1. Manuals
  2. Brands
  3. Sony Manuals
  4. Subwoofer
  5. XS-AW81P5
  6. Service manual

Sony XS-AW81P5 Service Manual

Hide thumbs Also See for XS-AW81P5:
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL
Ver 1.0 2004.05
Speaker section
Woofer
Impedance
Power amplifier section
Circuit system
Inputs
Maximum outputs
Rated outputs
Input level adjustment range
Harmonic distortion 0.03 % or less (at 100 Hz)
Low-pass filter
Sony Corporation
9-877-786-01
e Vehicle Company
2004E05-1
Published by Sony Engineering Corporation
© 2004.05
XS-AW81P5
SPECIFICATIONS
20 cm, cone type
4 ohms
OTL (output
transformerless) circuit
Pulse power supply
RCA pin jacks
High level input
200 watts
100 watts (150 Hz, 0.1 %
THD)
0.2 − 4.0 V (when using
RCA pin jacks)
0.4 − 8.0 V (when
connecting high level input)
cut-off frequency 50 −
200 Hz (variable), −12 dB/
oct
System Section
Power requirements 12 V DC car battery
(negative earth)
Power supply voltage
10.5 − 16 V
Current drain
at rated output: 13 A
Remote input: 1.5 mA
Approx. 386.3 × 310 × 335
Dimensions
mm (w/h/d)
Mass
Main unit
Approx. 14.2 kg not incl.
accessories
Supplied accessories Remote level controller (1)
Parts for installation and
connections (1 set)
Design and specifications are subject to change
without notice.
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
ACTIVE SUBWOOFER
AEP Model
UK Model

Advertisement

Table of Contents
loading

Related Manuals for Sony XS-AW81P5

Summary of Contents for Sony XS-AW81P5

  • Page 1 Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. ACTIVE SUBWOOFER Sony Corporation 9-877-786-01 e Vehicle Company 2004E05-1 Published by Sony Engineering Corporation © 2004.05...

  • Page 2: Section 1 General

    Om du har frågor eller problem av ett slag som manual, please consult your nearest Sony dealer. manual no trate, consulte con el distribuidor Sony d’emploi, consultez votre revendeur Sony. inte täcks av den här bruksanvisningen kontaktar más próximo.

  • Page 3: Installation

    Si cela se produit, éloignez l’appareil d’au • Utilice solamente la ferretería de montaje safe and secure installation. påverkades. • Consult your nearest Sony dealer for the moins 50 cm de l’appareil affecté. • Använd bara de medföljande suministrada para que la instalación sea segura •...
  • Page 4 XS-AW81P5 Installing the remote Installation du Instalación del Installation av level controller contrôleur de niveau de controlador de nivel nivåfjärrkontrollen télécommande remoto Install the remote level controller in places where Placera nivåfjärrkontrollen någonstans där den it will not hinder the operations of the steering inte utgör ett hinder för rattrörelserna,...
  • Page 5 XS-AW81P5 Connections Raccordement Conexiones Anslutningar Read all connection instructions for Lisez toutes les instructions de Lea todas las instrucciones de Innan du utför några anslutningar this subwoofer and any attached raccordement de ce haut-parleur conexión correspondientes a este bör du ha läst igenom components before making any d’extrêmes-graves et de tout autre...

  • Page 6: Power Connections

    XS-AW81P5 Power connections Raccordement de Conexiones de Strömanslutningar l’alimentation alimentación Remote output (REM OUT) Blue/White striped Sortie de télécommande (REM OUT) Rayé bleu/blanc XS-AW81P5 Salida remota (REM OUT) Con raya azul/blanca Car audio Utgång för fjärranslutning (REM OUT) Blåvitrandig Autoradio Sistema de audio de automóvil...

  • Page 7: Section 2 Disassembly

    XS-AW81P5 SECTION 2 DISASSEMBLY • This set can be disassembled in the order shown below. 2-1. DISASSEMBLY FLOW 2-2. SPEAKER (20cm) 2-3. AMP BOARD (Page 7) (Page 8) Note: Follow the disassembly procedure in the numerical order given. 2-2. SPEAKER (20cm) 2 six screws (K3 ×...

  • Page 8: Amp Board

    XS-AW81P5 2-3. AMP BOARD 1 seven screws (+P) 2 side panel 3 two connectors 4 four screws (B4 × 14) 5 AMP board...
  • Page 9 XS-AW81P5 SECTION 3 DIAGRAMS • Note for Printed Wiring Boards and Schematic Diagrams • IC Block Diagram IN901 µPC494GS Note on Printed Wiring Board: Note on Schematic Diagram: • X : parts extracted from the component side. • All capacitors are in µF unless otherwise noted. (p: PF) •...

  • Page 10: Printed Wiring Board

    XS-AW81P5 3-2. PRINTED WIRING BOARD • Semiconductor Location Ref. No. Location AMP BOARD SP101 D101 D102 – D103 D801 D802 D903 D904 D907 (CHASSIS) (CHASSIS) D908 D910 D911 D912 D913 R141 D914 T901 IC801 DC/DC IC802 CONVERTER IC803 IC901 IC902...

  • Page 11: Schematic Diagram

    XS-AW81P5 • See page 9 for Waveforms • See page 9 for IC Block Diagram. 3-3. SCHEMATIC DIAGRAM D102 DAN202K R122 R123 R124 R132 1.5k 1.5k Q104,105 DRIVE AMP Q108-111 R117 Q104 FINAL C901 2SA965 DRIVE CNJ801 C120 LOW-PASS FILTER...
  • Page 12 XS-AW81P5 MEMO...

  • Page 13: Section 4 Exploded View

    XS-AW81P5 SECTION 4 EXPLODED VIEW NOTE: • -XX and -X mean standardized parts, so they • Items marked “*” are not stocked since they may have some difference from the original are seldom required for routine service. Some one. delay should be anticipated when ordering •...

  • Page 14: Section 5 Electrical Parts List

    XS-AW81P5 SECTION 5 ELECTRICAL PARTS LIST NOTE: • Items marked “*” are not stocked since they • Due to standardization, replacements in the When indicating parts by reference number, please include the board. parts list may be different from the parts are seldom required for routine service.
  • Page 15 XS-AW81P5 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D904 8-719-025-50 DIODE 02CZ16-TE85L Q909 6-550-341-01 TRANSISTOR FKV550N D907 6-500-209-01 DIODE FCH08A15 D908 6-500-210-01 DIODE FRH08A15 Q910 8-729-207-82 TRANSISTOR 2SC3421-Y D910 8-719-801-78 DIODE 1SS184 Q911 8-729-207-89 TRANSISTOR...

  • Page 16: Manual, Instruction

    XS-AW81P5 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < THERMISTOR > R805 1-208-827-11 METAL CHIP 0.5% 1/10W R806 1-216-687-11 METAL CHIP 0.5% 1/10W TH901 1-804-301-11 THERMISTOR, CHIP R807 1-216-206-00 RES-CHIP 2.2K 1/8W TH902 1-804-301-11 THERMISTOR, CHIP...
  • Page 17 XS-AW81P5 MEMO...

  • Page 18: Revision History

    XS-AW81P5 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision...

Table of Contents