Sony HCD-GR5 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Stereo System
  5. HCD-GR5
  6. Service manual
Sony HCD-GR5 Service Manual

Sony HCD-GR5 Service Manual

Hide thumbs Also See for HCD-GR5:
Table of Contents

Advertisement

Quick Links

QQ
3 7 63 1515 0
SERVICE MANUAL
HCD-GR5/RX50 is the tuner, deck, CD
and amplifier section in MHC-GR5/RX50.
Dolby noise reduction manufactured under license from
Dolby Laboratories Licensing Corporation.
"DOLBY" and the double-D symbol a are trademarks
of Dolby Laboratories Licensing Corporation.
TE
L 13942296513
CD player section
System
Compact disc and digital
audio system
Laser
Semiconductor (λ = 780nm)
Emission duration:
continuous
Laser output
Max 44.6 µW*
*This output is the value
measured at a distance of
200mm from the objective
lens surface on the Optical
Pick-up Block with 7mm
aperture.
Wavelength
780 – 790 nm
Frequency response
2 Hz – 20 kHz (±0.5 dB)
Signal-to-noise ratio
More than 90 dB
Dynamic range More than 90 dB
CD DIGITAL OPTICAL OUTPUT
(Square optical connector jack,rear panel)
Wavelength
600nm
Output level
-18dBm
Tuner section
FM stereo, FM/AM superheterodyne tuner
www
FM tuner section
East European model:
65.0 – 75.0 MHz,
.
87.5 – 108.0 MHz
MICROFILM
http://www.xiaoyu163.com
HCD-GR5/RX50
SECTION
SECTION
x
ao
u163
y
i
http://www.xiaoyu163.com
2 9
8
Photo: HCD-GR5
Model Name Using Similar Mechanism
CD
CD Mechanism Type
Base Unit Type
Optical Pick-up Type
Q Q
3
6 7
1 3
1 5
TAPE
Model Name Using Similar Mechanism
DECK
Tape Transport Mechanism Type
SPECIFICATIONS
Tourist model:
Other models:
Aerial
Aerial terminals 75 ohm unbalanced
Intermediate frequency
AM tuner section
Tuning range
AEP, UK, East European models:
German models:
EA4,Thailand models:
COMPACT DISC DECK RECEIVER
co
.
— 1 —
9 4
2 8
AEP Model
UK Model
Tourist Model
HCD-H551
CDM28-5BD19
BU-5BD19
KSS-213BA/F-NP
0 5
8
2 9
9 4
HCD-H551
TCM-220WR2E
76.0 – 108.0 MHz
87.5 – 108.0 MHz
FM lead aerial
10.7 MHz
MW: 531 – 1,602 kHz (with
the interval set at 9 kHz)
LW: 153 – 279 kHz (with
the interval set at 3 kHz)
531 – 1,602 kHz (with
the interval set at 9 kHz)
531 – 1,710 kHz(with
the interval set at 9 kHz)
530 – 1,710 kHz(with
the interval set at 10 kHz)
— Continue on next page —
m
9 9
HCD-RX50
E Model
HCD-GR5
2 8
9 9

Advertisement

Table of Contents
loading

Related Manuals for Sony HCD-GR5

Summary of Contents for Sony HCD-GR5

  • Page 1 AEP Model UK Model HCD-RX50 E Model Tourist Model HCD-GR5 HCD-GR5/RX50 is the tuner, deck, CD and amplifier section in MHC-GR5/RX50. Photo: HCD-GR5 Dolby noise reduction manufactured under license from Model Name Using Similar Mechanism HCD-H551 Dolby Laboratories Licensing Corporation.
  • Page 2 Tape player section Recording system 4-track 2-channel stereo Frequency response (DOLBY NR OFF) 40 – 13,000 Hz (±3 dB), using Sony TYPE I cassette 40 – 14,000 Hz (±3 dB), using Sony TYPE II cassette Wow and flutter 0.3% W.RMS (NAB) u163 —...
  • Page 3 LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. u163 — 3 — http://www.xiaoyu163.com...

  • Page 4: Table Of Contents

    http://www.xiaoyu163.com TABLE OF CONTENTS 3 7 63 1515 0 1. SERVICING NOTE ............ 5 2. GENERAL ..............6 3. DISASSEMBLY 3-1. Front Panel ............... 8 3-2. TC Mechanism Deck ............8 3-3. HP Board, JOG Board and PANEL Board ...... 9 3-4.

