Table Of Contents - Yamaha VK10W Supplementary Service Manual

GENERAL INFORMATION
SPECIAL TOOLS .................................................1
FOR ELECTRICAL SERVICE ........................1
PERIODIC INSPECTION AND
ADJUSTMENT
INTRODUCTION...................................................2
PERIODIC MAINTENANCE CHART....................2
POWER TRAIN.....................................................4
DRIVE V-BELT ...............................................4
BRAKE PAD INSPECTION ............................6
AIR BLEEDING (HYDRAULIC BRAKE
SYSTEM) ........................................................6
DRIVE CHAIN.................................................7
TUNING ..............................................................10
CLUTCH .......................................................10
GEAR SELECTION ......................................11
HIGH ALTITUDE TUNING............................17
POWER TRAIN
SHIFT LEVER.....................................................18
INSTALLATION ............................................20
DRIVE CHAIN HOUSING ...................................21
REMOVAL ....................................................24
INSPECTION ................................................24
INSTALLATION ............................................26
SECONDARY SHAFT ........................................28
SECONDARY SHAFT AND DRIVE CHAIN
HOUSING INSTALLATION...........................28
BRAKE ...............................................................30
BRAKE PAD REPLACEMENT .....................31
BRAKE CALIPER DISASSEMBLY ...............35
BRAKE CALIPER INSTALLATION...............35
FRONT AXLE AND TRACK...............................36
INSTALLATION ............................................36
ENGINE
CAMSHAFTS......................................................37
INSTALLATION ............................................37
CARBURETION
CARBURETORS ............................................... 42
THROTTLE POSITION SENSOR (T.P.S.)
INSPECTION AND ADJUSTMENT ............. 43
ELECTRICAL
SIGNAL SYSTEM .............................................. 45
CIRCUIT DIAGRAM..................................... 45
TROUBLESHOOTING ................................. 46
GEAR POSITION SWITCH.......................... 47
GEAR POSITION SWITCH RELAY............. 47
SPECIFICATIONS
GENERAL SPECIFICATIONS........................... 48
MAINTENANCE SPECIFICATIONS.................. 50
ENGINE ....................................................... 50
POWER TRAIN............................................ 55
CHASSIS ..................................................... 58
ELECTRICAL ............................................... 59
HIGH ALTITUDE SETTINGS....................... 62
TIGHTENING TORQUE..................................... 63
ENGINE ....................................................... 63
POWER TRAIN............................................ 65
CHASSIS ..................................................... 67
GENERAL TORQUE SPECIFICATIONS .......... 68
DEFINITION OF UNITS ..................................... 68
CABLE ROUTING ............................................. 69