Advertisement
TECHNICAL GUIDE
AFFINITY
MODELS: PC9*UP
GAS-FIRED
CONDENSING / HIGH EFFICIENCY
UPFLOW MODULATING FURNACES
WITH ECM MOTORS
NATURAL GAS
60 - 120 MBH INPUT
EFFICIENCY
RATING
CERTIFIED
Due to continuous product improvement, specifications
are subject to change without notice.
Visit us on the web at www.york.com for the most
up-to-date technical information.
Additional rating information can be found at
www.gamanet.org.
FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE
DESCRIPTION
These Category IV, highly efficient, compact, condensing
type furnaces are designed for residential and commercial
installations in a basement, closet, alcove, recreation room or
garage where the ambient temperature is above 32°F, or
higher. They may be either side wall or thru-roof vented using
approved plastic type combustion air and vent piping. All
units are factory assembled, wired and tested to assure
dependable and economical installation and operation.
WARRANTY
Lifetime limited warranty on both heat exchangers to the orig-
inal purchaser; a 20-year limited warranty from original instal-
lation date to subsequent purchaser.
10-year warranty on the heat exchanger in commercial appli-
cations.
5-year limited parts warranty.
FEATURES
• Modulating heating operation includes:
• Provides increased comfort level & very quiet unit opera-
• Compact, easy to install, ideal height 40" cabinet
• Blower-off delay for cooling SEER improvement.
• Easy to connect power/control wiring.
• Built-in, high level self diagnostics with fault code display.
• Low unit amp requirement for easy replacement applica-
• Integrated control module for reliable, economical opera-
• May be installed as either two-pipe (direct vent) or single
• Top intake & vent connection allows installation in narrow
• Electronic Hot Surface Ignition saves fuel cost with
• Induced combustion system with inshot main burners for
• No special vent termination kit required.
• 100% shut off main gas valve for extra safety.
• ECM high efficiency direct drive motor with large, quiet
• 24V, 40 VA control transformer and blower relay supplied
• Hi-tech tubular aluminized steel primary heat exchanger.
• Secondary (condensing) heat exchanger of 29-4C high-
ISO 9001
Certified Quality
• Solid removable bottom panel allows easy application.
Management System
• Easy access from front of unit for cleaning, maintenance or
• Protection from intake, exhaust or condensate blockage.
• Insulated blower compartment for quiet operation.
- Modulating gas valve
- Modulating inducer operation
tion
tion.
tion.
pipe vent (using indoor combustion air)
locations.
increased dependability and reliability.
quiet, efficient operation.
blower.
for add-on cooling.
grade stainless steel.
service.
246813-YTG-D-0108
Advertisement
Table of Contents
Related Manuals for York PC9B12N060UP11
Summary of Contents for York PC9B12N060UP11
- Page 1 • Protection from intake, exhaust or condensate blockage. Visit us on the web at www.york.com for the most • Insulated blower compartment for quiet operation. up-to-date technical information. Additional rating information can be found at www.gamanet.org.
- Page 2 24-7/16 BOTTOM IMAGE TOP IMAGE RETURN END SUPPLY END DIMENSIONS Cabinet Dimension Nominal Cabinet Models Size A (in.) B (in.) C (in.) D (in.) PC9B12N060UP11 1200 17-1/2 16-1/4 14-1/2 8-1/2 PC9B12N080UP11 1200 17-1/2 16-1/4 8-1/2 PC9C16N080UP11 1600 19-3/4 8-7/8 PC9C16N100UP11...
-
Page 3: Electrical And Performance Data
Max. Blower7 Max/Min Max/Min Size Maximum Input Minimum Input Models Over-current Protect Amps °F °F PC9B12N060UP11 60/21 57/20 11 x 8 40 - 70 20 - 50 PC9B12N080UP11 80/28 76/26 11 x 8 40 - 70 20 - 50 PC9C16N080UP11... - Page 4 246813-YTG-D-0108 For additional connection diagrams for all UPG equipment refer to “Line Voltage System Wiring” document available on-line at www.upgnet.com in the Product Catalog Section. AC 26A Two Stage Air Conditioner – Variable Speed Modulating Furnace ID MODELS FC9C FL9C THERMOSTAT THERMOSTAT VARIABLE SPEED...
-
Page 5: Variable Speed Modulating Furnace
246813-YTG-D-0108 AC 26B Two Stage Air Conditioner – Variable Speed Modulating Furnace ID MODELS FC9C FL9C THERMOSTAT THERMOSTAT VARIABLE SPEED TWO STAGE *DN22C00124 *DP22U70124 MODULATING FURNACE CONDITIONER VARIABLE SPEED MODULATING FURNACE CONTROL 24 – Volt Common 24 – Volt Common 24 –... - Page 6 246813-YTG-D-0108 AC 26C Two Stage Air Conditioner – Variable Speed Modulating Furnace ID MODELS FC9C FL9C THERMOSTAT VARIABLE SPEED TWO STAGE *PP32U71124 MODULATING *PP32U72124 FURNACE CONDITIONER VARIABLE SPEED MODULATING FURNACE CONTROL 24 – Volt Common 24 – Volt Common 24 – Volt Common First Stage Compressor Single Stage Compressor First Stage Compressor...
- Page 7 246813-YTG-D-0108 HP 28A Two Stage Heat Pump – Variable Speed Modulating Furnace (With Hot Heat Pump Operation) ID MODELS OD MODELS FC9C FL9C THERMOSTAT VARIABLE SPEED TWO STAGE *PP32U71124 MODULATING HEAT PUMP *PP32U72124 FURNACE VARIABLE SPEED YORKGUARD VI MODULATING CONTROL FURNACE CONTROL 24 –...
- Page 8 246813-YTG-D-0108 HP 28C Two Stage Heat Pump – Variable Speed Modulating Furnace (With Hot Heat Pump Operation) ID MODELS OD MODELS FC9C FL9C THERMOSTAT THERMOSTAT VARIABLE SPEED *DN22H00124 TWO STAGE *PP32U70124 MODULATING *DP22U70124 HEAT PUMP FURNACE VARIABLE SPEED YORKGUARD VI MODULATING CONTROL FURNACE CONTROL...
-
Page 9: Air Flow Data
246813-YTG-D-0108 AIR FLOW DATA HIGH / LOW SPEED COOLING AND HEAT PUMP CFM PC9B12N060UP11 PC9B12N080UP11 JUMPER SETTINGS High High COOL Tap ADJ Tap 1330 1310 1130 1100 1220 1220 1040 1000 1120 1090 PC9C16N080UP11 PC9C20N100UP11 PC9C16N100UP11 JUMPER SETTINGS High High... -
Page 10: Filter Performance
246813-YTG-D-0108 FILTER PERFORMANCE NOTE: The filter pressure drop values in the “Filter Perfor- mance” table shown are typical values for the type of filter The airflow capacity data published in the “Blower Perfor- listed and should only be used as a guideline. Actual pres- mance”... - Page 11 246813-YTG-D-0108 NOTES Unitary Products Group...
- Page 12 Subject to change without notice. Printed in U.S.A. 246813-YTG-D-0108 Copyright © by Unitary Products Group. 2008. All rights reserved. Supersedes: 246813-YTG-C-0606 Unitary 5005 Norman Products York Group Drive 73069...