  • Page 5: Servicing Note

    http://www.xiaoyu163.com SECTION 1 3 7 63 1515 0 SERVICING NOTE NOTES ON LASER DIODE EMISSION CHECK NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser beam on this model is concentrated so as to be focused on The laser diode in the optical pick-up block may suffer electrostatic the disc reflective surface by the objective lens in the optical pick- break-down because of the potential difference generated by the...

  • Page 6: General

    http://www.xiaoyu163.com SECTION 2 This section is extracted from GENERAL 3 7 63 1515 0 instruction manual. @ª ª / · (reverse side play / Rear Panel Index to Parts and Controls front side play) button #º p (stop) button (AEP, UK, German, East European models) #¡...
  • Page 7 http://www.xiaoyu163.com 3 7 63 1515 0 Display Window Remote (RM-SD50) 2 3 4 56789 0 !¡ DOLBY NR 12 REC SLEEP B OFF RELAY DBFB SUR 12 TUNED MONO STEREO 11 12 13 14 15 ALL PROGRAM 1DISK S SHUFFLE 16 17 18 19 20 MANUAL !¡...

  • Page 8: Disassembly

    http://www.xiaoyu163.com SECTION 3 DISASSEMBLY 3 7 63 1515 0 Note: Follow the disassembly procedure in the numerical order given. 3-1. FRONT PANEL 4 Two screws (+BVTP2.6X8) 1 Remove the connectors (MAIN board: CN402, CN702) (HP board: CN513) CN402 CN702 CN513 L 13942296513 2 Two screws (+BVTT3X8)

  • Page 9: Hp Board, Jog Board And Panel Board

    http://www.xiaoyu163.com 3 7 63 1515 0 3-3. HP BOARD, JOG BOARD AND PANEL BOARD * Note: It will be easy to remove if you push lightly from the hole of the JOG board with some screwdrivers or etc. Screw driver 3 Nut 4 Nut 1 Knob (VOL) * Note...

  • Page 10: Cd Block

    http://www.xiaoyu163.com 3 7 63 1515 0 3-4. CD BLOCK 4 CD block 3 Two screws (CD mechanism deck 1 Remove the connectors (+BVTP3X8) and CD chassis) (MAIN board: CN201) (LOADING board: CN291) CN291 2 PC board holder CN201 L 13942296513 3-5.

  • Page 11: Mechanical Adjustments

    http://www.xiaoyu163.com SECTION 4 SECTION 5 MECHANICAL ADJUSTMENTS 3 7 63 1515 0 ELECTRICAL ADJUSTMENTS Precaution DECK SECTION 0 dB=0.775V 1. Clean the following parts with a denatured alcohol-moistened swab: 1. Demagnetize the record/playback head with a head damagnetizer. record/playback heads pinch rollers 2.
  • Page 12 http://www.xiaoyu163.com 3 7 63 1515 0 Procedure: Tape Speed Adjustment (Deck A) 1. Mode : Playback 2. Turn the adjustment screw and check output peaks. If the peaks Note: Start the Tape Speed adjustment as below after setting the do not match for L-CH and R-CH, turn the adjustment screw so test mode.
  • Page 13 http://www.xiaoyu163.com 3 7 63 1515 0 Record Bias Adjustment (Deck B) Record Level Adjustment (Deck B) Procedure: Procedure: 1. Press FUNCTION button to Select MD. 1. Press FUNCTION button to Select MD. 2. Mode: Record 2. Mode: Record MD IN 1) 315Hz MD IN 50 mV (–23.8 dB)

  • Page 14: Tuner Section

    http://www.xiaoyu163.com 3 7 63 1515 0 TUNER SECTION 0dB=1µV Note: 1. As a front-end (FE1) is difficult to repair if faulty, replace it with new one. 2. No adjustment is needed due to a tuner pack. AM Tuned Level Adjustment Note: FM Tuned Level adjustment should be performed after this AM Tuned Level Adjustment.
  • Page 15 http://www.xiaoyu163.com 3 7 63 1515 0 Adjustment Location: SW OSC Voltage Adjustment (Tourist model) [TCB BOARD] — Component Side — Setting: Band: SW D1, CV2, T2 Procedure: SW OSC Voltage 1. Connect digital Voltmeter to diode D1 center lead and ground. Adjustment 2.

