http://www.xiaoyu163.com SAFETY INFORMATION 3 7 63 1515 0 CAUTION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual.
Page 3
http://www.xiaoyu163.com 3 7 63 1515 0 Laser diode characteristics Wave length : 785 nm to 814 nm Maximum output : 1 190 µW(Emitting period : unlimited) Additional Laser Caution Transistors Q101 in PCB drive the laser diodes. When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.
Page 4
http://www.xiaoyu163.com 3 7 63 1515 0 [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual.
http://www.xiaoyu163.com 1. SERVICE PRECAUTIONS 3 7 63 1515 0 1.1 SERVICE PRECAUTIONS 1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.
Page 7
http://www.xiaoyu163.com 3 7 63 1515 0 9. Capacitor Bond Lock (UC, EW5) Acetate Tape (GYH1026) Please stick acetate tape along white line. Please confirm line hiding with acetate tape. * length of tape : 24 ± 4 mm 10. Capacitor Bond Lock (ES) Silicon Glue (GEM1017) Place the capacitor in the center of the silk print, and confirm it does not touch to the connector.
http://www.xiaoyu163.com 1.2 NOTES ON SOLDERING 3 7 63 1515 0 For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering.
http://www.xiaoyu163.com 2. SPECIFICATIONS 3 7 63 1515 0 2.1 SPECIFICATIONS • DEH-7300BT/XSUC, DEH-73BT/XSUC General CD player Power source ....1 4.4 V DC (10.8 V to 15.1 V al- System ......Compact disc audio system lowable) Usable discs ....Compact disc Grounding system ....Negative type Signal-to-noise ratio ..
Page 10
http://www.xiaoyu163.com 3 7 63 1515 0 • DEH-7300BT/XSEW5 General WAV signal format ....Linear PCM & MS ADPCM Power source......14.4 V DC (10.8 V to 15.1 V (Non-compressed) allowable) Grounding system....Negative type Maximum current consumption USB standard specification ............10.0 A ...........USB 2.0 full speed Backup current......3.0 mA or less Maximum current supply ..
Page 11
3 7 63 1515 0 • DEH-7350BT/XSES General Usable discs ....Compact disc Rated power source ..14.4 V DC Signal-to-noise ratio ..94 dB (1 kHz)(IEC-A network) (allowable voltage range: 12.0 Number of channels ..2 (stereo) V to 14.4 V DC) WMA decoding format ..
3 7 63 1515 0 The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc. and any use of such marks by Pioneer Corporation is under license. Other trademarks and trade names are those of their respective owners.
http://www.xiaoyu163.com 3 7 63 1515 0 Display indication Indicator State Indicator State The track (song) name is dis- Tuner: band and frequency played. Main dis- Built-in CD, USB storage A playable audio file has been play sec- device and iPod: elapsed selected during operation of tion playback time and text in-...
L 13942296513 CAUTION The track (song) name is dis- played. Use an optional Pioneer USB cable (CD-U50E) A playable audio file has been se- to connect the USB audio player/USB mem- (song) lected during operation of the list.
2.4 CONNECTION DIAGRAM 3 7 63 1515 0 DEH-73BT/XSUC, DEH-7300BT/XSUC, DEH-7350BT/XSES This unit Perform these connections when using a sub- woofer without the optional amplifier. 1 Power cord input 2 Microphone input ...
Page 16
http://www.xiaoyu163.com 3 7 63 1515 0 j When using a subwoofer of 70 W (2 Ω), be sure to connect the subwoofer to the violet and violet/black leads of this unit. Do not connect anything to the green and green/ black leads.
Page 17
http://www.xiaoyu163.com 3 7 63 1515 0 DEH-7300BT/XSEW5 This unit 8 Black (chassis ground) 9 Blue/white The pin position of the ISO connector will dif- fer depending on the type of vehicle. Connect 9 and b when Pin 5 is an antenna control type.
