Related Manuals for ESS Mountain Man MBP 2.5
Summary of Contents for ESS Mountain Man MBP 2.5
- Page 1 Owner’s Manual ESS MBP 2.5 ESS MBP 4.0 Mountain Man Sprayer ELECTROSTATIC SPRAYING SYSTEMS, INC. 62 Morrison St. · Watkinsville, GA 30677-2749 www.maxcharge.com · www.electrostaticspraying.com...
- Page 2 Owner’s Manual ess MBP 2.5 ess MBP 4.0 MOuntain Man sPrayer Electrostatic Spraying Systems, Inc. 62 Morrison St. · Watkinsville, GA 30677-2749 CE certification applied for Copyright © 2009, Electrostatic Spraying Systems, Inc. – All Rights Reserved This manual last updated April 1, 2009...
- Page 3 The products of ESS are the result of the efforts and creativity of many people. In addition to input from engineering, marketing and manufac- Brandon Wells...
- Page 4 Notes ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL...
-
Page 5: Table Of Contents
Of COntents Overview of the ESS MBP 2.5 / 4.0 Air-assisted Electrostatic Sprayer 1 Safe operation of the MBP Sprayer ............... 2 Operator’s responsibility ................2 Safety precautions ..................2 Chemical safety precautions ..............2 About the low-voltage system of the MaxCharge spray gun ..... 3 Safety decals ...................... - Page 6 Notes ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL...
-
Page 7: Overview Of The Ess Mbp 2.5 / 4.0 Air-Assisted Electrostatic Sprayer
The University of California completed a series of tests to investi- gate what happens to spray liquid after it leaves the nozzle. Conclusion: ESS technology places over 4 times the amount of spray onto the plant surface using 1/2 the amount of chemicals. -
Page 8: Safe Operation Of The Mbp Sprayer
Be aware of poisoning symptoms and know the appropriate first aid. Know the length of time needed to pass before allowing people and pets to go back into the sprayed area. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 9: About The Low-Voltage System Of The Maxcharge Spray Gun
“tingle” or a slight stinging sensation when the spray from the nozzle falls on their bare skin. Location of 9-volt rechargeable battery pack in the handle of the spray gun. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 10: Safety Decals
The decal below is located on the tank. This decal describes important information regarding the safe use of agricultural chemicals. If it is missing, please contact ESS imme- diately for a replacement decal. ¡ PRECAUCIÓN! -
Page 11: Features Of The Mbp Mountain Man Sprayer
9.5 ltr./hr. (2.5 gal./hr.) Drop size 40 microns Spray range 4.6 m. to 6.1 m. (15 to 20 ft.) Available options Dual-headed spray gun Additional hose up to 76.2 meters (250 ft.) max. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 12: Operating Instructions
A warranty registration card is bound into the manual after the Warranty page. After unpacking the sprayer, please take time to fill this card out and send it in to ESS. This will insure your warranty protection in the event anything happens to your sprayer or handgun. -
Page 13: Before Use
9. Aim spray gun and engage the trigger; lock trigger if desired. Spray with even, sweeping strokes. NOTE: It may take about a few moments for air to clear the lines before liquid sprays regularly without air bubbles. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 14: After Spraying
18. Clean the nozzle assembly. Sil-Glyde is an excellent silicone-based 19. Record application in Spray Log. protective lubricant. You may purchase it directly from ESS. S/N # 3174 ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 15: Mbp Maintenance Schedule
Clean spark plug in engine Every 100 operational hours OR every season** Change compressor oil Every 100 operational hours OR if dirty** Check and tighten bolts Every month ** Whichever comes first ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 16: Reference Section Engine
1. Move Throttle Speed control towards the turtle icon (slow) at the left. 2. Turn ON/OFF switch to OFF. Note: Do not use choke to stop engine, as a backfire or engine damage may result. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 17: Compressor
Note: Do not operate the sprayer when the tank lid is not securely can be purchased from ESS. closed. Chemicals may splash out onto the operator if the tank is open Order S/N#1566. during operation. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 18: Quick Connects
The liquid line is gray and only long enough to allow the user to move freely with the spray gun. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 19: Spray Gun
2. Check inside each part for debris. Clean any dirt out with compressed air or warm, soapy water. 3. Reassemble the air filter, making sure to put it together as shown above. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 20: Trigger
2. Check inside the trigger for blockage. Clean out any debris with compressed air or warm, soapy water. 3. Replace the spring and plunger; rethread the brass bolt into the top of the spray gun until tight. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 21: Liquid Filter Assembly
