Electronic Appliance Checkout; Wiring Diagrams; Warranty; Replacement Parts - Lennox Hearth Products EBVCLNE Homeowner's Care And Operation Instructions Manual

Hood
MILLIVOLT
Thermocouple
Pilot
Nozzels
Thermopile
Figure 11

Electronic Appliance Checkout

To light the burner, refer to the lighting instruc-
tions on page 16 and 17 . Ensure the ignitor lights
the pilot. The pilot flame should engulf the flame
sensor as shown in Figure 12 .
ELECTRONIC
Proper Flame
Adjustment
Pilot
Nozzle
Figure 12
With proper care and maintenance, your appli-
ance will provide many years of enjoyment. If you
should experience any problem, first refer to the
trouble shooting guide in this manual. If problem
persists, contact your Lennox distributor.

WIRING DIAGRAMS

Wiring diagrams are provided here for refer-
ence purposes only. This information is also
provided on schematics attached directly to
the appliance on a pullout panel located within
the control compartment.
CAUTION: LABEL ALL WIRES PRIOR TO DIS-
CONNECTION WHEN SERVICING CONTROLS.
WIRING ERRORS CAN CAUSE IMPROPER AND
DANGEROUS APPLIANCE OPERATION.
10
Ignitor Rod
If any of the original wire as supplied must be replaced,
it must be replaced with Type AWM 105 C – 18 GA. wire.
³⁄₈" Min
(9 mm)
*OPTIONAL WALL-MOUNTED ON/OFF
SWITCH OR OPTIONAL THERMOSTAT
OR OPTIONAL REMOTE RECEIVER
*Turn the appliance-mounted ON/OFF burner control
Electronic Wiring Diagram (Honeywell)
1. If any of the original wire as supplied must be replaced,
3/8 To 1/2 Inch
1. it must be replaced with Type AWM 105 C – 18 GA.
(9 mm to 13 mm)
wire.
2. 120V, 60Hz – Less than 3 amps.
*ON/OFF Switch (Integral
with Gas Valve)
Ground
Electrode
BK
Flame Rod
R
Hot Surface
Igniter
WT
APPLIANCE-MOUNTED ON/OFF SWITCH
**Turn the appliance-mounted ON/OFF burner control switch to
the OFF position if an optional control switch is installed.

PRODUCT REFERENCE INFORMATION

We recommend that you record the following important information about your fireplace. Please
contact your Lennox dealer for any questions or concerns. For the number of your nearest Lennox
dealer, please call 800-731-8101
Your Fireplace's Model Number _______________________________________
Your Fireplace's Serial Number ________________________________________
The Date On Which Your Fireplace Was Installed __________________________
The Type of Gas Your Fireplace Uses ___________________________________
Your Dealer's Name _________________________________________________
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
Millivolt Wiring Diagram
White
Thermopile
Black
Field Wired
Factory Wired
APPLIANCE-MOUNTED ON/OFF SWITCH
switch to the OFF position if an optional
control switch is installed.
Schematic Representation Only
*Leave the ON/OFF switch, which is integral
with the gas valve, in the ON position.
Gas Valve
PILOT
ASSEMBLY
Green
BL
White G o r n u
N e t u a r
120 VAC - Black
Black
Junction Box
Tab Intact
Tab
Broken
Red
Optional
Green
Accessory
Hot
Neutral
Ground
Switch
Side of Side of
Screw
Receptacle
Receptacle
W
Transf.
B
120 V.
G
24 V
BL
R
BK
WT
LIMIT SWITCH
**OPTIONAL WALL SWITCH
OR OPTIONAL THERMOSTAT
OR OPTIONAL REMOTE
RECEIVER
Factory Wired Field Wired
Schematic Representation Only

WARRANTY

Your gas appliance is covered by a limited
twenty year warranty. You will find a copy of
the warranty accompanying this manual.
Please read the warranty to be familiar with its
coverage.
Retain this manual. File it with your other docu-
ments for future reference.

REPLACEMENT PARTS

A complete parts list is found at the end of this
manual. Use only parts supplied from the
manufacturer.
Normally, all parts should be ordered through
your Lennox distributor or dealer. Parts will be
shipped at prevailing prices at time of order.
When ordering repair parts, always give the
following information:
1. The model number of the appliance.
2. The serial number of the appliance.
3. The part number.
4. The description of the part.
5. The quantity required.
- d G e r n e
6. The installation date of the appliance.
- l W h e t i
If you encounter any problems or have any
questions concerning the installation or appli-
cation of this system, please contact your dis-
tributor, or Lennox directly:
LENNOX HEARTH PRODUCTS
1110 West Taft Avenue
Orange, CA 92865