Table of Contents
Advertisement
Model Numbers
HS- 45-KFA / HS-70T-KFA / HS-125T-KFA / HS-175T-KFA / HS-215T-KFA
CONSUMER: READ AND SAVE THESE INSTRUCTIONS
GENERAL HAZARD WARNING:
DANGER
READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL
BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER. Be sure to comply with the
instructions and warnings provided with this heater. Failure to comply can result in fire or explosion
that can cause property loss, bodily injury, or loss of life. Only persons who can follow and
understand these instructions should operate or service this heater. If you need heater info; such as
an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996.
NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES
DANGER
WITHOUT ADEQUATE VENTILATION. TO BE USED IN WELL VENTILATED
COMMERCIAL / INDUSTRIAL OCCUPANCIES. This is an unvented portable heater that uses
air (Oxygen) from within the area in which it is used. Failure to provide adequate combustion and
ventilation air will result in asphyxiation, carbon monoxide poisoning, bodily injury or death. Refer to
"Ventilation" on Page 7.
668 Stony Hill Road #302 Yardley, PA 19067 USA
Fax: (215)-891-8461
User's Manual & Operating Instructions
© 2013 Pinnacle Products International, Inc.
• Web: www.Heat-Stream.com • Email: info@pinnacleint.com
®
Toll Free (800)-641-6996
•
701000355-13
Advertisement
Table of Contents
Related Manuals for Pinnacle Products International HeatStream HS- 45-KFA
Summary of Contents for Pinnacle Products International HeatStream HS- 45-KFA
- Page 1 Only persons who can follow and understand these instructions should operate or service this heater. If you need heater info; such as an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996. NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES DANGER WITHOUT ADEQUATE VENTILATION.
-
Page 2: Table Of Contents
THE INSTALLATION OF THIS HEATER SHALL COMPLY WITH THE REGULATIONS OF THE AUTHORITIES HAVING JURISDICTION. Look for this icon throughout the manual for helpful tips on how to assemble, use and clean your KFA Heater. © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 3: Safety Information
If your heater is equipped with a thermostat, “Ventilation” on page 7 for further instructions. once it is plugged in, it can start at anytime in accordance with the thermostat setting. © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 4: Specifications
Gauge Fuel Cap Storage Drawer Electric Outlet Fuel Ta nk Lamp Side Cover (120V 5amp max Drain Plug Thermostat Knob non fused) Power Cord Power/Reset Switch Figure 2 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 5: Assembly Instructions
Figure 4. 2. Insert screws (13 mm) and tighten firmly. 2. Insert screws (10 mm) and tighten firmly. Tools Needed: - Phillips Head Screw Driver Figure 3 Figure 4 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... - Page 6 Tires (2) Cord Wraps (2) Axle Nuts (2) Spacers (2) Spare Drain Plug (1) Wheel Support Frame Front Handle Rear Handle Axle Missing Parts? Please Call 800-641-6996 For Assistance © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual...
- Page 7 8. Tilt the heater up gently so it is resting on the front handle. NOTE: DO NOT do this if there is fuel in the tank. Figure 7 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual...
-
Page 8: Operation
Kerosene deteriorates over time. OLD KEROSENE WILL NOT BURN Storage Drawer PROPERLY IN THIS HEATER. (125T / 175T / 215T-KFA Only) Electrical Outlet Figure 8 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... - Page 9 “Off” position and unplug the power cord. - To restart the heater; wait 10 seconds and follow ignition steps. Temperature Display Thermostat Knob Power Switch Power Switch Figure 10 Figure 9 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual...
-
Page 10: Maintenance
Air Output Filter Head Flange Seal Cap Intake Filter Figure 12 IMPORTANT: Never store leftover kerosene between Lint Filter End Filter seasons, using old fuel can damage heater. Figure 13 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... - Page 11 125T / 175T / 215T-KFA turn filter 90º counter-clockwise. See Figure 15. Fuel Filter Fuel Line Photocell Wire Side Cover Figure 15 Figure 17 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual...
-
Page 12: Wiring Diagram
9.0 PSI Tolerance ± 10% Pressure Valve Burner Head Figure 19 Adjusting Screw Figure 18 Wiring Diagram Figure 20: 45-KFA Figure 21: 70T-KFA / 125T-KFA / 175T-KFA / 215T-KFA © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 13: Troubleshooting Guide
4. Improper electrical connection supply. between temperature limit sensor 3. Check / replace the fuse. and circuit board. 4. Inspect all electrical connections (see wiring diagrams on page 11). © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 14: Exploded View
WHILE CONNECTED TO A POWER SOURCE ® Exploded View 49** 50** 56** 42** 5 35 53** 52** * HS-45-KFA / HS-70T-KFA Only ** HS-125T-KFA / HS-175T-KFA / HS-215T-KFA Only 54** © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 15: Parts List
Wheel Nut – – 70-041-0550 70-041-0550 70-041-0550 Hardware Kit 70-056-0100 70-056-0100 70-056-0210 70-056-0210 70-056-0210 Cord Wrap 70-032-0100 70-032-0100 70-032-0200 70-032-0200 70-032-0200 Motor Supporter 70-020-0600 70-020-0600 70-020-0610 70-020-0610 70-020-0610 © 2013, Pinnacle Products International, Inc. Kerosene Forced Air Heater User’s Manual... -
Page 16: Limited Warranty
® LIMITED WARRANTY Pinnacle Products International, Inc. warrants this heater If Pinnacle Products International, Inc. finds the item to to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect.