Table of Contents
Advertisement
B-VENT GAS
FIREPLACE
HEATER INSERTS
RETAIN THIS MANUAL FOR
FUTURE REFERENCE
Suitable for installation
into masonry or factory
built fi replaces
Report No. 116-F-15-5
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAMAGE,
PERSONAL INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY
Do not store or use gasoline or other fl ammable
vapors or liquids in the vicinity of this or any other
appliance.
WHAT TO DO IF YOU SMELL GAS:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow your gas supplier's
instructions.
• If your gas supplier cannot be reached, call
the fi re department.
Installation and service must be performed by a quali-
fi ed installer, service agency or the gas supplier
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
®
Lennox Elite
Series Models: EBVI25 & EBVI30
P/N 775,155M Rev. D,12/2005
• Hot! Do not touch! The glass and surfaces of this appliance
will be hot during operation and will retain heat for a while
after shutting off the appliance. Severe burns may result.
• Carefully supervise children in the same room as appliance.
• If small children are present in the home, it is recommended
that this appliance be fi tted with a screen door or screen panel
kit. See Page 12 for ordering information.
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE
POUR RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE
OU POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides infl ammables dans
le voisinage de cet appareil ou de tout autre appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifi é
.
installeur, agence de service ou le fournisseur de gaz.
WARNINGS
Advertisement
Table of Contents
Related Manuals for Lennox Hearth Products EBVI25
Summary of Contents for Lennox Hearth Products EBVI25
-
Page 1: Operation Instructions
HOMEOWNER'S CARE AND OPERATION INSTRUCTIONS ® Lennox Elite Series Models: EBVI25 & EBVI30 P/N 775,155M Rev. D,12/2005 WARNINGS • Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will retain heat for a while after shutting off the appliance. -
Page 2: Table Of Contents
Hearth Products to provide you, our valued customer, with an appliance that will ensure years of trouble-free warmth and pleasure. Thank you for selecting a Lennox Hearth Products gas-fi red heater as the answer to your home heating needs. Sincerely,... -
Page 3: Burn-In Period
SCREW KNOB and heat output) TP/TH OUTLET WIRING INLET PRESSURE TERM- PRESSURE INALS Figure 1 MODEL EBVI25 SIT Millivolt Gas Valve Controls GAS CONTROL KNOB CONVERTIBLE OUTLET HI/LO REGULATOR INLET PRESSURE (adjusts fl ame height PRESSURE and heat output) PIEZO... -
Page 4: Control Compartment Access
CONTROL COMPARTMENT ACCESS Pull down hinged door to access control compartment (see Figure 3) Control Compartment Access Pull down hinged door to access control compartment Side View of Insert Pull down lower louver (hinged) Figure 3 Burner Off/on Switch and Rheostat Location If optional surround is installed Units with Beveled Surround Burner Off/On... - Page 5 For Removing Standard Glass Door Assembly on Page 7). Remove log set, burner and grate. Remove blower access panel and gasket (see Figure 5 for model EBVI25 and Figure 6 for model EBVI30). Be careful not to damage the gasket. Model EBVI25...
-
Page 6: Maintenance Schedule
MAINTENANCE Annually (Before the onset of the Burning Season) Maintenance Task Inspecting/Cleaning Burner, Logs and Controls Check Flame Patterns and Flame Height Inspecting/Cleaning Pilot and Burner Checking Vent System Appliance Checkout Replacing Rockwool Ember Materials Periodically (After the Burning Season) Maintenance Task Cleaning Firebox Interior Check Flame Patterns and Flame... -
Page 7: Front Glass Door Assembly, Removal And Installation
Ensure that the front glass panel is in place and sealed during adjustment. NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Burner Flame Appearance EBVI25 Shown IMPORTANT... -
Page 8: Log Placement Instructions
Gas Type Air Shutter Gap EBVI30 Natural Gas 5/16" (7.94mm) Propane 1/2" (12.7mm) EBVI25 Natural Gas 1/16" (1.59mm) Propane 1/2" (12.7mm) Figure 14 Carbon will be produced if the air shutter is closed too much. Any damage due to carboning resulting from improperly setting the air shutter is not covered under the warranty. - Page 9 1. Place the rear log onto the two corresponding locating pins at the back of the fi rebox as shown in Figure 16. Figure 16 Rear Log 2. Place the Front Right Log onto the two corresponding locating pins as shown in Figure 17. Figure 17 3.
- Page 10 Top Right Log Figure 22 8. Place the glowing embers on the burner as shown in Figure 23. One package of ember material has been included with this log set You will not need to use the entire bag. IMPORTANT: The quantity and placement of the ember material can affect insert performance therefore it is very important that it be placed as shown in Figure a.
-
Page 11: Millivolt Appliance Checkout
If you should experience any problem, fi rst refer to the troubleshooting guide in this manual. If problem persists, contact your Lennox Hearth Products Dealer. BLOWER OPERATION When the insert heats up, the blower will auto- matically be turned on by the fan disc located under the fi... -
Page 12: Warranty Information
Use only parts supplied from the manufacturer. All parts should be ordered through your Lennox Hearth Products Distributor or Dealer. Parts will be shipped at prevailing prices at time of order. When ordering repair parts, always give the following information: 1. - Page 13 BLK-30BVI Brick Liner Kit, EBVI30 H1577 BLK-25BVI Brick Liner Kit, EBVI25 Decorative Bay Window Trim Kits These decorative trim accents, install along the top and bottom front edges of the bay window. They are available in two different fi nishes to enhance the beauty of the insert and are sure to fi...
- Page 14 Flat Louver Kit, Charcoal, EBVI25 H1506 FLK-25G Flat Louver Kit, Gold, EBVI25 H1507 FLK-25BS Flat Louver Kit, Br. Stainless, EBVI25 H0846 FLK-30BVI Flat Louver Kit, Charcoal, EBVI30 H0847 FLK-30BVIG Flat Louver Kit, Gold, EBVI30 H0848 FLK-30BVIBS Flat Louver Kit, Br. Stainless, EBVI30...
-
Page 15: Lighting Instructions - Millivolt
LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo igniter. - Page 16 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
-
Page 17: Replacement Parts List
Misc. Gas Components Miscellaneous Parts Log Set Room Air Blower System (H1128) NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Where Used EBVI25 & EBVI30 EBVI25 & EBVI30 EBVI25 & EBVI30 EBVI25 & EBVI30 EBVI25 EBVI30 EBVI25 & EBVI30 EBVI25 EBVI30 EBVI25 &... - Page 18 REPLACEMENT PARTS DIAGRAMS NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
-
Page 19: Troubleshooting Guide
TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM Note: Before troubleshooting the gas control system, be sure external gas shut off valve (located at gas supply inlet) is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualifi ed service technician. SYMPTOM 1) Spark igniter will not light A. - Page 20 Consult your local distributor for insert code information. Printed in U.S.A. © LENNOX HEARTH PRODUCTS 2003 1110 West Taft Avenue • Orange, CA 92865 P/N 775,155M Rev. D 12/2005...