Page 1
XT650, XT675, XT775 Owner's Manual IMPORTANT: Read all safety precautions and instructions carefully before operating equipment. Refer to operating instruction of equipment that this engine powers. Ensure engine is stopped and level before performing any maintenance or service. Warranty coverage as outlined in the warranty card and on KohlerEngines.com.
Page 2
Safety Precautions WARNING: A hazard that could result in death, serious injury, or substantial property damage. CAUTION: A hazard that could result in minor personal injury or property damage. NOTE: is used to notify people of important installation, operation, or maintenance information. WARNING WARNING WARNING...
Page 3
Oil Fill Cap/ Starter Handle Fuel Cap Fuel Tank Dipstick Fuel Shut-Off Air Cleaner Spark Plug Valve Pre-Start Checklist 1. Check oil level. Add oil if low. Do not overfi ll. 2. Check fuel level. Add fuel if low. Check fuel system components and lines for leaks. 3.
Page 4
4000 ft. (1219 meters). To obtain high altitude kit a. Manual Choke Models: information or to fi nd a Kohler authorized dealer Cold engine: Place throttle control to visit KohlerEngines.com or call 1-800-544-2444 FAST position. Pull choke control into (U.S.
Page 5
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any repair establishment or individual; however, warranty repairs must be performed by a Kohler authorized dealer found at KohlerEngines.com or 1-800-544-2444 (U.S. and Canada). Maintenance Schedule After fi...
Page 6
Fuel Recommendations Fuel Line Low permeation fuel line must be installed on WARNING carbureted Kohler Co. engines to maintain EPA and CARB regulatory compliance. Explosive Fuel can cause fi res and severe burns. Do not fi ll fuel tank while engine is hot or running.
Page 7
Loosen knob and remove air cleaner cover. To fi nd a Kohler authorized dealer visit Precleaner (if equipped): KohlerEngines.com or call 1-800-544-2444 (U.S. and Canada). 1. Remove precleaner.
Exhaust Emission Control System for models XT650, XT675, XT775 is EM for U.S. EPA, California, and Europe. Any and all horsepower (hp) references by Kohler are Certifi ed Power Ratings and per SAE J1940 & J1995 hp standards. Details on Certifi ed Power Ratings can be found at KohlerEngines.com.