  • Page 16: Cd Section

    http://www.xiaoyu163.com 3 7 63 1515 0 S Curve Check CD SECTION Procedure : oscilloscope Note: 1. CD Block is basically designed to operate without adjustment. BD board Therefore, check each item in order given. TP (FEO) 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. TP (VC) 3.
  • Page 17 http://www.xiaoyu163.com 3 7 63 1515 0 E-F Balance Check Adjustment Location: oscilloscope [BD BOARD] — Component Side — BD board TP (TEO) RV101 TP (VC) IC101 Procedure: RV103 1. Connect test point TP703 (ADJ2) on MAIN board to Ground with a lead wire. 2.

  • Page 18: Diagrams

    HCD-GR5/RX50 SECTION 6 3 7 63 1515 0 DIAGRAMS 6-1 BLOCK DIAGRAMS - CD SECTION - OPTICAL PICK-UP BLOCK X101 DIGITAL OUT IC200 16.9344MHz IC101 (1/2) OPTICAL FOCUS/TRACKING SERVO IC104 EFM COMPARATOR DIGITAL FILTER DETECTOR D/A CONVERTER 5 • 6...

  • Page 19: Main Section

    HCD-GR5/RX50 3 7 6 3 1 5 1 5 0 — MAIN SECTION — IC601 EXCEPT AEP,UK,G,EE MIC AMP J601 J201 SUPER R-CH WOOFER R-CH J801 IC802 INPUT SELECTOR IC1201 POWER AMP TM1201 (AUDIO) SPEAKER RY1201 – Q1207 RELAY DRIVE...

  • Page 20: (Aep,Uk,German,East European Model)

    HCD-GR5/RX50 3 7 6 3 1 5 1 5 0 — TUNER SECTION — — TUNER SECTION — (Tourist MODEL) (AEP,UK,German,East European MODEL) ST +10V ST +10V AEP,UK,G MODEL OUT L AMP IN L AMP OUT L AM / FM...

  • Page 21: Deck Section

    HCD-GR5/RX50 3 7 6 3 1 5 1 5 0 — DECK SECTION — 6-2. CIRCUIT BOARDS LOCATION TCB board (AED, UK, G, EE, JE) PB A/B TRANSFORMER board FM/AM TUNER ENCAPSULATED COMPONENT CN403 S1004 S1008 (EXCEPT AEP,UK,G,EE,JE) A CrO2...
  • Page 22 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...

  • Page 23: Q Q

    http://www.xiaoyu163.com w w w http://www.xiaoyu163.com...
  • Page 24 http://www.xiaoyu163.com w w w http://www.xiaoyu163.com...
  • Page 25 http://www.xiaoyu163.com w w w http://www.xiaoyu163.com...
  • Page 26 http://www.xiaoyu163.com w w w http://www.xiaoyu163.com...
  • Page 27 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
  • Page 28 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
  • Page 29 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
  • Page 30 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
  • Page 31 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...
  • Page 32 http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 http://www.xiaoyu163.com...

  • Page 33: Tel 13942296513

    http://www.xiaoyu163.com 3 7 63 1515 0 6-14. IC PIN FUNCTIONS • IC501 GRAPHIC CONTROL (µPD78042FGF-027-3B9) Function Pin No. Pin Name Fluorescent indicator tube grid signal output. 1 to 7 GR7 to 1 – 9, 10 LED9, 10 LED drive signal output Not used.

  • Page 34: Ic701 Master Control (Tmp87Cp64Yf-6521)

    http://www.xiaoyu163.com 3 7 63 1515 0 • IC701 MASTER CONTROL (TMP87CP64YF-6521) Pin Name Pin No. Function – Ground XOUT X’tal (10 MHz). RESET Reset signal input. XOUT X’tal for clock (32.768 KHz). – Ground GND (test) Back up signal input. AC CUT Not used.
  • Page 35 http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function AUB IN Audio bus in/output. (Not used) (Open) AUB OUT FOCUS SW Focus switching signal output. SQ-CLK Subcode Q data read clock output. SQ-DATA Subcode Q data input. X-LAT Latch signal digital signal processor.
  • Page 36 http://www.xiaoyu163.com 3 7 63 1515 0 Pin Name Pin No. Function NORM NORMAL/HIGH control signal output. BIAS OFF Bias oscillation output. REC MUTE Mute output. NR OFF Dolby ON/OFF signal output. REC/PB control signal output. PASS. AMP/DOLBY Dolby switching signal output. LINE MUTE ON Mute signal output for deck.

