Table of Contents
Advertisement
Owner's Manual & Safety Instructions
Save This Manual
operating, inspection, maintenance and cleaning procedures. Write the product's serial number in the
back of the manual near the assembly diagram (or month and year of purchase if product has no number).
Keep this manual and the receipt in a safe and dry place for future reference.
Using an engine indoors
CAN KILL YOU IN MINUTES.
Engine exhaust contains carbon monoxide.
This is a poison you cannot see or smell.
NEVER use inside
a home or garage,
EVEN IF doors and
windows are open.
Visit our website at: http://www.harborfreight.com
Email our technical support at: productsupport@harborfreight.com
Email our engine support at: predator@harborfreight.com
When unpacking, make sure that the product is intact
and undamaged. If any parts are missing or broken,
please call 1-888-866-5797 as soon as possible.
©
Copyright
2014 by Harbor Freight Tools
No portion of this manual or any artwork contained herein may be reproduced in
any shape or form without the express written consent of Harbor Freight Tools.
Diagrams within this manual may not be drawn proportionally. Due to continuing
improvements, actual product may differ slightly from the product described herein.
Tools required for assembly and service may not be included.
Keep this manual for the safety warnings and precautions, assembly,
Only use OUTSIDE
and far away from
windows, doors,
and vents.
®
. All rights reserved.
Read this material before using this product.
Failure to do so can result in serious injury.
SAVE THIS MANUAL.
REV 15i
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Predator 62201
Summary of Contents for Predator 62201
- Page 1 Visit our website at: http://www.harborfreight.com Email our technical support at: productsupport@harborfreight.com Email our engine support at: predator@harborfreight.com When unpacking, make sure that the product is intact and undamaged. If any parts are missing or broken, please call 1-888-866-5797 as soon as possible.
-
Page 2: Table Of Contents
The emissions control system for this Engine is warranted for standards set by the U.S. Environmental Protection Agency and by the California Air Resources Board (also known as CARB). For warranty information, refer to the last pages of this manual. Page 2 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 3: Safety
It must be understood by the operator that common sense and caution are factors which cannot be built into this product, but must be supplied by the operator. SAVE THESE INSTRUCTIONS ITEM 62201 For technical questions, please call 1-888-866-5797. Page 3... -
Page 4: Set Up Precautions
Do not spray 15. Wear ANSI-approved safety glasses the tool itself or any electrical wiring/receptacle. and hearing protection during use. Page 4 For technical questions, please call 1-888-866-5797. ITEM 62201... - Page 5 If you feel any medical or vibration occurs, stop use immediately. physical symptoms related to vibration (such as tingling, numbness, and white or blue fingers), seek medical advice as soon as possible. ITEM 62201 For technical questions, please call 1-888-866-5797. Page 5...
-
Page 6: Service Precautions
Pressure Washer to remain idle for more than two minutes. If allowed to remain idle, the water in the unit will heat up, possibly causing damage to the Pressure Washer. SAVE THESE INSTRUCTIONS. Page 6 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 7: Setup
3. Attach the Hose Hanger (7) to the Handle with a Knob (4). Frame 4. Attach the two Wand Holders (14) Wand Holder to the Frame using Bolts (20). Bolt Wand Holder Bolt Figure A ITEM 62201 For technical questions, please call 1-888-866-5797. Page 7... - Page 8 Supply minute at 20 PSI. Only use a 5/8" inner diameter Hose (or larger) hose that is rated to meet this capacity. Figure F Page 8 For technical questions, please call 1-888-866-5797. ITEM 62201...
- Page 9 Spray Gun Handle Trigger Handle Spray Gun Trigger Lock Nozzles Wand Pressure Hose Engine Frame Detergent Tank Lid Detergent Tank Pump Pump Outlet Fitting Thermal Relief Valve Water Inlet Fitting ITEM 62201 For technical questions, please call 1-888-866-5797. Page 9...
-
Page 10: Engine Controls
Engine Controls Fuel Cap Starter Handle Oil Cap/Dipstick Muffler Oil Drain Plug Air Filter Choke Engine Switch Page 10 For technical questions, please call 1-888-866-5797. ITEM 62201... - Page 11 High Altitude Kit Parts List - A Carburetor Assembly Part Description Main Jet 7000-8000 ft. Fuel Cup Seal Bolt Seal Fuel Cup Seal Mixing Tube (might remain inside carburetor) Main Jet Fuel Cup Bolt Seal Bolt ITEM 62201 For technical questions, please call 1-888-866-5797. Page 11...
