The use of a substitute replacement component which does Leakage 0.5mA current Device not have the same safety characteristics as the PIONEER tester under recommended replacement one, shown in the parts list in test this Service Manual, may create shock, fire, or other hazards.
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. u163 DV-285-S http://www.xiaoyu163.com...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING SECTION L 13942296513 "Operating Instructions" u163 DV-285-S http://www.xiaoyu163.com...
Page 7
Operating Instructions(English) J2G40201A Operating Instructions See Contrast table (2) • • • • • • • • (2) CONTRAST TABLE DV-285-S/KUXTL and DV-285-S/KCXTL are constructed the same except for the following : Mark Symbol and Description DV-285-S/KUXTL DV-285-S/KCXTL Guarantee Card...
http://www.xiaoyu163.com 2.3 05 DVD MECHA SECTION 3 7 63 1515 0 Cannot supply separately. If the repair is needed, replace the Lubricating Oil LOADER SUB ASS'Y. GYA1001 Daifree GEM1036 Lubricating Oil GYA1001 L 13942296513 CD2001 PCB610 (LOADING MOTOR PCB ASS'Y) CD2302 Do not replace the parts.
Page 15
J8001 CVBS : POWER PORT BLOCK VIDEO OUT (COMPOSITE) L 13942296513 J8002 S VIDEO OUT J8003 AUDIO OUT J8004 COAXIAL DIGITAL OUT CP502(14P) Cord Connector 06C32E3504 POWER PCB ASSY (A2G402A240) u163 CP501 BLACK BLACK(L) AC IN WHITE(N) WHITE DV-285-S http://www.xiaoyu163.com...
PCE# AD3 {1} AD4 {1} AD5 {1} AD6 {1} AD7 {1} PRD# {1} PCE# {1} PWR# {1} u163 (V+3D) V+3 {1,5} D_GND {1,3,4,5} NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-285-S http://www.xiaoyu163.com...
SLED/SPINDLE CP2303 00_6232_006_006_800+ SW(GND) TP2324 LIMIT LIMIT SW TP2325 MOT_SLED- SLD- TP2326 MOT_SLED+ SLD+ R2329 TP2327 SPD- TP2328 MOT_SPDL+ SPD+ MOT_SPDL- V+3F u163 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-285-S http://www.xiaoyu163.com...
Y out C8015 0.1 B CY out C8002 GND2 CY in (CB) Cb out (CB) C8004 B/CB Cb in GND2 (CR) MUTE2 Cr out (CR) C8005 R/CR GND2 Cr in u163 JAPAN ---> Q8002,R8010 ON J8001 MSP-244V10-95_NI_FE_LF I/XP CVBS/Y/U/V DV-285-S http://www.xiaoyu163.com...
Page 23
AUDIO_R R8063 +-1% C8072 J8003 D8007 R8057 MSP-242V2-01NI-FE_LF REF GEN L/R AUDIO OUT Q8016 1SS355 KTC3875S_Y_RTK 12.5 W866 u163 J8002 MDC-070V-B_LF NOTE : THE DC VOLTAGE EACH PART WAS Y/C SEPA MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-285-S http://www.xiaoyu163.com...
DVD MT PCB ASSY (A2G402A130) POWER PORT BLOCK IC4006 SIP1117L-ADJ-TP REG+1.8V IC VOUTADJ W853 R4011 R4012 L 13942296513 68 +-1% CP4003 A2001WV2-14P P.CON+12V AT+12V for MUTE P.CON+5V P.CON+6V GND(M) P.CON+3.3V(AT) AT+3.3V STBY L GND(D) FL DC- FL DC+ -28V u163 DV-285-S http://www.xiaoyu163.com...
Page 25
V+3E (FIP/LED/IR/RESET) V+3E {1} V+1R8 (CORE) V+1R8 {1} V+3A {4} L 13942296513 FLDC- {1} POWER_ON {1} FLDC+ {1} -28V {1} D_GND {1,2,3,4} NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. u163 DV-285-S http://www.xiaoyu163.com...
2H092801 DEE039 CP603 (CP602) CP602 (CP603) 00_6232_009_102_800+ 00_6232_009_102_800+ OS651 ROM-N340TAO POWER STOP STOP SW667 Vout PLAY/+SKIP PLAY/+SKIP PAUSE/-SKIP PAUSE/-SKIP EVQ11L05R R666 POWER POWER V+3E V+3E V+3E 1/4W OPERATION 3 PCB ASSY SW667 : POWER u163 B C G DV-285-S http://www.xiaoyu163.com...
Page 27
-28V FLDC- FLDC- u163 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-285-S http://www.xiaoyu163.com...
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS OF FUSE. 1.6A 125V{F501} 1.6A 125V CAUTION : SINCE THESE PARTS MARKED BY ARE CRITICAL FOR SAFETY,USE ONES DESCRIBED IN PARTS LIST ONLY. DV-285-S http://www.xiaoyu163.com...
Page 29
NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE PROTECT Q506 WITHOUT NOTICE. KTA1504S_Y_RTK PROTECT R527 Q501 KTC3875S_Y_RTK NOTE : THE DC VOLTAGE EACH PART WAS 1/4W u163 MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-285-S http://www.xiaoyu163.com...
