Table of Contents
Related Manuals for Cornelius ID-90 Series
Summary of Contents for Cornelius ID-90 Series
- Page 1 ® LANDMARK ICE DISPENSERS Installation and Service Manual Release Date: June 15, 2004 Publication Number: 60418002 Revision Date: March 21, 2014 Revision: F Visit the Cornelius web site at www.cornelius.com for all your Literature needs.
-
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than... -
Page 3: Table Of Contents
Troubleshooting Guide ..........5 © 2004-2014, Cornelius Inc. - Page 4 Landmark Ice Dispenser Installation and Service Manual Publication Number: 60418002 - ii - © 2004-2014, Cornelius Inc.
-
Page 5: General Description
Place the ice trap in the drain outlet in the ice bin. This holds ice away from drain outlet and allows water to drain properly. Check connection for leaks. IMPORTANT - SYSTEM MUST BE SANITIZED AS INSTRUCTED PRIOR TO OPERATION. See Cleaning and Sanitizing Instructions. © 2004-2014, Cornelius Inc. - 1 - Publication Number: 60418002... - Page 6 (as you face the front of the unit) or no ice will be dispensed and damage to the dispense wheel mechanism could result. See Figure 1 for proper orientation. FRONT FIGURE 1 Static Bar Location Publication Number: 60418002 - 2 - © 2004-2014, Cornelius Inc.
-
Page 7: Ice Gate Adjustment
Continuous maintenance of this unit is a basic requirement for proper operation and sanitation, including all support equipment utilized in the daily operation of this equipment. © 2004-2014, Cornelius Inc. - 3 - Publication Number: 60418002... -
Page 8: Cleaning Equipment And Supplies
Connect electrical power to dispenser and refill with ice. NOTE: Static Breaker bar in the ice bin must be situated inside the right of the dispense door or no ice will be dispensed. Publication Number: 60418002 - 4 - © 2004-2014, Cornelius Inc. -
Page 9: Troubleshooting Guide
Reposition, see Figure 1. Excessive water spilling from Adjust ice maker to eliminate field installed ice maker spillage. Poorly adjusted field installed Adjust ice maker to eliminate ice maker large waffle shapes. © 2004-2014, Cornelius Inc. - 5 - Publication Number: 60418002... - Page 10 Bridge of ice sheet is too thick Adjust field installed ice maker. Ice clusters in bin Break up clusters. Irregular Sound Shaved ice clusters in bin Remove clusters. FIGURE 3 Wiring Diagram Publication Number: 60418002 - 6 - © 2004-2014, Cornelius Inc.
- Page 11 Landmark Ice Dispenser Installation and Service Manual FIGURE 4 Wiring Diagram - Timed Agitation © 2004-2014, Cornelius Inc. - 7 - Publication Number: 60418002...
- Page 12 Landmark Ice Dispenser Installation and Service Manual Publication Number: 60418002 - 8 - © 2004-2014, Cornelius Inc.
- Page 14 Cornelius Inc. www.cornelius.com...