  • Page 37: Ic Block Diagrams

    http://www.xiaoyu163.com 3 7 63 1515 0 6-15. IC BLOCK DIAGRAMS - BD BOARD Section - IC101 CXA1782BQ – LEVELS 24 SENS – MIRR RF IV AMP1 DFCT 23 C. OUT – 22 XRST RF IV AMP2 21 DATA L 13942296513 FE BIAS •...
  • Page 38 http://www.xiaoyu163.com 3 7 63 1515 0 -BD BOARD Section - IC102 BA6397FP DRIVE BUFFER OUT1A DRIVE BUFFER OUT1B OUT4A DRIVE LEVEL BUFFER SHIFT THERMAL IN1A OUT4B SHUT DOWN DRIVE LEVEL SHIFT BUFFER IN1B IN4A TR-B IN4B REG 0 XRST REGULATOR L 13942296513 IN2A IN3B...
  • Page 39 http://www.xiaoyu163.com 3 7 63 1515 0 - BD BORD Section - IC103 CXD2507AQ 57 56 55 54 SERVO AUTO DATA SEQUENCER XRST SENS SUB CODE INTERFACE PROCESSOR MUTE DIGITAL SQCK LOCK SQSO TEST EXCK FILO DIGITAL SBSO FILI DEMODULATOR SCOR WFCK ASYMMETRY AVSS...
  • Page 40 http://www.xiaoyu163.com 3 7 63 1515 0 - TCB BOARD Section - IC21 LC72130 XOUT AOUT2 AIN2 AIN1 AOUT1 VDD FMIN AMIN PHASE DETECTOR CHARGE PUMP POWER RESET UNLOCK DETECTOR SWALLOW COUNTER REFERENCE 1/16. 1/17 4bits DIVIDER 12bits PROGRAMMABLE DRIVER DATA SHIFT REGISTER UNIVERSAL COUNTER LATCH...
  • Page 41 http://www.xiaoyu163.com 3 7 63 1515 0 - AUDIO BOARD Section - IC602 uPC1330HA INVERTER COMPARATER SW R1 SW P1 CONT SW P2 SW R2 IC901 M62427FP KEY IN2 BB22 SBAND GRAPHIC EQUALIZER – BPF OUT BUF IN1 – L 13942296513 BPF IN BUF OUT1 IN 2B...
  • Page 42 http://www.xiaoyu163.com 3 7 63 1515 0 - MAIN BOARD Section - IC201,402 LB1641 T.S.D O.C.P MOTOR MOTOR DRIVE DRIVE FWD/REV/STOP CONTROL LOGIC IC802 MC14052BCP SELECT A INH 7 L 13942296513 SELECT B IC1202 uPC1237HA OVER LOAD DET MUTE OFFSET DET LATCH/ AUTORESET AC OFF...

  • Page 43: Exploded Views

    http://www.xiaoyu163.com SECTION 7 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • Abbreviation • Items marked “*” are not stocked since they are The components identified by : German model seldom required for routine service. Some delay mark ! or dotted line with mark ! EE : East European model should be anticipated when ordering these items.

  • Page 44: Back Panel Section

    http://www.xiaoyu163.com 3 7 63 1515 0 7-2. BACK PANEL SECTION (EXCEPT UK, E, TH, IA, JE Model) CNP1601 (TH Model) (HK Model) (EA3, MY, CNP1601 SP,TW Model) (UK Model) CNP1601 (E, IA, JE, Model) CNP1601 (E, IA, JE Model) (UK, HK Model) F1603 F1602 not supplied...

  • Page 45: Front Panel Section 1

    http://www.xiaoyu163.com 3 7 63 1515 0 7-3. FRONT PANEL SECTION 1 not supplied Supplied with J501, J601 FL501 Supplied with S562 L 13942296513 Supplied with S561 TCM-220WR2E Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-959-229-11 DETENT, CASSETTE * 111 A-4392-573-A PANEL BOARD, COMPLETE (RX50) X-4948-143-1 HOLDER (B) ASSY, CASSETTE (SILVER)