LOADING MOTOR LOADING MOTOR PCB ASSY PCB ASSY (INSERTED PARTS) (CHIP MOUNTED PARTS) L 13942296513 SIDE A SIDE B CD2302 CP2302 SW PCB ASSY M2603 LOADING MOTOR CD2301 M2602 u163 SLED MOTOR CD2301 M2601 SPINDLE CP2303 MOTOR DV-285-S http://www.xiaoyu163.com...
OPERATION PCB ASSY CP601 DOWN SW652 SW661 RETURN L 13942296513 SW655 HOMEMENU SW653 SW654 SW659 TOPMENU SW657 MENU SW656 SW658 CP601 CP400 OPERATION 2 PCB ASSY SW662 SW664 DEE038A + SKIP CP605 u163 CP605 CP604 B C G DV-285-S http://www.xiaoyu163.com...
Page 37
SIDE A NTSC C674 OS651 DEE039A R666 CP604 CP604 CP605 DEE028A CP601 CP602 D651 L 13942296513 D652 D654 W805 D655 D656 D657 D658 D659 V651 CP601 CP602 CP4002 CP603 SW660 SW665 SW663 NTSC STOP PAUSE u163 B C G DV-285-S http://www.xiaoyu163.com...
Page 38
3 7 63 1515 0 SIDE B OPERATION 3 PCB ASSY CP604 OPERATION PCB ASSY L 13942296513 CP602 OPERATION 2 PCB ASSY u163 B C G DV-285-S http://www.xiaoyu163.com...
Page 39
3 7 63 1515 0 SIDE B CP603 L 13942296513 IC651 CP601 u163 CP605 B C G DV-285-S http://www.xiaoyu163.com...
Page 44
W24002 JUMPER IN PCB 1230T10001 C526 CE 220 UF 6.3V E02LU0221M W24003 JUMPER IN PCB 1230T05001 C527 CE 100 UF 10V E02LU1101M C528 CE 2.2 UF 50V E50HU52R2M W24004 JUMPER IN PCB 1230T12501 C531 CE 100 UF 16V E02LU2101M DV-285-S http://www.xiaoyu163.com...
Page 45
R666 RC 2.2K OHM 1/4W R002T4222J OTHERS CP603 CONNECTOR PCB SIDE 069EV93050 CP604 CONNECTOR PCB SIDE 069EV53050 PCB280 PCB DEE038A 13DEE038AW SW PCB ASSY There is no Service Parts LOADING MOTOR PCB ASSY u163 There is no Service Parts DV-285-S http://www.xiaoyu163.com...
• Soldering combination: Sn-3.0Ag-0.5Cu • When Soldering/Removing of solder, use the draw in equipment over the Pick Up Unit to prevent the Flux smoke from it. L 13942296513 Pick Up PCB Short circuit using a soldering iron. Fig. 1 u163 DV-285-S http://www.xiaoyu163.com...
• The video signal and the audio signal are outputted during the test mode. • The SKIP key and the SCAN key are effective during the test mode. TEST MODE: OFF POWER u163 GGF1381 Test mode remote control unit DV-285-S http://www.xiaoyu163.com...
• Place the unit on a workstation equipped to protect against static electricity, such as conductive mat. • Soldering iron with ground wire or ceramic type is used. • A worker needs to use a ground conductive wrist strap for body. u163 DV-285-S http://www.xiaoyu163.com...
DVD : Press the [TEST] (A8-5E) and [1] (A8-01) keys in order, and turn on the laser diode (650n). : Press the [TEST] (A8-5E) and [4] (A8-04) keys in order, and turn on the laser diode (780n). L 13942296513 u163 DV-285-S http://www.xiaoyu163.com...
PAL system : [PAL] Automatic setting : [AUTO] Scart terminal output [SK – ∗ ∗] (Display only the WY model which can do the output setting of scart terminal.) VIDEO : [00] S-VIDEO : [01] u163 : [02] DV-285-S http://www.xiaoyu163.com...
After you press the A.MON key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. the unit, an error message is displayed, and the tray opens. u163 DV-285-S http://www.xiaoyu163.com...
Display it according to model information set from the FL Driver IC. 2 Region No. L 13942296513 3 ROM number Rom display Version. 5 SUM CHKSUM value of E2P ROM displays with four places. Calculation range : TV_COMP_POS (65d) – LAST_TV_SYSTEM_POS (151d) 6 CHIP VERSION u163 DV-285-S http://www.xiaoyu163.com...
7.0e -4 : NG 3 EDC/ID error history (ID Address, EDC/ID errors, last eight errors) Note: ∗ Error of AV1 is not supported in this player. L 13942296513 Indication plan contents Character in bold : Item name : Information display u163 DV-285-S http://www.xiaoyu163.com...
Measure the voltage between the two ends of R2320 or R2322 on the DVDM Assy. If the voltage is 0.4 V or higher, the 780-nm LD is degraded. To OPTICAL PICKU DVD MT PCB ASSY CP2301 L 13942296513 Front side SIDE A u163 DV-285-S http://www.xiaoyu163.com...
