604 CN601 ESMT_M12L64164A JK705 MX29LV160TTC 4M/16BIT CN602 HDMI DVD : A,B,C,D,RF 16/32BIT SDRAM Download CD : A,B,C,D,E,F,RF Jack FLASH ROM SPINDLE CD_DVD, VR_CD,VR_DV PICK MOTOR PICKSEL RAMAD[00:11] RAMCKE CD_LD,DVD_LD,V PCLK RAMBA RAMCS1 SLED RAMDQM LOADING (FEEDING) RAMWE MOTOR...
Page 7
1. POWER CHECK FLOW 2. SYSTEM OPERATION FLOW Power on No 5V No 3.3VA 1. 186 CPU initializes SERVO, DSP & RISC registers 2. Write RISC code to SDRAM 3. Reset RISC Is 3.3VA Is 3.3VA section working? section working? Show LOGO Tray closed? Is 3.3V...
Page 8
3. SYSTEM TEST FLOW TEST RESET or power on. Check the AC Replace power PCBA or AC transformer. Voltage power PCBA (110V or 220V) Check connection lines Flash between FLASH & ZR36888 memory operates Show LOGO? and the FLASH access time Switch on the power PCBA properly? whether is suitable or not.
Page 9
Check the laser power circuit LD_DVD or Laser Does the on ZR36888 and connecting Motor LD_CD output turns on when reading Check the connection line of SLED move driver MUTE pin to power transistor. properly? disc? to inner side when it is at MUTE signal.
Page 10
Proper Check connections between Normal Audio DAC Check connection between Focus on OK? signals on A, B, C, D of audio output when disc ZR36888 and pick-up head. received correct data ZR36888 & audio DAC. ZR36888 playback? stream? Check the FOCUS_S Check FE signal connection on ZR36888 Check the related...
Page 11
1. SYSTEM 27MHz CLOCK, RESET, FLASH R/W SIGNAL 2. SDRAM CLOCK 1) ZR36888 main clock is at 27MHz (X601) 1) SDRAM clock is at 143MHz CLK=143MHz, Vp-p=3.3V IC603 38PIN 3.1V, 27MHz FIG 1-1 FIG 2-1 3. TRAY OPEN/CLOSE SIGNAL 2) ZR36888 reset is low active 1) Tray open/close waveform 3.3VA OPEN...
Page 12
2) Tray open waveform 4. SLED CONTROL RELATED SIGNAL (NO DISC CONDITION) SLED_S OPEN DRVSB CLOSE SLED+ SLED- FIG 3-2 FIG 4-1 3) Tray close waveform 5. LENS CONTROL RELATED SIGNAL (NO DISC CONDITION) FOCUS_S OPEN FOCUS+ CLOSE FOCUS- FIG 3-3 FIG 5-1 Note: Refer to Schematic Diagram on waveform’s check point.
Page 13
6. LASER POWER CONTROL RELATED SIGNAL (NO DISC CONDITION) VR_CD FACT+ DVD_LD CD_LD SBAD FIG 6-1 FIG 7-2 (DVD) 7. DISC TYPE JUDGEMENT WAVEFORM FACT+ FACT+ SBAD SBAD FIG 7-1 (DVD) FIG 7-3 (CD) Note: Refer to Schematic Diagram on waveform’s check point.
Page 14
FACT+ FOCUS FACT+ SBAD FACT- FIG 7-4 (CD) FIG 8-2 (CD) 8. FOCUS ON WAVEFORM 9. SPINDLE CONTROL WAVEFORM (NO DISC CONDITION) SPINDLE_S FOCUS FACT+ FACT- FIG 9-1 (DVD) FIG 8-1 (DVD) Note: Refer to Schematic Diagram on waveform’s check point.
Page 15
10. TRACKING CONTROL RELATED SIGNAL (SYSTEM CHECKING) 11. RF WAVEFORM TRACK_S TACT+ TACT- FIG 10-1 (DVD) FIG 11-1 12. ZR36888 AUDIO OPTICAL AND COAXIAL OUTPUT (SPDIF) TRACK_S TACT+ TACT- FIG 10-2 (CD) FIG 12-1 Note: Refer to Schematic Diagram on waveform’s check point.
