Advertisement

Owner's Manual & Safety Instructions
Save This Manual
operating, inspection, maintenance and cleaning procedures. Write the product's serial number in the
back of the manual near the assembly diagram (or month and year of purchase if product has no number).
Keep this manual and the receipt in a safe and dry place for future reference.
Using an engine indoors
CAN KILL YOU IN MINUTES.
Engine exhaust contains carbon monoxide.
This is a poison you cannot see or smell.
NEVER use inside
a home or garage,
EVEN IF doors and
windows are open.
Email our technical support at: productsupport@harborfreight.com
Email our engine support at: predator@harborfreight.com
When unpacking, make sure that the product is intact
and undamaged. If any parts are missing or broken,
please call 1-888-866-5797 as soon as possible.
©
Copyright
2014 by Harbor Freight Tools
No portion of this manual or any artwork contained herein may be reproduced in
any shape or form without the express written consent of Harbor Freight Tools.
Diagrams within this manual may not be drawn proportionally. Due to continuing
improvements, actual product may differ slightly from the product described herein.
Tools required for assembly and service may not be included.
Keep this manual for the safety warnings and precautions, assembly,
Only use OUTSIDE
and far away from
windows, doors,
and vents.
Visit our website at: http://www.harborfreight.com
®
. All rights reserved.
Read this material before using this product.
Failure to do so can result in serious injury.
SAVE THIS MANUAL.
REV 16a

Advertisement

Table of Contents
loading

Summary of Contents for Predator 62214

  • Page 1 Visit our website at: http://www.harborfreight.com Email our technical support at: productsupport@harborfreight.com Email our engine support at: predator@harborfreight.com When unpacking, make sure that the product is intact and undamaged. If any parts are missing or broken, please call 1-888-866-5797 as soon as possible.
  • Page 2: Table Of Contents

    The emissions control system for this Engine is warranted for standards set by the U.S. Environmental Protection Agency and by the California Air Resources Board (also known as CARB). For warranty information, refer to the last pages of this manual. Page 2 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 3: Safety

    It must be understood by the operator that common sense and caution are factors which cannot be built into this product, but must be supplied by the operator. SAVE THESE INSTRUCTIONS ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 3...
  • Page 4: Set Up Precautions

    Do not spray 15. Wear ANSI-approved safety glasses the tool itself or any electrical wiring/receptacle. and hearing protection during use. Page 4 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 5 If you feel any medical or vibration occurs, stop use immediately. physical symptoms related to vibration (such as tingling, numbness, and white or blue fingers), seek medical advice as soon as possible. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 5...
  • Page 6: Service Precautions

    Pressure Washer to remain idle for more than two minutes. If allowed to remain idle, the water in the unit will heat up, possibly causing damage to the Pressure Washer. SAVE THESE INSTRUCTIONS. Page 6 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 7: Setup

    3. Attach the Hose Hanger (7) to the Handle with a Knob (4). Frame 4. Attach the two Wand Holders (14) Wand Holder to the Frame using Bolts (20). Bolt Wand Holder Bolt Figure A ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 7...
  • Page 8 Water minute at 20 PSI. Only use a 5/8" inner diameter Supply Inlet (or larger) hose that is rated to meet this capacity. Hose Fitting Figure F Page 8 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 9 Spray Gun Handle Handle Spray Gun Trigger Pressure Hose Trigger Lock Nozzles Wand Frame Engine Pump Detergent Tank Lid Detergent Tank Pump Outlet Fitting Thermal Water Inlet Relief Valve Fitting ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 9...
  • Page 10: Engine Controls

    Engine Controls Fuel Cap Air Filter Starter Handle Muffler Oil Drain Plug Choke Fuel Valve Engine Switch Oil Cap/Dipstick Page 10 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 11 Fuel Cup Seal Part Description Main Jet 3000-6000 ft. Mixing Tube Main Jet 6000-8000 ft. (might remain Bolt Seal inside carburetor) Fuel Cup Seal Main Jet Fuel Cup Bolt Seal Bolt ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 11...
  • Page 12: Operation