Page 18
http://www.xiaoyu163.com 3 7 63 1515 0 Power amp (sold separately) Perform these connections when using the optional amplifier. 1 System remote control Connect to Blue/white cable. 2 Power amp (sold separately) 3 Connect with RCA cable (sold separately) 4 To Rear output 5 Rear speaker...
Noise Volume too low Volume too high Volume fluctuating Sound interrupted L 13942296513 3.2 PCB LOCATIONS A:DEH-7300BT/XSUC B:DEH-7300BT/XSEW5 C:DEH-73BT/XSUC D:DEH-7350BT/XSES Unit Number : YWM5486(A,C) : YWM5482(B) : YWM5483(D) Unit Name : Tuner Amp Assy Unit Number : YWM5492(A,C) : YWM5488(B) CD Core Unit ( S11.1STD-DOUT...
http://www.xiaoyu163.com 3.3 JIGS LIST 3 7 63 1515 0 - Jigs List Name Jig No. Remarks 16P FFC GGD1310 Tuner Amp Unit - CD Core Unit Test Disc TCD-782 Checking the grating L.P.F. Checking the grating (Two pieces) Acetate Tape GYH1026 Capacitor Bond Lock - Grease List...
http://www.xiaoyu163.com 5.2 ERROR CODE LIST 3 7 63 1515 0 ERROR CODES If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from customers and facilitate failure analysis and repair work in servicing.
Page 26
(e.g., not caught your dealer or an in metal objects). authorized After checking, Pioneer Service turn the ignition Station. DEH-7300BT/XSUC http://www.xiaoyu163.com...
http://www.xiaoyu163.com 6. SERVICE MODE 3 7 63 1515 0 6.1 DISPLAY TEST MODE The information such as the system microcomputer version is checked. [How to enter Test mode] Press “ 1 ” and “ 3 ” keys simultaneously to start resetting. [Operation key] Operation key Processing...
http://www.xiaoyu163.com 6.2 CD TEST MODE 3 7 63 1515 0 - Flow Chart [Key] [CD] or [SOURCE] [4] + [6] -> BUP + ACC ON Test Mode IN Source ON Contents Display [BAND] Power On RF AMP (T.Offset is adjusted) Gain switching 00 00 00 [BAND]...
http://www.xiaoyu163.com 7. DISASSEMBLY 3 7 63 1515 0 While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same. Removing the Panel Assy (Fig.1) Remove the two hooks. Remove the two hooks and then remove the Panel Assy. Fig.1 Panel Assy Removing the CD Mechanism Module (Fig.2, 3, 4)
Page 31
http://www.xiaoyu163.com 3 7 63 1515 0 Removing the BT Unit and the Tuner Amp Assy (Fig.5) BT Unit Disconnect the FFC. Straighten the tabs at three locations indicated and then remove the BT Unit. Remove the two screws. Remove the two screws. Fig.5 Straighten the tabs at two locations indicated...
Page 32
http://www.xiaoyu163.com 3 7 63 1515 0 Disassembling the Panel Part (Fig.7, 8) 1. Remove the arm while bending the rib of the panel upward. Fig.7 2. Press the upside hook and the bottom side hook of the button at the same time, and pull out the button. Fig.8 L 13942296513 Assembling the Panel Part (Fig.9, 10, 11)
Page 33
http://www.xiaoyu163.com 3 7 63 1515 0 3. Fit the spring in the groove at the position shown in the figure. 4. Fit the boss on the lower side of the arm in the lower hole of the panel, and then warp the rib on the panel in the direction shown in the figure and fit the boss of the arm in the panel.
Page 34
http://www.xiaoyu163.com How to carry the mecha unit 3 7 63 1515 0 1. Hold the designated points (shown with dashed lines) of the upper chassis and the front/rear bracket. 2. Be careful not to hold the solid line portions or the CRG mecha part or insert foreign substances, to prevent distortion. 3.