-
Page 12: Operation
10% ethanol (E10). Do not use E85 ethanol. To prevent FIRE, do not start the engine while the smell of fuel hangs in the air. Page 12 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 13: Starting The Engine
Then, if the Choke lever is in the START position, move the Choke Lever very slowly to its RUN position. Note: Moving the Choke Lever too fast could stall the engine. START ITEM 62201 For technical questions, please call 1-888-866-5797. Page 13... - Page 14 Pressure Washer will draw one gallon of detergent for every seven gallons of water. Only use the Black (low pressure) Nozzle when spraying detergents. Page 14 For technical questions, please call 1-888-866-5797. ITEM 62201...
- Page 15 Spray Gun from the Spray Gun Holder as shown in Figure H. 7. Store the equipment indoors out of children’s reach. Figure H NOTICE See “Long-Term Storage” on page 19 for complete storage instructions. ITEM 62201 For technical questions, please call 1-888-866-5797. Page 15...
-
Page 16: Maintenance
4. Clean carbon build-up from combustion chamber Replace fuel line if necessary Service more frequently when used in dusty areas. These items should be serviced by a qualified technician. Page 16 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 17: Counterclockwise
Have the unit serviced by a qualified technician. 10W-30 5W-30 100°F Average outdoor temperature 7. Thread the dipstick back in clockwise. NOTICE: Do not run the engine with too little oil. The engine will be permanently damaged. ITEM 62201 For technical questions, please call 1-888-866-5797. Page 17... - Page 18 If overtightened, the threads in the engine block will be damaged. 6. Apply dielectric spark plug boot protector (not included) to the end of the spark plug and reattach the wire securely. Page 18 For technical questions, please call 1-888-866-5797. ITEM 62201...
- Page 19 Pressure Washer. d. With spark plug cap disconnected and Engine switch in OFF position, pull Starter Handle several times until antifreeze begins to come out of Pump outlet fitting. ITEM 62201 For technical questions, please call 1-888-866-5797. Page 19...
-
Page 20: Troubleshooting
4. Engine valves or tappets mis-adjusted or stuck. 4. Have qualified technician adjust/ repair valves and tappets. Follow all safety precautions whenever diagnosing or servicing the equipment or engine. Page 20 For technical questions, please call 1-888-866-5797. ITEM 62201... - Page 21 7. Dried chemicals in injector. 7. Dissolve by running warm water through the injection tube. Run clean water through injector until clear. Follow all safety precautions whenever diagnosing or servicing the equipment or engine. ITEM 62201 For technical questions, please call 1-888-866-5797. Page 21...
- Page 22 Page 22 For technical questions, please call 1-888-866-5797. ITEM 62201...
- Page 23 Note: If product has no serial number, record month and year of purchase instead. Note: Some parts are listed and shown for illustration purposes only, and are not available individually as replacement parts. ITEM 62201 For technical questions, please call 1-888-866-5797. Page 23...
-
Page 24: Parts Lists And Diagrams
White Nozzle – 4 0° Detergent Tank Lid Black Nozzle – D etergent Detergent Tube Nozzle Grommet Bolt Pump Nozzle Panel Engine Mounting Bolt Handle Knob Engine Frame Flange Nut Wand Holder Bolt Page 24 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 25: General Assembly Diagram
General Assembly Diagram ITEM 62201 For technical questions, please call 1-888-866-5797. Page 25... -
Page 26: Pump Parts List
O-Ring Ø14 x 2 Seal O-Ring Ø4.48 x 1 .78 When ordering replacement parts from this list, the “A” suffix must be included in order to get the correct part. Page 26 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 27: Pump Assembly Diagram
Pump Assembly Diagram ITEM 62201 For technical questions, please call 1-888-866-5797. Page 27... -
Page 28: Engine Parts List
Washer Φ10 x 1 .5 x Φ 16 When ordering replacement parts from this list, the “B” suffix must be included in order to get the correct part. Page 28 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 29: Engine Assembly Diagram
Engine Assembly Diagram ITEM 62201 For technical questions, please call 1-888-866-5797. Page 29... -
Page 30: Warranties
This warranty gives you specific legal rights and you may also have other rights which vary from state to state. Page 30 For technical questions, please call 1-888-866-5797. ITEM 62201... -
Page 31: Your Warranty Rights And Obligations
If you have any questions regarding your warranty rights and present on the outdoor equipment purchased. responsibilities, you should contact the toll free number 1-888-866-5797 or contact predator@harborfreight.com for emission warranty service. The following emission warranty parts are covered (if applicable): Fuel Metering System... - Page 32 3491 Mission Oaks Blvd. • PO Box 6009 • Camarillo, CA 93011 • 1-888-866-5797...
Need help?
Do you have a question about the 62201 and is the answer not in the manual?
Questions and answers