Page 2
(4) damage to or loosening of hinges before the oven is released to the and latches, owner. (e) A microwave leakage check should be (5) evidence of dropping or abuse. performed on each oven prior to release to the owner. Samsung Electronics...
Primary and door sensing switches, as well as the Interlock Monitor Switch. The correct adjustment of these switches is described elsewhere in this manual. Make sure that the fuse has the correct rating for the particular model being repaired. Samsung Electronics...
DO NOT measure the voltage in the high voltage circuit including filament voltage of magnetron. PRECAUTION Never touch any circuit wiring with your hand nor with an insulated tool during operation. PRECAUTION Servicemen should remove their watches whenever working close to or replacing the magnetron. Samsung Electronics...
2. Specifications 2-1 Table of Specifications (CM1219 / CM1229) MODEL CM1219 CM1229 ITEM TIMER Max. 25 min Max. 25 min POWER SOURCE 230V/50HZ, AC 230V/50HZ, AC POWER CONSUMPTION MICROWAVE : 2,200W MICROWAVE : 2,200W OUTPUT POWER 230V: 1,200W (IEC-705) 230V: 1,200W (IEC-705)
3. Operating Instructions 3-1 Features (CM1219) VARIABLE COOKING POWER CONTROL DIAL TIMER DIAL OVEN LAMP (230V 25W) +20sec PAD DISPLAY STOP/CANCEL PAD OVEN LAMP COVER START BUTTON DOOR HANDLE CEILING COVER SAFETY INTERLOCK HOLES DOOR DOOR LATCHES PLATE TRAY AIR FILTER...
Page 7
5. POWER LEVEL SELECTOR PAD 6. DEFROST SELECTOR PAD 7. DOUBLE QUANTITY PAD 8. +20sec PAD (ONE TOUCH COOK PAD) 9. STOP/CANCEL PAD 10. START BUTTON 3-4 External Views (CM1219 / CM1229) 3-4-1 External Views (CM1219) 1000 3-4-2 External Views (CM1229) 1000 Samsung Electronics...
Page 8
Operating Instructions 3-5 Operation Guide (CM1219) Cooking/Reheating 1. Make sure the oven is plugged into a properly earthed electrical outlet and ‘ON’ appears in the display window. 2. Open the door. The oven lamp will be turned on. 3. Put the food into a suitable container, place it in the center of the oven and then close the door securely.
Page 9
Operating Instructions 3-5 Operation Guide (CM1219 continued) To stop the cooking You can stop cooking at any time so that you can: • Check the food • Turn the food over or stir it • Leave it to stand * Temporarily ; Open the door or press button once.
Page 10
‘ON’ appears again. Food may be removed from oven whilst the fan is still running. 8. Open the door and take the food out. 9. Close the door. The oven lamp will go off. Samsung Electronics...
Like traditional cooking, you may find that, depending on the food’s characteristics or your tastes, you have to adjust the cooking times slightly. Before operating the oven, times can be increased/decreased using either the time pads or +20sec button. During the operating, time may only be added by using the +20sec button. Samsung Electronics...
Memory programs are available up to 30 items. Make sure the unit is properly programmed. After programming is finished, all you have to do for memory cooking is to press the NUMBER pad. Then the selected memory program automatically starts cooking. Samsung Electronics...
Result: Cooking stops. To resume cooking, close the door and press again. * Completely: Press the pad twice. Result: The cooking settings are cancelled. If you want to cancel any cooking settings before starting cooking, simply press CANCEL pad once. Samsung Electronics...
Page 14
Operating Instructions 3-5 Operation Guide (CM1219 / CM1229) Power Levels and Time Variations The power level function enables you to adapt the amount of energy dissipated and thus the time required to cook or reheat your food, according to its type and quantity. You can choose between the power levels below.
4-2 Replacement of High Voltage Transformer 1. Discharge the high voltage capacitor. 2. Disconnect all the leads. 3. Remove the mounting bolts securing the HVT. 4. Reconnect the leads correctly and firmly. H. V. Trans 4 Mounting Bolts Samsung Electronics...
2. Adjust so that the door has no play between the inner door surface and oven front surface. If the door assembly is not mounted properly, microwave energy may leak from the space between the door and oven. 3. Do the microwave leakage test. Samsung Electronics...
Page 17
If any of them are deformed, abnormal symptom can happen such as arcing or sparks during operation. Ass’y Stirrer Ass’y Stirrer Cover Plastic Clips Samsung Electronics...