  • Page 46: Front Panel Section 2

    X-4948-246-1 BUTTON (T/B) ASSY (SILVER) 4-978-716-01 WINDOW (FL) X-4946-801-1 BUTTON (ENTER/NEXT) ASSY (BLACK) 4-978-745-21 PLATE, ORNAMENTAL, JOG X-4948-245-1 BUTTON (ENTER/NEXT) ASSY (SILVER) 4-962-708-11 EMBLEM (4-A), SONY X-4946-707-1 BUTTON (TC-PLAY) ASSY (BLACK) u163 4-930-336-61 FOOT (FELT) X-4948-243-1 BUTTON (TC-PLAY) ASSY (SILVER)

  • Page 47: Cd Mechanism Section (Cdm28-5Bd19)

    http://www.xiaoyu163.com 3 7 63 1515 0 7-5. CD MECHANISM SECTION (CDM28-5BD19) (including r B) M903 L 13942296513 BU-5BD19 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-960-836-01 TABLE, DISC 4-960-838-03 BASE (MD) 4-960-835-01 HOLDER (M) 4-917-583-21 BRACKET, YOKE 1-452-719-11 MAGNET ASSY 4-933-134-01 SCREW(+PTPWH M2.6X6) 4-960-842-01 GEAR (P)

  • Page 48: Base Unit Section (Bu-5Bd19)

    http://www.xiaoyu163.com 3 7 63 1515 0 7-6. BASE UNIT SECTION (BU-5BD19) L 13942296513 M101 M102 S101 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No.

  • Page 49: Tc Mechanism Section 1 (Tcm-220Wr2E)

    http://www.xiaoyu163.com 3 7 63 1515 0 7-7. TC MECHANISM SECTION 1 (TCM-220WR2E) (Including p A) • A HP101 • B (including • A) not supplied • A • B not supplied not supplied L 13942296513 HRPE101 (including • B) not supplied not supplied not supplied not supplied...

  • Page 50: Tc Mechanism Section 2 (Tcm-220Wr2E)

    http://www.xiaoyu163.com 3 7 63 1515 0 7-8. TC MECHANISM SECTION 2 (TCM-220WR2E) p A : MOTOR board (Supplied with AUDIO board) L 13942296513 not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-908-597-01 CAM (A) X-3370-171-1 FLYWHEEL (BR) ASSY 3-908-608-11 SCREW, STEP 3-908-600-01 LEVER (REV-B)

