Table of Contents
Advertisement
www.hatcocorp.com
Register Online!
(see page 2)
Atmospheric Hot Water Dispenser
Installation and Operating Manual
WARNING
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual
contains
important
information concerning the maintenance,
use, and operation of this product. If
you're unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
AWD Series
P/N 07.04.356.00
ADVERTENCIA
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
safety
o
muerte.
Este
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual
por
favor
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manual
contiene
manuel
importantes
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
pregunte
a
su
dans un endroit sûr pour pouvoir vous y
référer plus tard.
AVERTISSEMENT
non-respect
des
instructions
contient
des
informations
concernant
l'entretien,
© 2011 Hatco Corporation
Advertisement
Table of Contents
Related Manuals for Hatco AWD Series
Summary of Contents for Hatco AWD Series
- Page 1 à votre supérieur. Conservez ce manuel manual favor pregunte manual in a safe location for future supervisor. Almacenar este manual en dans un endroit sûr pour pouvoir vous y reference. una localización segura para la referencia référer plus tard. futura. © 2011 Hatco Corporation...
-
Page 2: Table Of Contents
Additional information can be found by visiting our web site at www.hatcocorp.com. INTRODUCTION Hatco Atmospheric Hot Water Dispensers quickly provide 2, 3, This manual provides the installation, safety, and operating or 4 quarts (1.9, 2.8, or 3.8 liters) of hot water for food instructions for Atmospheric Hot Water Dispensers. -
Page 3: Important Safety Information
• Discontinue use if power cord is frayed or worn. enough to support the weight of the unit and contents. • Do not attempt to repair or replace a damaged power cord. The cord must be replaced by Hatco, an NOTICE Authorized Hatco Service Agent, or a person with similar qualifications. -
Page 4: Model Description
MODEL DESCRIPTION All Models Hatco Atmospheric Hot Water Dispensers are equipped with an electronic temperature controller, a digital temperature display, a POWER ON/OFF (I/O) switch, premeasured dispensing Control buttons, and a manual dispense button. The units are protected Panel with a high-temperature limit switch and low-water cut-off. -
Page 5: Dimensions
SPECIFICATIONS Dimensions Width Depth Height Footprint Footprint Model Width (D) Depth (E) 13-3/8″ 27-1/2″ 28-1/16″ 10-3/4″ 14-3/4″ AWD-12 (339 mm) (698 mm) (713 mm) (273 mm) (375 mm) Figure 4. Dimensions Water Temperature Recovery Table Degrees of Rise 60°F 70°F 80°F 90°F 100°F... -
Page 6: Installation
1/4" NPT adapter with flare connection (or • make sure the unit is at the proper counter height in an by using optional 1/4" inlet tubing supplied by Hatco). area convenient for use. NOTE: Water inlet and drain connections must be made with •... -
Page 7: Operation
Information section before operating this equipment. 2. Push the appropriate button on the electronic temperature Hatco Corporation is not responsible for the actual food controller to fill a container. Dispensing is controlled by the product serving temperature. It is the responsibility of the four dispensing buttons on the front of the unit. -
Page 8: Programming The Dispenser
OPERATION Programming the Dispenser WARNING ELECTRIC SHOCK HAzARD: Turn OFF power switch, unplug power cord, and allow unit to cool before performing any cleaning, adjustments, or maintenance. Dipswitch Panel A dipswitch panel is located on the back of the control board which is behind the front panel graphic overlay. -
Page 9: Maintenance
Hatco equipment. This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966; or International fax 414-671-3976. -
Page 10: Deliming The Dispenser
MAINTENANCE Deliming the Dispenser 5. Turn the POWER ON/OFF (I/O) switch to the ON (I) position, and allow the unit to run at the operating Use the following procedure for periodic cleaning and deliming temperature for 1-2 hours. of the water tank. •... -
Page 11: Resetting The High Temperature Safety Switch
Setting the setpoint temperature over 195°F (91°C) will cause nuisance tripping of this safety switch. Hatco does not recommend adjusting the setpoint temperature above 195°F (91°C). To reset the safety high limit switch after it activates, follow the following procedure. -
Page 12: Troubleshooting Guide
Hatco for assistance. Low-water cut-off activated. make sure the unit is supplied with water. POWER ON/OFF (I/O) switch is defective. Contact Authorized Service Agent or Hatco for assistance. Unit does not dispense Drain valve handle is in the open (vertical) make sure the drain valve handle is in the closed water. -
Page 13: Options And Accessories
15,000 gallons (56,000 liters) of use or at least once per make sure to make clean, straight cuts on the tubing for year. Order Hatco P/N 03.05.116.00 for a replacement proper connection to the push-on fittings. water filter cartridge. -
Page 14: Limited Warranty
Product’s purchase date by registering the Product bulbs, fluorescent lights, heat lamp bulbs, coated halogen light with Hatco or by other means satisfactory to Hatco in its sole bulbs, halogen heat lamp bulbs, xenon light bulbs, LED light discretion. - Page 15 NOTES Form No. AWDm-1111...
-
Page 16: Authorized Parts Distributors
HATCO AUTHORIzED PARTS DISTRIBUTORS ALABAMA IOWA NEW yORK TExAS Jones mcLeod Appl. Svc. Electric motor Service Co. Acme American Repairs, Inc. GCS Service Birmingham 205-251-0159 Davenport 319-323-1823 Brooklyn 718-456-6544 Fort Worth 800-433-1804 Goodwin Tucker Group Alpro Service Co. Armstrong Repair Service...