    10% ethanol (E10). Do not use E85 ethanol. To prevent FIRE, do not start the engine while the smell of fuel hangs in the air. Page 12 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 13: Starting The Engine

    Repeat until the engine starts. Note: Do not let the Starter Handle snap back against the engine. Hold it as it recoils so it doesn't hit the engine. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 13...
  • Page 14 The maintenance break-in period will last about 20 hours of use. • Change the engine oil after this period. Under normal operating conditions subsequent maintenance follows the schedule explained in the MAINTENANCE section. Page 14 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 15: Quick Connect 0

    Lid. The Pressure Washer will draw one gallon of detergent for every seven gallons of water. Only use the Black (low pressure) Nozzle when spraying detergents. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 15...
  • Page 16 7. Store the equipment indoors out of children’s reach. NOTICE Drain fuel at end of season or warranty is void. See Long-Term Storage on page 20 for complete storage instructions. Page 16 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 17: Maintenance

    4. Clean carbon build-up from combustion chamber Replace fuel line if necessary Service more frequently when used in dusty areas. These items should be serviced by a qualified technician. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 17...
  • Page 18 8. Thread the dipstick back in clockwise. NOTICE: Do not run the engine with too little oil. The engine will shut off if too little engine oil is used. Page 18 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 19 If overtightened, the threads in the engine block will be damaged. 6. Apply dielectric spark plug boot protector (not included) to the end of the spark plug and reattach the wire securely. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 19...
  • Page 20 With spark plug cap disconnected and Engine switch in OFF position, pull Starter Handle several times until antifreeze begins to come out of Pump outlet fitting. e. Remove garden hose from Pump. Page 20 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 21: Troubleshooting

    2. Engine mounted on a slope, 2. Bring engine level. Check engine oil. triggering low oil shutdown. Follow all safety precautions whenever diagnosing or servicing the equipment or engine. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 21...
  • Page 22: Counterclockwise

    5. Clean strainer. 6. Nozzle blocked. 6. Clean Nozzle. 7. Dried detergent in injector. 7. Dissolve by running warm water through the injection tube. Run clean water through injector until clear. Page 22 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 23 LICENSED TECHNICIANS, AND NOT BY THE BUYER. THE BUYER ASSUMES ALL RISK AND LIABILITY ARISING OUT OF HIS OR HER REPAIRS TO THE ORIGINAL PRODUCT OR REPLACEMENT PARTS THERETO, OR ARISING OUT OF HIS OR HER INSTALLATION OF REPLACEMENT PARTS THERETO. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 23...
  • Page 24: Parts Lists And Diagrams

    Note: If product has no serial number, record month and year of purchase instead. Note: Some parts are listed and shown for illustration purposes only, and are not available individually as replacement parts. Page 24 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 25: General Assembly Diagram

    General Assembly Diagram ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 25...
  • Page 26: Pump Parts List

    Seal Oil Seal O-Ring Ø14  x   2 Housing When ordering replacement parts from this list, the “A” suffix must be included in order to get the correct part. Page 26 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 27: Pump Assembly Diagram

    Pump Assembly Diagram ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 27...
  • Page 28: Engine Parts List

    112B Governor Support Bolt Recoil Starter Assembly 113B Nut When ordering replacement parts from this list, the “B” suffix must be included in order to get the correct part. Page 28 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 29: Engine Assembly Diagram

    Engine Assembly Diagram ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 29...
  • Page 30: Warranties

    (2) year term of this warranty at no cost to you, including diagnosis, parts and labor. This warranty applies to the original purchaser and any subsequent owner within the two year warranty period. Page 30 For equipment technical questions, please call 1-888-866-5797. ITEM 62214...
  • Page 31 The nearest Harbor Freight Tools retail store can be found on the internet at http://www.harborfreight.com. ITEM 62214 For equipment technical questions, please call 1-888-866-5797. Page 31...
  • Page 32 3491 Mission Oaks Blvd. • PO Box 6009 • Camarillo, CA 93011 • 1-888-866-5797...

Table of Contents