Ornamental Trivet Installation; Pedestal Trim Installation (If Supplied); Bricks And Baffle Installation - Napoleon EPA 1150 Installation And Operating Instructions Manual

20
5.3

ORNAMENTAL TRIVET INSTALLATION

Insert the ornamental trivet into the space on the stove top.
5.4

PEDESTAL TRIM INSTALLATION (IF SUPPLIED)

Ensure that the pedestal surfaces are clean and dry; peel the protective backing from the trim adhesive. Insert
one end of the brass trim into one of the slots located in the pedestal and pressing fi rmly, proceed around
to the other slot. Cut trim to size. Attach the rear knockout plate (located inside the ash pan for shipping
purposes).
5.5

BRICKS AND BAFFLE INSTALLATION

OPERATIION OF THE APPLIANCE WITHOUT THE BAFFLES CAN RESULT IN EXCESSIVE
With appliance and chimney installation completed, move the bricks into place for your appliance as
previously illustrated.
A. Install the bottom bricks, working from the back of the appliance forward.
B. Install fi ve (1100 series), six (1400 series)* or eight (1900) bricks along both sides of the appliance.
Before installing the back bricks, loosen the screw holding the brick retainer and ensure that it has
been moved forward. Install the six bricks along the back wall by pivoting the bricks up under the brick
retainer. Retighten the screw. NOTE: Center bricks have been cut.
C. 1900 Only
Place the stainless steel support onto the top row of the bricks as illustrated. Pivot the 2 piece baffl e
up and onto the support, then slide them over and onto the fl ange of the manifold. Ensure that the
overlaps are interlocked to close the gap. Push the baffl es to the rear of the fi rebox. Repeat for the op-
posite side.
D. Carefully pivot fi bre baffl e up onto the top of the side brick. Slide it over onto the fl ange of the manifold
shield. Ensure that the top baffl es are pushed all the way to the rear of the fi rebox, leaving a minimum
of a 1" gap along the front. This will allow the fl ue gases to escape the fi rebox.
E. Install the 4 bricks along the front opening.
* The fi bre baffl es may need to be placed in prior to the side bricks for the 1400 series.
NOTE: Do not operate if baffl e and manifold shield are not in position.
W415-0763 / A / 11.03.10
TEMPERATURES THAT COULD DAMAGE THE APPLIANCE, CHIMNEY AND THE
WARNING
!
SURROUNDING ENCLOSURE.
TRIVET
KNOCKOUT
PLATE
TRIM
PEDESTAL