Chevrolet Kodiak 2008 Owner's Manual page 343

Rear axle service — Eaton
axles (or every 12 months, whichever occurs
first). (30)
Exhaust brake service, if equipped. Check for
excessive spindle free play and smooth operation.
Lubricate ball joint cap.
Inspect air compressor discharge port (or every
6 months or every 1,800 hours, whichever occurs
first).
Manual transmission (ZF 6-speed only) fluid
replacement (or every 48 months, whichever
occurs first).
Trailer brake hand control valve service (or every
12 months, or every 3,600 hours, whichever
occurs first). (35)
120,000 Miles (192 000 km)
C600, C700, and C800 Gasoline Engines Only:
Replace engine drive belts.
C400 and C500 Gasoline Engines Only: Engine drive
belts service (or every 12 months, whichever occurs
first). (17)
®
DURAMAX Diesel Only: Diesel Particulate Filter
(DPF) service. Then every 100,000 miles
(160 000 km). (7) (38)
® ® ®
, Rockwell , Spicer
150,000 Miles (240 000 km)
Cooling system service (or every 60 months since
last service, whichever occurs first). (2) (29)
Diesel Engine Only: Inspect engine drive belt;
replace as necessary.
Isuzu Diesel Only: Diesel Particulate Filter (DPF)
service (or every 4,500 hours, whichever occurs
first). Then every 150,000 miles (240 000 km),
or every 4,500 hours, whichever occurs first. (7)
200,000 Miles (320 000 km)
Rear axle service — Eaton
axles (or every 12 months, whichever occurs
first). (30)
Remove, disassemble, clean, and inspect the air
brake trailer supply valve (or every 2 years, or
every 7,200 hours, whichever occurs first).
Diesel Engine Only: Inspect engine drive belt;
replace as necessary.
250,000 Miles (400 000 km)
Four-wheel drive only: Front axle service. (30)
Four-wheel drive only: Transfer case service. (30)
Manual transmission (except ZF 6-speed) fluid
replacement (or every 60 months, whichever
occurs first).
® ® ®
, Rockwell , Spicer
6-19