Components - Honeywell HW6200 Owner's Manual

COMPONENTS

Use information provided in this section to become familiar with your generator's components.
The information below is provided for reference only. Refer to "OPERATION" on page 13 for instructions on
CAUTION
operating the generator.
J
H
G
A—Power Control Center
Household Outlets
120V 20 Amp Duplex (NEMA 5-
20R)outlets to connect 120V appli-
ances to generator for power.
Power Cord/ Transfer Switch
120/240V 30 Amp Twist-Lock outlet
can be used to:
•
Power 120V appliances using 4-
in-1 power cord (included with
generator).
•
Power 240V appliances using appropriate (NEMA L14-
30R) power cord (not included).
•
Connect a transfer switch to building's main electrical sys-
tem for back-up power (see page 10).
Breakers
Protects circuits from damage caused by
overload or short circuit by stopping flow of
electricity from the generator to the appli-
ance. Master circuit breaker controls power
to all outlets. If there is no power at outlets,
see Troubleshooting section.
Ground Terminal
Connects generator to ground wire for grounding protection.
Generator must be grounded to prevent electrical
shock from faulty appliances. See page 10.
B—Engine Oil Fill Cap/Dipstick
Seals off engine oil fill hole and provides indicator for engine
oil level.
C—Engine Oil Plug
When loosened, allows engine oil to drain from generator.
HW6200/HW6200L Portable Electrical Generator Owner's Manual
I
D
F
B
E
C
FIGURE 16: HW6200L Portable Generator
POWER CONTROL CENTER
HOUSEHOLD 4-IN-1POWER CORD
OUTLETS TRANSFER SWITCH
120 VOLTS AC 120/240 VOLTS AC
BREAKER BREAKER
6200
389cc
PORTABLE GENERATOR
6200 CONTINUOUS WATTS • 7750MAXIMUM WATTS
Set
CAUTION
A
D—Engine Control Switch
Control used to run and stop the engine. Engine switch has
OF
two positions:
•
RUN—Prepares engine to start
•
STOP—Stops generator engine
E—Recoil Starter Grip Handle
MASTER
BREAKER
Starts engine.
F—Fuel Valve
Controls flow of fuel from fuel tank to carburetor.
G—Air Cleaner Assembly
Removes dust from engine intake air.
H—Choke Control
Controls choke valve. Choke control must be pulled out to ON
position when starting a cold engine.
I— Fuel Gauge
Indicates level of fuel currently in fuel tank.
J—Fuel Tank Cap
Provides a secure seal on fuel tank.
Tripped
K—Muffler Equipped with Spark Arrester
Provides outlet for engine exhaust. Prevents sparks and other
combustible materials from escaping generator.
Muffler reaches temperatures that can cause serious
burns if touched. NEVER touch hot surfaces.
L—Spark Plug Cap (Wire)
Delivers voltage to spark plug. When spark plug needs ser-
vice, cap must be removed.
M—Carbon Canister (HW6200L model only)
Reduces hydrocarbon emissions.
K
WARNING
www.honeywellgenerators.com
L
M
11