Check the video signal path between DVD IC (DVD MT Assy IC4002) displayed on the monitor Video circuit after DVD IC and video-out terminal (see the block diagram) (The FL display lights. The (IC4001) mechanism does not work.) u163 DV-285-S http://www.xiaoyu163.com...
Page 56
Any kind of symptoms (no power, a failure in any of the servo, video and audio systems, etc.) may be u163 (DVD MT Assy : IC4001) generated, because the DVD processing is performed by a single chip. 64M SDRAM No power. (DVD MT Assy : IC4005) Block noise is generated during playback. DV-285-S http://www.xiaoyu163.com...
Up PCB and DVD PCB connector. 1-4: DVD PCB (Refer to Fig. 1-4) Power PCB Remove the 4 screws 1. Remove the 4 screws 2. Remove the DVD PCB in the direction of arrow. DVD PCB Fig. 1-2 u163 Fig. 1-4 DV-285-S http://www.xiaoyu163.com...
Page 59
3 supports 1. between A and B. Fig. 2-3-D Remove the Plate Clamper, Magnet Clamper and Clamper. Check Hook Check Hook Plate Clamper Magnet Clamper Main Frame Clamper Loading Motor PCB Ass’y Check Hook Fig. 2-5-A Fig. 2-3-E u163 DV-285-S http://www.xiaoyu163.com...
Page 60
Remove the Switch PCB Ass'y. 8.0 ± 0.2mm Remove the screw 4. Remove the Gear Feed. Feed Motor Remove the 2 screws 5. Remove the Feed Motor. Remove the Gear Motor. Safety surface for pressing of the insert. Fig. 2-7-C u163 DV-285-S http://www.xiaoyu163.com...
Page 61
Fig. 2-8. NOTE L 13942296513 Do not make the folding lines except the specified positions for the FFC. [ 24 pin FFC ] Printing _Serface 85±1 mm Reinforcement Plat To Pick Up PCB Fig. 2-8 u163 DV-285-S http://www.xiaoyu163.com...
Page 63
Video DAC Servo IO Servo Motor Processor Video Drive Processor interlacer Spindle Control FLASH MPEG-1/2 Audio JPEG Memory Video Decoder Controller DRAM CCIR601/656 System Audio L 13942296513 Parser Audio Output CPPM/CPRM SPDIF System GPIO 32-bit RISC IR/VFD u163 DV-285-S http://www.xiaoyu163.com...
Page 65
1: Microcontroller external interrupt 2 RAS# DRAM row address strobe, active low 2 : GPIO u163 RCS# DRAM chip select, active low 170 SPDIF SPDIF output 3.3V power pin for VIDEO DAC circuitry DRAM bank address 0 171 DACVDDC – DV-285-S http://www.xiaoyu163.com...
Page 66
RF ripple detect input (through AC-coupling) HRFZC High frequency RF ripple zero crossing CRTPLP Defect level filter capacitor connecting RFGND – Analog Power RF Offset cancellation capacitor connecting RF Offset cancellation capacitor connecting RFGC RF AGC loop capacitor connecting for DVD-ROM u163 DV-285-S http://www.xiaoyu163.com...
Page 71
High-Voltage Segment Output Pins 14 to SG1/KS1 to SG16/KS16 Also acts as the Key Source – Pull-Down Level 31 to SG17/GR12 to SG24/GR5 High Voltage Segment/Grid Output Pins 39 to GR4 to GR1 High-Voltage Grid Output Pins u163 DV-285-S http://www.xiaoyu163.com...
7.4 DISC / CONTENT FORMAT PLAYBACK COMPATIBILITY 3 7 63 1515 0 L 13942296513 File structure (may differ): Up to 299 folders on a disc; up to 648 folders and files u163 (combined) within each folder. DV-285-S http://www.xiaoyu163.com...
8.1 FRONT PANEL SECTION 3 7 63 1515 0 Front panel STANDBY/ON MENU L 13942296513 10 ENTER & cursor buttons 11 TOP MENU 12 Display OPEN/CLOSE RW Compatible 14 Disc tray HOME MENU 15 Remote control sensor RETURN u163 DV-285-S http://www.xiaoyu163.com...
Lights during multi-angle scenes on a DVD A <––> B Indicator disc. Repeats playback between A and B. PRGSVE Lights when the player is set to output progressive scan video. Lights in any of the repeat play modes. u163 DV-285-S http://www.xiaoyu163.com...
12 PLAY MODE Press to display the Play Mode menu. (You can also get to the Play Mode menu by pressing HOME MENU and selecting Play Mode). Press to jump to the beginning of the current u163 DV-285-S http://www.xiaoyu163.com...
12 PLAY MODE Press to display the Play Mode menu. (You can also get to the Play Mode menu by pressing HOME MENU and selecting Play Mode). Press to jump to the beginning of the current u163 DV-285-S http://www.xiaoyu163.com...
12 PLAY MODE Press to display the Play Mode menu. (You can also get to the Play Mode menu by pressing HOME MENU and selecting Play Mode). Press to jump to the beginning of the current u163 DV-285-S http://www.xiaoyu163.com...