Page 18
Wire Harness-B Main P.C.Board (PCB1) Wire Harness-C Digitron(PCB4) Panel-Base Wire Harness-D PCB2 Button-Select Button-Start Main P.C.Board (PCB1) Control Box Ass’y (CM1219) Wire Harness-C Digitron(PCB4) Wire Harness-B Panel Base Wire Harness-F Window-Display Cover Panel PCB3 Cover-Panel/L Switch-Membrane Control Box Ass’y Cover-Panel/R...
3. Replace with a new lamp by rotating it counter- clockwise. Lamp Holder Lamp Cover NOTE : If it is necessary to replace the lamp holder, you can disconnect lead wires by pushing down on the hole of lead wires using a long pointed tool. Outer Panel Samsung Electronics...
Page 20
NOTE: It is not necessary to remove Magnetron in order to remove HVC. 1. Remove the outer panel and back cover. 2. Discharge the high voltage capacitor. 3. Remove HVT wire and H.V.Fuse. 4. Remove screws securing HVC bracket. H.V.Capacitor Samsung Electronics...
2. Once the capacitor is charged, a normal capacitor shows continuity for a short time, and then indicates 9MΩ. 3. A shorted capacitor will show continuous continuity. 4. An open capacitor will show constant 9MΩ. 5. Resistance between each terminal and chassis should read infinite. Samsung Electronics...
Door Open Door Closed procedures. ∞ Primary S/W ∞ 4. Confirm that the gap between the switch housing Monitor S/W(COM-NC) ∞ Monitor S/W(COM-NO) and the switch actuator is no more than 0.5mm ∞ Door Sensing S/W when door is closed. Samsung Electronics...
3. After moving the water into another glass vessel, place it in the center of the cooking tray. Set the oven to high power and operate for 26 seconds for CM1219/1229 exactly. (3 secondsincluded as a holding time of magnetron oscillation) 4.
; CENTRAL SERVICE CENTER 3) At least once a year have the microwave energy survey meter checked for accuracy by its manufacturer. Thermistor Sensor Temperature Samsung Electronics...
2. Defective high voltage components Check high voltage component (No heat while oven lamp H.V.Transformer according to component test procedure and fan motor turn on.) H.V.Capacitor and replace if defective. H.V.Diode, H.V.Fuse Magnetron Samsung Electronics...
Page 26
Oven can program but Defective circuitry of Start function Check circuitry of Start function timer does not start. of Main PCB Ass’y. of Main PCB Ass’y and replace if defective. Loose lead wires Adjust or repair loose wires. Samsung Electronics...
Page 27
Check the circuitry. (Refer to Operating Sequence circuit failure as shown in page 42.) 1. Memory IC (EEPROM IC) failure Check Memory IC (IC3) and replace if defective. CM1229 2. MICOM failure Replace Assy Main PCB or MICOM. Samsung Electronics...
Page 31
Exploded Views and Parts List Exploded Views and Parts List Exploded Views and Parts List Exploded Views and Parts List 7-3 Exploded View & Parts List - Control & Door(CM1219) MD06 MD08 MD04 MC22 MC20 MD15 MD01 MD17 MC21 MD10...
Page 35
8. P.C.B Circuit Diagrams and Parts List 8-1 P.C.B Circuit Diagram (CM1219) Samsung Electronics...
Page 36
P.C.B Circuit Diagrams and Parts List P.C.B Circuit Diagrams and Parts List 8-2 P.C.B Circuit Diagram (CM1229) 8-2 P.C.B Circuit Diagram (CM1229) 8-2 P.C.B Circuit Diagram (CM1229) 8-2 P.C.B Circuit Diagram (CM1229) Samsung Electronics Samsung Electronics Samsung Electronics Samsung Electronics...
Page 37
P.C.B Diagrams and Parts List P.C.B Diagrams and Parts List P.C.B Diagrams and Parts List P.C.B Diagrams and Parts List 8-3 P.C.B Parts List (CM1219) Part Code Description Specification Q'ty Remark 0604-000237 PHOTO-COUPLER TR,50-600%,200mW,DIP-4,ST IC4,IC5 3002-000198 BUZZER-PIEZO 80dB,-,-,4KHz,ST BUZ1 3406-001031 SWITCH-ROTARY 10V,1mA,DP24T,18.3mm...
1 and 2 is 30 seconds. The relation between indications on the display window and the output power of the microwave oven is as shown in figure below. CM1219 / CM1229 c(d): 30% -> opt short - 9sec(6sec) 15% -> opt short - 5sec(10sec)
Page 42
In case of Power Relay 2 (RY5), check the waveform (C), (D) below. In case of Power Relay 2 (RY5), check the waveform (C), (D) below. In case of Power Relay 2 (RY5), check the waveform (C), (D) below. Samsung Electronics...