Page 16
13. ZR36888 VIDEO OUTPUT WAVEFORM 3) C 1) Full colorbar signal (CVBS) JK701 14PIN JK701 2PIN FIG 13-1 FIG 13-3 2) Y 14. AUDIO OUTPUT FROM AUDIO DAC 1) AUDIO L/R 1kHz 0dB JK701 13PIN JK701 5, 8PIN FIG 13-2 FIG 14-1 Note: Refer to Schematic Diagram on waveform’s check point.
Page 17
2) Audio Related Signal AOUT0 ABCK ALRCLK FIG 14-2 Note: Refer to Schematic Diagram on waveform’s check point.
Page 18
DVF-5400 PC BOARD COMPONENT/PROGRESSIVE SCAN MAIN (SIDE A) DIGITAL AUDIO HDMI OUTPUT OUTPUT VIDEO DIGITAL AUDIO COAXIAL AUDIO JK705 OUTPUT JK703 JK701 C7E2 C741 Q706 Q713 Q708 Q712 Q705 Q716 C6A7 R715 Q711 C706 X601 C787 Q715 C6A6 CN702 C727 RA701 IC701 RA702...
Page 21
CONDENSER AND TR VOLTAGE CHECK STOP PLAY STOP PLAY STOP PLAY STOP PLAY STOP PLAY STOP PLAY STOP PLAY IC201 1.61 1.89 1.28 1.62 2.64 3.14 3.34 3.18 3.33 3.34 0.01 0.05 1.88 2.15 3.34 3.31 0.01 3.38 PLAY 1.67 1.67 0.01 0.01...
Page 22
DVF-5400 MAIN : WAVEFORM POINT (Refer to Service Manual) +3.3V +3.3VD CN601 DUPTD0 DUPRD0 +1.8V +1.8V IC605 R229 R230 +3.3VA R624 MOTOR DRIVE IC201 TP602 CN602 MUTE TP601 R629 VINFC DUPTD1 BIAS Q203 TRB 1 DUPRD1 VINTK E2PROM REGO 2 TRB 2 OPOUT VINSL+...
Page 26
DVF-5400 TIMER DIG901 DIG.1 DIG.2 DIG.3 DIG.4 DIG.5 RC901 REMOTE SENSOR SW902 R904 OPEN/CLOSE SW904 IC901 R905 PLAY CN901 D OUT DOUT D IN RESOLUTION SW903 MAIN- CN604 SW905 +3.3VA SG14/GR5 R901 STOP L901 SG1/KS1 SG13/GR6 SW906 SG2/KS2 SG12/GR7 SG3/KS3 SG11 R906 SG10/KS10...
Page 27
DVF-5400 EXPLODED VIEW (MECHANISM) 1.7x7 N09-5550-08 1.7x3 N09-5565-08 2.0x6 (BLK) N89-2006-43 DVF-5400 Parts with the exploded numbers larger than 700 are not supplied.
Page 29
Add- Desti- Parts No. Description Ref. No. Parts No. Description ress Parts nation marks ress Parts nation marks DVF-5400-S (S) / DVF-5400-B (B) C7E2 CD04BJ1C220M ELECTRO 22UF 16WV C7F3 CD04BJ1C101M ELECTRO 100UF 16WV ✽ B60-5683-08 Inst.manual (EN) MFL36465761 C7E4 CD04BJ1C470M...
Page 30
✽ New parts ✽ New parts Parts without Parts No. are not supplied. Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No.
Page 31
✽ New parts ✽ New parts Parts without Parts No. are not supplied. Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No.
✽ New parts ✽ New parts Parts without Parts No. are not supplied. Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No.
2. Full performance is not guaranteed in extremely cold (C-signal) environments (under water-freezing temperatures). NTSC ............0.286 Vp-p (75 Ω) PAL ............0.300 Vp-p (75 Ω) HOW TO READ THE PARTS LIST ABBREVIATION OF MODEL AND MASS PRODUCTION’S DESTINATIONS Australia Europe MODEL ABB. DVF-5400-B DVF-5400-S...