  • Page 51: Electrical Parts List

    http://www.xiaoyu163.com SECTION 8 AUDIO ELECTRICAL PARTS LIST 3 7 63 1515 0 Note: • Due to standardization, replacements in the parts • COILS The components identified by list may be different from the parts specified in the uH : µ H mark ! or dotted line with mark ! diagrams or the components used on the set.
  • Page 52 http://www.xiaoyu163.com AUDIO 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R609 1-249-433-11 CARBON 1/4W C132 1-163-037-11 CERAMIC CHIP 0.022uF R611 1-249-409-11 CARBON 1/4W C133 1-163-145-00 CERAMIC CHIP 0.0015uF 5% C134 1-164-346-11 CERAMIC CHIP R612 1-249-409-11 CARBON 1/4W...
  • Page 53 http://www.xiaoyu163.com 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R128 1-216-105-91 METAL GLAZE 220K 1/10W C647 1-162-282-31 CERAMIC 100PF R129 1-216-049-91 METAL GLAZE 1/10W C648 1-124-257-00 ELECT 2.2uF R130 1-216-079-00 METAL CHIP 1/10W C649 1-124-589-11 ELECT...
  • Page 54 http://www.xiaoyu163.com LOADING MAIN LEAF SWITCH 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark S560 1-554-303-21 SWITCH, TACTILE (KARAOKE PON/MPX) < CAPACITOR > S561 1-467-869-11 ENCODER, ROTARY (VOLUME) C201 1-126-961-11 ELECT 2.2uF S562 1-467-968-11 ENCODER, ROTARY (MULTI JOG STATION) C202...
  • Page 55 http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C903 1-136-495-11 FILM 0.068uF C1022 1-126-968-11 ELECT 100uF C904 1-136-495-11 FILM 0.068uF C1023 1-126-968-11 ELECT 100uF C905 1-136-156-00 FILM 0.018uF C906 1-136-156-00 FILM 0.018uF C1025...
  • Page 56 http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark * CN702 1-568-830-11 SOCKET, CONNECTOR 11P IC401 8-759-289-38 IC HA12195NT * CN703 1-568-834-11 SOCKET, CONNECTOR 15P (EXCEPT EA4,TH) IC402 8-759-822-09 IC LB1641 * CN703 1-568-832-11 SOCKET, CONNECTOR 13P (EA4,TH) IC701...
  • Page 57 http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < RESISTOR > R703 1-249-437-11 CARBON 1/4W R704 1-249-429-11 CARBON 1/4W R201 1-249-415-11 CARBON 1/4W R202 1-249-435-11 CARBON 1/4W R705 1-249-429-11 CARBON 1/4W R203 1-249-425-11 CARBON...
  • Page 58 http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R763 1-249-429-11 CARBON 1/4W R1007 1-249-417-11 CARBON 1/4W R764 1-249-429-11 CARBON 1/4W R1020 1-249-409-11 CARBON 1/4W R780 1-249-425-11 CARBON 4.7K 1/4W (IA) R1021 1-249-409-11 CARBON...
  • Page 59 http://www.xiaoyu163.com PANEL MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1258 1-249-425-11 CARBON 4.7K 1/4W < CAPACITOR > ! R1259 1-212-881-11 FUSIBLE 1/4W F ! R1260 1-208-602-11 WIREWOUND 0.22 C513 1-162-294-31 CERAMIC 0.001uF R1261...
  • Page 60 http://www.xiaoyu163.com PANEL 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q510 8-729-119-76 TRANSISTOR 2SA1175-HFE R565 1-249-429-11 CARBON 1/4W Q511 8-729-119-76 TRANSISTOR 2SA1175-HFE R566 1-249-429-11 CARBON 1/4W Q601 8-729-119-76 TRANSISTOR 2SA1175-HFE R567 1-249-429-11 CARBON 1/4W Q602...
  • Page 61 http://www.xiaoyu163.com PANEL 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark S524 1-554-303-21 SWITCH, TACTILE ()) 1-163-031-11 CERAMIC CHIP 0.01uF 1-163-038-91 CERAMIC CHIP 0.1uF S525 1-554-303-21 SWITCH, TACTILE (p) 1-163-038-91 CERAMIC CHIP 0.1uF S526 1-554-303-21 SWITCH, TACTILE (0)
  • Page 62 http://www.xiaoyu163.com 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < IFT > < RESISTOR > IFT41 1-409-636-11 TRANSFORMER, IF (CERAMIC FILTER) 1-249-401-11 CARBON 1/4W 1-216-037-00 METAL CHIP 1/10W < JUMPER RESISTOR > 1-216-037-00 METAL CHIP 1/10W 1-216-037-00 METAL CHIP...
  • Page 63 http://www.xiaoyu163.com 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < TERMINAL > 1-126-964-11 ELECT 10uF 1-104-396-11 ELECT 10uF 1-537-488-11 TERMINAL BOARD (ANT) (ANTENNA) 1-104-396-11 ELECT 10uF 1-104-396-11 ELECT 10uF < VIBRATOR > 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 1-760-549-11 VIBRATOR, CRYSTAL (4.5MHz)
  • Page 64 http://www.xiaoyu163.com TRANSFORMER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-410-521-11 MICRO INDUCTOR 100uH 1-216-073-00 METAL CHIP 1/10W 1-410-521-11 MICRO INDUCTOR 100uH 1-216-042-00 METAL CHIP 1/10W 1-410-119-11 MICRO INDUCTOR (EL TYPE) 1mH 1-216-021-00 METAL CHIP 1/10W 1-247-843-11 CARBON...
  • Page 65 http://www.xiaoyu163.com TRANSFORMER 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < TRANSFORMER > ************* HARDWARE LIST ! T1601 1-431-127-11 TRANSFORMER,POWER (EXCEPT AEP,UK,G,EE) ************* ! T1601 1-431-129-11 TRANSFORMER,POWER (AEP,UK,G,EE) 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S ************************************************************ 7-685-872-09 SCREW +BVTT 3X8 (S) MISCELLANEOUS...
  • Page 66 HCD-GR5/RX50 3 7 63 1515 0 L 13942296513 u163 Sony Corporation 97C0974-1 Printed in Japan © 1997.3 9-960-912-11 Home A&V Products Company Published by ServIce and Safty Engeneering Dept.(Shibaura) — 94 — http://www.xiaoyu163.com...

This manual is also suitable for:

Hcd-rx50

Table of Contents