PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. VSX-D511-K...
Dolby Laboratorories. "DTS" ,“ES” and "DTS Digital Surround" are trademarks of Digital Theater Systems, Inc. Accessories AM loop antenna FM wire antenna AA size IEC R6P Remote control unit (ATB7009) (ADH7005) Dry cell batteries (x2) (XXD3039) VSX-D511-K...
Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING /MYXJIEW Type VSX-D511-K...
Page 7
See Contrast table(2) Operating instructions See Contrast table(2) Operating instructions See Contrast table(2) Remote Control Unit XXD3039 (2) CONTRAST TABLE VSX-D511-K/MVXJI, /MYXJIEW, /MYXJIGR and VSX-D511-S/MYXJIEW are constructed the same except for the following : VSX-D511-K/ VSX-D511-S/ VSX-D511-K/ VSX-D511-K/ Mark Symbol and Description...
2.2 EXTERIOR SECTION 39(1/2) 39(2/2) Accessory of Front Panel NON-CONTACT SIDE CONTACT SIDE Refer to "2.3 FRONT PANEL SECTION". VSX-D511-K...
Page 9
XEC3031 KAWA CN5005 - FM/AM TUNER CN201 Screw See Contrast table(2) 19P F•F•C/30V (J35) XDD3101 (2) CONTRAST TABLE VSX-D511-K/MVXJI, /MYXJIEW, /MYXJIGR and VSX-D511-S/MYXJIEW are constructed the same except for the following : VSX-D511-K/ VSX-D511-S/ VSX-D511-K/ VSX-D511-K/ Mark Symbol and Description...
Page 11
See Contrast table(2) Pioneer Badge See Contrast table(2) C Ring DIA8.1 XBH3016 Led Lens 1.6 XAK3308 (2) CONTRAST TABLE VSX-D511-K/MVXJI, /MYXJIEW, /MYXJIGR and VSX-D511-S/MYXJIEW are constructed the same except for the following : VSX-D511-K/ VSX-D511-S/ VSX-D511-K/ VSX-D511-K/ Mark Symbol and Description...
Page 25
AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491010 FOR IC604, IC605, IC606, AND IC607 MFD, BY LITTELFUSE INC. • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS ONLY. VSX-D511-K...
3.8 AMP & PRIM.(2/2), REG., HASHIGETA, B TO B and MECH SW ASSYS HASHIGETA ASSY CN351 (XWZ3566) BOARD TO BOARD ASSY (XWZ3527) CN301 AMP& PRIMARY ASSY (XWZ3533) REGULATOR ASSY (XWZ3544) CN302 E F G VSX-D511-K...
Page 27
ASSY (XWZ3552) REK1026 (T2.5A) LIVE NEUTRAL AC POWER CORD VDG1076 : /MVXJI VDG1077 : /MYXJI • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - H I Y REPLACE WITH SAME TYPE AND RATINGS ONLY. VSX-D511-K...
3.10 FRONT, R.ENCODER and POWER SW ASSYS R.ENCODER ASSY S511 : ENTER S512 : MULTI JOG DIAL S513 : MASTER VOLUME R.ENCODER ASSY (XWZ3511) CN5001 FRONT ASSY (XWZ3493) CN102 VSX-D511-K...
Page 31
S458 : DIRECT S459 : EON MODE S460 : PTY SEARCH S461 : MPX S462 : BAND S463 : STANDARD S464 : TUNING(+) S465 : TUNING(–) S466 : STATION(+) S467 : STATION(–) S468 : MULTI JOG S476 : CLASS VSX-D511-K...
Page 35
: The power supply is shown with the marked box. (TX) : AUDIO SIGNAL ROUTE (TUNER) (AM) : AM SIGNAL ROUTE (FM) : FM SIGNAL ROUTE (AM) (TX) (FM) (TX) (TX) (TX) (FM) (FM) (TX) (AM) L201 ATE7003 VSX-D511-K...
Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B Chip Part P.C.Board transistor Resistor array 3-terminal regulator VSX-D511-K...
4.1 TRANS1, TRANS2 and TRANS3 ASSYS SIDE A SIDE A TRANS3 ASSY J6 J4 J8 J5 (XNP3053-C) POWER TRANSFORMER ATTENTION TRANS2 ASSY REMPLACER LE IC LINKS COMME INDIQUE. DE CHEZ LITTELFUSE INC. (XNP3053-C) TRANS1 ASSY (XNP3053-C) C D I VSX-D511-K...
Page 39
Q9611 Q9601 Q9602 IC9101 IC9507 IC9501 IC9504 IC9201 Q9201 Q9202 IC9812 Q9203 Q9204 IC104 CN802 Note : The pin of function IC(IC101 TC9273F-007)can be checked from side-A by the through-hole round. The pin No. is printed on the side-A. VSX-D511-K...