Page 35
http://www.xiaoyu163.com 3 7 63 1515 0 How to remove the PU unit 1. Create an empty-clamp state according to “How to create empty clamp state (motor drive)”. 2. Hook the feeding screw biasing spring to a tentative hooking portion (Fig 2b). Be careful not to get injured by the spring edge.
http://www.xiaoyu163.com 8. EACH SETTING AND ADJUSTMENT 3 7 63 1515 0 8.1 CD ADJUSTMENT 1) Cautions on adjustments 2) Test mode In this product the single voltage (3.3 V) is used for the This mode is used to adjust the CD mechanism module. regulator.
http://www.xiaoyu163.com 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT 3 7 63 1515 0 Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module.
http://www.xiaoyu163.com 8.3 PCL OUTPUT CONFIRMATION 3 7 63 1515 0 - PCL output With the TESTIN (26 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started. Check that square wave of 600.0 kHz is output from PCL (8 Pin) of IC601. If clock signal is out of this range, this resonator (X601) must be changed for a new one.
http://www.xiaoyu163.com 9. EXPLODED VIEWS AND PARTS LIST 3 7 63 1515 0 9.1 PACKING 73BTUC L 13942296513 73BTUC 73BTUC u163 UC, ES DEH-7300BT/XSUC http://www.xiaoyu163.com...
Page 41
See Contrast table (2) 22-8 Caution Card See Contrast table (2) Polyethylene Bag See Contrast table (2) (2) CONTRAST TABLE DEH-7300BT/XSUC, DEH-7300BT/XSEW5, DEH-73BT/XSUC and DEH-7350BT/XSES are constructed the same except for the following: Mark Description DEH-7300BT/XSUC DEH-7300BT/XSEW5 DEH-73BT/XSUC DEH-7350BT/XSES Polyethylene Bag...
Page 42
Norwegian *YRB5193 Finnish *YRB5194 Danish *YRB5195 Portuguese *YRB5196 Greek L 13942296513 *YRB5197 Turkish All operation manuals are supplied in PDF files by the CD-ROM. Regarding the availability of paper manual, contact Pioneer Service representative in your region. u163 DEH-7300BT/XSUC http://www.xiaoyu163.com...
http://www.xiaoyu163.com 9.2 EXTERIOR 3 7 63 1515 0 UC, ES L 13942296513 u163 DEH-7300BT/XSUC http://www.xiaoyu163.com...
Page 45
See Contrast table (2) Screw BSZ26P120FTC L 13942296513 Seal See Contrast table (2) Heat Sink QNR3002 (2) CONTRAST TABLE DEH-7300BT/XSUC, DEH-7300BT/XSEW5, DEH-73BT/XSUC and DEH-7350BT/XSES are constructed the same except for the following: Mark Description DEH-7300BT/XSUC DEH-7300BT/XSEW5 DEH-73BT/XSUC DEH-7350BT/XSES Cord Assy QDP3013 QDP3014...
http://www.xiaoyu163.com 9.3 CD MECHANISM MODULE 3 7 63 1515 0 ( C ) ( C ) ( C ) ( A ) ( A ) L 13942296513 ( D ) ( A ) ( D ) ( C ) ( B ) ( D ) ( A ) ( A )
Page 47
http://www.xiaoyu163.com CD MECHANISM MODULE SECTION PARTS LIST Mark No. Description Part No. Mark No. 3 7 63 1515 0 Description Part No. Damper CNW1198 ..Screw BSZ20P040FTC CNW1726 Screw(M2 x 4) CBA1835 Motor Unit(M2)(LOAD/CRG) CXC4026 Washer CBF1038 Screw Unit CXC8894 Spring CBH3010 Arm Assy...
http://www.xiaoyu163.com 11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP ASSY 3 7 63 1515 0 NOTE FOR PCB DIAGRAMS TUNER AMP ASSY 1.The parts mounted on this PCB > P 25 include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- WIRED REMOTE...