Replace the flow disk so that the numbers on the disk face the strainer. 6. Replace the strainer in the 1/8” NPT body. 7. Rethread the 1/8” NPT body and the cap. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 22: Nozzle Assembly
Wipe clean the exterior of all hoses and fittings connected to the nozzle. The electrode cover should be hand tight. Never use pliers or other tools to tighten it. The insulating ring should be loose. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 23: Pre-Spray Check
You may wish to purchase Nutra-Sol Tank Cleaner from ESS (S/N# 1566), which cuts hard water scale and chemical deposits from the electrode and internal component of the spray gun. The regular use of Nutra-Sol will keep your equipment operating at peak performance. -
Page 24: The Batteries
4. Replace the battery cover. Screw the two 6-32 x 1/2” Phillips head machine screws back in to secure the battery cover. 5. Charge the spray gun before attempting to use it. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 25: Yearly Spray Gun Service
As an additional Electrostatic Spraying Systems, Inc. offers and recommends yearly benefit, services on ESS spray guns. For a nominal fee plus the cost of replace- ment parts, ESS will thoroughly clean the spray gun, replace any worn Yearly Spray Gun parts and recalibrate the electronics and nozzle. -
Page 26: Spraying With Your Ess Sprayer
As in spray painting, the goal is to achieve even coverage over the sur- face. The ESS MaxCharge spray gun is designed to help you do just that -- by propelling the chemical spray with a gentle air flow, you can stay well away from the target surface and let the electrostatic attraction do Let the MaxCharge™... -
Page 27: Preparing A Tank Mix
With your new ESS sprayer you need to find out how much water is needed to spray the known area. The amount of water required to spray both houses is the amount of water in which you mix the 6 ounces of chemical in. -
Page 28: Chemical Compatibility
It is also a good idea to treat the water curely, and shake vigorously. with a pH agent. Carefully observe the interac- ESS does not recommend the use of wetting agents or tion between the chemical spreader-stickers. compounds. If the water... -
Page 29: Spraying With Optional Spray Guns
Not recommended #59 flow disk does not work Please let your ESS sales representative recommend the nozzle cover/flow disk combination that will be best for your particular crop. * All spray distance tests are conducted with no wind blowing. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 30: Siphoning
If your spray gun is held above your head, the liquid will not spray properly. To get the best performance from your sprayer, hold the spray gun no higher than your shoulder. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 31: Troubleshooting Guide
If problem persists, replace battery pack during operation · Dirty nozzle · Clean nozzle according to instructions Gasoline engine will not Please see the Briggs & Stratton Owner’s Manual start ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 32: Mbp Spray Gun Service Parts (Drawing)
ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 33: Mbp Spray Gun Service Parts (Key)
Note: Use of a flow disk is crucial to the operation of the spray gun. If the wrong size flow disk, or no flow disk is used, then the spray gun will not spray or charge efficiently ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 34: Back Pack Exploded View (Drawing)
Backpack exploded view Air to Spray Gun Liquid to Spray Gun ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 35: Back Pack Service Parts
HHCS — 1/4” - 2O × 11/4” - SS 6835 SCREW — #10-32 × 3/4” - PHILLIPS- RH- SS 8419 HEX NUT — #6-32 K-L - SS 8663 HEX NUT - #10-32 NYLOC - SS ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 36: Chassis Service Parts
PLUG — HEX HEAD - 1/8” MPT - BRASS 17204 QUICK FIST 1-PIECE RUBBER CLAMP (SMALL) PP242 RADIATOR — 5/8” DIA TUBE × 6 PASS BELT GUARD - DEVIL BLISS AIR POWER * NOT SHOWN ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... -
Page 37: Warranty
IS AUTHORIZED TO CHANGE THIS WARRANTY IN ANY WAY OR GRANT ANY OTHER WARRANTY UNLESS SUCH CHANGE IS MADE IN WRITING AND IS SIGNED BY A CORPORATE OFFICER OF ELECTROSTATIC SPRAYING SYSTEMS, INC. ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL... - Page 38 ESS MBP 2.5 / MBP 4.0 MOUNTAIN MAN OWNER’S MANUAL...
-
Page 39: Spray Gun Repair/Yearly Service Return Form
Spray gun repair/Yearly service return form When returning a spray gun for warranty or repair services to ESS, please pack it securely and include the following form with your spray gun. Spray Gun Serial Number: ____________________________________ Returned from: Company: ______________________________________...
Need help?
Do you have a question about the Mountain Man MBP 2.5 and is the answer not in the manual?
Questions and answers