SAE Standard J1273 (Hose and Hose Assemblies): Publication 99930323 All specifications are nominal and may change as design improvements occur. Greenlee Textron Inc. shall not be liable for damages resulting from misapplication or misuse of its products. Loctite is a registered trademark of Henkel Corp.
Failure to observe this warning could result in severe or servicing this tool. injury or death. Failure to wear eye protection could result in serious eye injury from flying debris or hydraulic oil. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
In case of accidental skin contact with hydraulic oil, wash the affected area immediately to remove the oil. Failure to observe these precautions may result in injury. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
2. Hydraulic Motor 7. Housing 3. Hydraulic Tank Port “T” (return) 8. Inlet Screen 4. Hydraulic Pressure Port “P” (supply) 9. Base Plate 5. Handle Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
* 13.8 bar (200 psi) is the maximum agreed standard back pressure Inlet Screen (strainer): for the HTMA (Hydraulic Tool Manufacturers Association). Height: 82.6 mm (3.25") Greenlee Utility tools will operate satisfactorily at this standard. Diameter: 229 mm (9") 1. Maximum hydraulic fluid temperature must not Openings: 9.53 mm (0.375") exceed 60 °C (140 °F).
Refer to publication 99930323, SAE J1273 Two methods are used to identify the pressure (supply) (Hose and Hose Assemblies). and tank (return) ports of Greenlee Utility tools. Match the markings on your tool to this table. Replacement Refer to a Greenlee Utility catalog or publication...
Perform a thorough inspection of the hydraulic hoses attention immediately. and fittings as described in publication 99930323, SAE J1273 (Hose and Hose Assemblies). Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Tool operates, but discharge Inlet screen plugged with debris. Remove debris from inlet screen. is low. Discharge hose plugged. Remove and clean hose. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 10
H4660B Submersible Pump Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Norma SAE J1273 (Manguera y conjuntos de mangueras): Publicación 99930323 Todas las especificaciones son nominales y podrían cambiar según se hagan mejoras en el diseño. Greenlee Textron Inc. no será responsable por daños que resulten de la aplicación o uso indebidos de sus productos.
De no utilizar protectores para ojos podría sufrir graves lesiones oculares ocasionadas si el aceite hidráulico, o restos de materiales llegaran a saltar. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 14
Si ocurre el contacto accidental, lávese de inmediato el área afectada a fin de eliminar el aceite. De no observarse estas advertencias podrían sufrirse lesiones. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
3. Bocatoma “T” del tanque hidráulico 7. Carcasa (retorno) 8. Cedazo de la admisión 4. Bocatoma “P” de presión hidráulica 9. Placa de base (suministro) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Diámetro: 229 mm (9 pulg.) Association o Asociación de Fabricantes de Herramientas Bocatomas: 9,53 mm (0,375 pulg.) Hidráulicas). Las herramientas Greenlee Utility funcionarán de manera satisfactoria de acuerdo con estas normas. Bocatoma de admisión de la bomba: 1. La temperatura máxima del fluido hidráulico no 63,5 mm (2,5 pulg.)
Existen dos métodos para identificar las bocatomas (Manguera y conjuntos de mangueras). de presión (suministro) y del tanque (retorno) de las bombas Greenlee Utility. Compare las marcas en su Reemplazo bomba con lo indicado en esta tabla. Consulte el catálogo Greenlee Utility o la publicación Bocatoma de presión...
Si publicación 99930323, SAE J1273 (Manguera y se lesiona debido a una fuga de conjuntos de mangueras). aceite, solicite atención médica de inmediato. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Cedazo de la admisión obstruido Retire los residuos del cedazo de la descarga es lenta. con residuos. admisión. La manguera de descarga está Retire y limpie la manguera. obstruida. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 20
Bomba sumergible H4660B Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Illustrations et liste des pièces .......53–55 Ce manuel est conçu pour que le personnel puisse se familiariser avec les procédures de fonctionnement et d’entretien en toute sécurité de l’outil de Greenlee Utility suivant : H4660B (42190) Pompe submersible Code de série FYP Mettre ce manuel à...
Négliger de porter des lunettes de protection pourrait entraîner des blessures oculaires graves causées par la projection de débris ou d’huile hydraulique. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 24
En cas de contact cutané accidentel avec l’huile hydraulique, laver immédiatement la partie affectée pour enlever l’huile. Le non-respect de ces consignes peut entraîner des blessures graves. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
3. Orifice du réservoir hydraulique « T » 7. Boîtier (retour) 8. Filtre d’admission 4. Orifice de pression hydraulique « P » 9. Socle (alimentation) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Hauteur : 82,6 mm (3,25 po) Association / Association des fabricants d’outils hydrauliques). Diamètre : 229 mm (9 po) L’outil de Greenlee Utility fonctionne parfaitement avec cette Ouvertures : 9,53 mm (0,375 po) contre-pression. Orifice d’admission de la pompe : 63,5 mm (2,5 po) 1.
Deux méthodes sont utilisées pour identifier les orifices (Tuyaux et assemblages de tuyaux). de pression (alimentation) et du réservoir (retour) des outils de Greenlee Utility. Comparer les marques sur Remplacement l’outil aux indications du tableau suivant. Consulter un catalogue de Greenlee Utility ou la Orifice de pression Orifice du réservoir...