Page 63
http://www.xiaoyu163.com 3 7 63 1515 0 SIDE A > P 251 (A,6,127) Fuse 3 A CEK1286 IC301 L901 POWER SUPPLY Q751 C321 R754 C309 JA901 C320 C752 C313 C319 C318 Q752 C901 Q351 D751 C315 R351 ANTENNA C753 C751 JA401 C312 C215 D902...
http://www.xiaoyu163.com 11.3 CD CORE UNIT (S11.1STD-DOUT) 3 7 63 1515 0 CD CORE UNIT (S11.1STD-DOUT) SIDE A PICKUP UNIT(P10.5)(SERVICE) CN101 LOADING/CARRIAGE S901 TH201 HOME MOTOR C102 REFO1 SPINDLE D101 C216 MOTOR C235 CN702 R216 C224 R229 R246 C225 C223 C222 C219 C221 R214...
Page 69
http://www.xiaoyu163.com 3 7 63 1515 0 CD CORE UNIT (S11.1STD-DOUT) SIDE B R102 C101 R103 R101 C111 C110 C104 Q101 R108 Q102 R109 R106 C239 C220 C236 C229 L 13942296513 C205 C301 C308 Q201 C206 R245 R240 R296 R254 R253 C231 C232 S905...
http://www.xiaoyu163.com 11.4 BT UNIT 3 7 63 1515 0 BT UNIT SIDE A R4 R5 CN971 BT MODULE L 13942296513 BT UNIT SIDE B u163 DEH-7300BT/XSUC http://www.xiaoyu163.com...
341S2162 IC 601 (A,124,66) IC R5S7267ZD144FP C:DEH-73BT/XSUC IC 651 (A,146,72) IC S-80827CNMC-B8M IC 671 (A,120,29) IC(A,C) PEA018A8 D:DEH-7350BT/XSES (A,120,29) IC(B) PEA017A8 (A,120,29) IC(D) PEA019A8 Unit Number : YWM5486(A,C) IC 801 (A,107,18) L-MOS And Gate TC7SET08FUS1 : YWM5482(B) IC 891 (A,101,62) Regulator IC...
Page 72
http://www.xiaoyu163.com Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. D 911 (A,157,63) Diode 1SR154-400 3 7 63 1515 0 D 912 (A,157,60) Diode 1SR154-400 R 261 (A,41,132) RS1/16SS223J R 262 (A,34,132) RS1/16SS223J D 931 (A,122,115) Diode(A,C,D) HZU7L(A1) R 263 (A,18,131) (B)
Page 73
http://www.xiaoyu163.com Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. R 620 (A,139,76) RS1/16SS473J R 874 (A,126,22) RS1/16SS103J 3 7 63 1515 0 R 621 (A,112,82) RS1/16SS473J R 911 (A,140,42) RS1/10SR1R0J R 622 (A,125,82) RS1/16SS473J R 912 (A,148,42) RS1/10SR1R0J R 623...
Page 74
http://www.xiaoyu163.com Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. C 552 (A,127,46) CKSSYB104K10 3 7 63 1515 0 C 312 (A,99,124) CKSRYB104K16 C 601 (A,118,51) CKSRYB104K16 C 313 (A,69,130) CEVW100M16 C 314 (A,65,132) CCSRCH100D50 C 602 (A,124,51) CKSSYB104K10 C 315...
http://www.xiaoyu163.com Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. C 974 (A,109,31) CCSRCH221J50 R 1805 (B,74,18) RS1/10SR222J 3 7 63 1515 0 C 975 (A,106,31) CCSRCH471J50 R 1806 (B,73,15) RS1/10SR222J R 1822 (B,54,27) RS1/10SR273J C 976 (A,103,40) CCSRCH471J50 R 1823...
Page 76
http://www.xiaoyu163.com Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. R 232 (A,19,21) RS1/16SS0R0J C 304 (A,60,35) CKSSYB472K25 3 7 63 1515 0 R 235 (A,45,32) RS1/16SS103J C 305 (A,58,35) CKSSYB223K16 R 236 (A,46,32) RS1/16SS103J C 306 (A,68,20) CKSRYB105K10 R 237...