99930323, SAE J1273 (Tuyaux et assemblage de gangrène, voire la mort. En cas de tuyaux). blessure par un jet d’huile, consulter immédiatement un médecin. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Le filtre d’admission est bouché par Enlever les debris du filtre d’admission. l’évacuation est lente. des debris. Le tuyau d’évacuation est bouché. Enlever et nettoyer le tuyau. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 30
Pompe submersible H4660B Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Tauchpumpe H4660B Inhaltsverzeichnis Beschreibung Beschreibung .............. 32 Die Tauchpumpe H4660B von Greenlee Utility ist für das Fördern von ausschließlich Wasser in allen Arten von Sicherheitsvorkehrungen ..........32 nicht-explosionsgefährdeten Umgebungen vorgesehen. Zweck dieses Handbuchs ........... 32 Diese Pumpe wird entweder mit Open-Center- oder Closed-Center-Hydrauliksystemen betrieben.
Das Nichtbeachten dieser Warnung kann zu einen Augenschutz tragen. schweren oder tödlichen Verletzungen führen. Absplitternde Trümmer oder verspritztes Hydrauliköl könnten bei fehlendem Augenschutz schwere Augenverletzungen verursachen. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 34
Im Falle eines versehentlichen Kontakts der Haut mit Hydrauliköl die betroffenen Stellen sofort reinigen, um das Öl zu entfernen. Das Nichtbeachten dieser Vorsichtsmaßnahmen kann unter Umständen zu Verletzungen führen. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
* 13,8 Bar ist die unter den Mitgliedern der „Hydraulic Tool Einlassfilter (-sieb): Manufacturers Association“ (HTMA) vereinbarte Norm für den Staudruck. Die Geräte von Greenlee Utility halten diese Höhe: 82,6 mm Norm ein, das heißt, sie funktionieren bei diesem Höchstwert Durchmesser: 229 mm zufriedenstellend.
Identifikation der Anschlüsse Siehe Publikation 99930323, SAE J1273 Die Druck- und Tankanschlüsse (Zulauf und Rücklauf) (Schlauch und Schlauchbausätze). von Geräten von Greenlee Utility können auf zwei verschiedene Arten erkannt werden. Vergleichen Sie die Ersatzteile Markierungen am Gerät mit denen in dieser Tabelle.
Eine gründliche Inspektion der Hydraulikschläuche und einer Verletzung ist sofort ein Arzt -verbindungen vornehmen, wie in Publikation 99930323, aufzusuchen. SAE J1273 (Schlauch und Schlauchbausätze) beschrieben. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Gerät funktioniert, die Einlassfilter mit Schmutzteilen Schmutzteile vom Einlassfilter entfernen. Fördermenge ist jedoch zu verstopft. gering. Der Abpumpschlauch ist verstopft. Den Schlauch abnehmen und reinigen. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 40
Tauchpumpe H4660B Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Standard SAE J1273 (Tubo flessibile e gruppi del tubo): Pubblicazione 99930323 Tutte le specifiche sono nominali e potrebbero cambiare man mano che si apportano migliorie al design. La Greenlee Textron Inc. non sarà responsabile di eventuali danni risultanti dall’errata applicazione o dall’uso improprio dei suoi prodotti.
Il mancato utilizzo della protezione per gli occhi potrebbe causare gravi infortuni provocati da detriti vaganti o dall’olio idraulico. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 44
• In caso di contatto accidentale dell’olio idraulico con la pelle, lavare immediatamente l’area interessata per rimuovere l’olio. L’inosservanza di queste precauzioni potrebbe causare lesioni. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
3. Raccordo “T” della porta del 7. Custodia serbatoio idraulico (ritorno) 8. Filtro d’entrata 4. Raccordo “P” della pompa della 9. Piastra base pressione idraulica (mandata) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
* 13,8 bar (200 psi) è la contropressione massima concordata dalla HTMA (Associazione dei produttori di attrezzi idraulici). I prodotti Altezza: 82,6 mm (3,25 pollici) Greenlee Utility funzionano in modo soddisfacente a questo Diametro: 229 mm (9 pollici) standard. Aperture: 9,53 mm (0,375 pollici) 1.
Consultare la pubblicazione 99930323, SAE J1273 Per identificare le aperture della pressione (mandata) e (tubo flessibile e gruppi di tubi). del serbatoio (ritorno) sugli attrezzi Greenlee Utility, si possono adottare due metodi. Confrontare le indicazioni Ricambi sul proprio utensile con questa tabella.
In caso 99930323, SAE J1273 (Tubo flessibile e gruppi del di infortunio causato da fuoriuscita tubo). d’olio, consultare immediatamente un medico. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
L’attrezzo funziona, ma lo scarico Filtro d’entrata ostruito da detriti. Togliere i detriti dal filtro d’entrata. è basso. Flessibile di scarico ostruito. Togliere e pulire il flessibile. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 50
Pompa sommergibile H4660B Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
If a complete overhaul is necessary, return the tool to Inspect each component as described in this section. your nearest Greenlee Utility Authorized Service Center. Replace any component that shows wear or damage. The disassembly procedure is divided into sections of 1.
(strainer) (24). 3. Install strainer assembly on bottom of housing (1) using six hex head cap screw (27). Tighten cap screws securely. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
23760 52023760 Motor retrofit kit (includes items marked with an asterisk) Decals 41547 50415471 Decal, Greenlee Utility ............1 50495062 Decal, CE ................1 52000843 Decal, hydraulic specs ............1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 55
41219 50412193 Hose assembly, heavy-duty discharge Coupling, cam lock ..............1 Clamp, hose ................4 Hose, discharge, 2.5" x 25'............ 1 Coupling, male ............... 1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 56
800-435-0786 Fax: 800-451-2632 815-397-7070 Fax: 815-397-1865 Canada 800-435-0786 Fax: 800-524-2853 International +1-815-397-7070 Fax: +1-815-397-9247 4455 Boeing Drive • Rockford, IL 61109-2988 • USA • 815-397-7070 • An ISO 9001 Company Greenlee Textron Inc. is a subsidiary of Textron Inc. www.greenlee.com...