IC602 IC602 R613 R613 R613 D633 D633 D633 R607 R607 R607 IC602 IC602 IC602 IC601 IC601 IC601 W502 W502 W502 R601 R601 R601 IC603 IC603 IC603 W501 W501 W501 W507 W507 W507 W505 W505 W505 B B H Y VSX-D511-K...
Page 43
REMPLACER LE IC LINKS REMPLACER LE IC LINKS CN53 CN53 CN53 DE CHEZ LITTELFUSE INC. DE CHEZ LITTELFUSE INC. DE CHEZ LITTELFUSE INC. CN801 CN801 CN801 D722 D722 D722 CN53 CN53 CN53 W509 W509 W509 D724 D724 D724 KN601 KN601 KN601 VSX-D511-K...
W248 S466 S465 S464 S467 S463 S457 S458 W224 W223 W222 S462 S468 S461 S460 S459 S476 CN702 H.P ASSY 1551 CMKI-P3X 1551 R1552 (XNP3052-C) HP R KN1551 POWER SW ASSY HP L R1551 JA1551 (XNP3052-C) O Q U VSX-D511-K...
Page 45
4 T_GND 3 FM COMP 2 STEREO 1 TUNED 1 AC RY 2 TONE 3 FENC A 4 FENC B 5 GND S512 6 ENC B 7 ENC A (XNP3052-C) CMKS-P3X S511 W289 S513 R.ENCODER ASSY KNIFE SPACE (XNP3052-C) VSX-D511-K...
Page 46
2 STEREO R476 1 TUNED R411 1 AC RY 2 TONE 3 FENC A 4 FENC B R458 5 GND 6 ENC B 7 ENC A R459 Q401 Q441 Q442 IC401 CMKS-P3X R512 R.ENCODER XWZ3511 XWZ3512 XWZ3582 R.ENCODER ASSY (XNP3052-C) VSX-D511-K...
Page 47
Q405 Q403 Q481 Q482 IC481 Q483 Q471 H.P ASSY POWER SW. R501 1551 CMKI-P3X XWZ3510 STBY CMKI-P3X XWZ3513 R1556 (XNP3052-C) Q1551 POWER SW ASSY C1552 HPSW uGND uGND R1555 Q1552 C1557 HP GND C1556 C1558 (XNP3052-C) O Q U VSX-D511-K...
Page 49
PLL DO T MUTE STEREO TUNED +10V FM COMP Q5001 CN303 A MUTE A MUTE SR OUT SR OUT 4053A 4053A PLL CE 4053INH SYS DT 4053INH SYS CK PLL DO T MUTE STEREO TUNED +10V FM COMP (XNP3052-C) (XNP3052-C) VSX-D511-K...
4.7 FM/AM TUNER MODULE SIDE B SIDE A FM/AM TUNER MODULE CN201 CN5005 (ANP7338-B) Q202 FM/AM TUNER MODULE SIDE B CN201 (ANP7338-B) Q201 IC201 Q203 Q205 IC202 Q204 VSX-D511-K...
POWER SW Assy R. ENCODER Assy H.P. Assy AMP INPUT Assy TRANS 3 Assy D.D & INPUT Assy TRANS 1 Assy KAWA Assy TRANS 2 Assy VIDEO Assy AMP&PRIMARY Assy FM/AM TUNER Unit 6CH IN Assy REGULATOR Assy DIGITAL IN Assy VSX-D511-K...
When detected overload, A.MUTE* is on and speaker relay is off, then flash "OVERLOAD" on display. ↓ An unusual state continues for 3 seconds. ↓ continuation ↓ return A power supply is shut off even if it A power supply is shut off. returns. VSX-D511-K...
Page 65
Strobe for E-volume (TC9459) of SB 9459_ST MVRATT ATT control of master volume for E-volume (less than -15dB : L) SYS_DT Data signal for communication with M62446, TC9163, TC9164 and PLL SYS_CK Clock signal for communication with M62446, TC9163, TC9164 and PLL VSX-D511-K...
Page 72
Lch Negative Analog Output Pin AOUTL+ Lch Positive Analog Output Pin Ground Pin Power Supply Pin DZFR Rch Data Zero Input Detect Pin DZFL Lch Data Zero Input Det ect Pin Note: All input pins should not be left floating. VSX-D511-K...
Neo:6 • Grid Assignment DIGITAL MONITOR SIGNAL AUTO SB DIRECT RF ATT PRO LOGIC ∏ Re-EQ TUNED DIGITAL MIDNIGHT STEREO DIGITAL MPEG LOUDNESS MONO ADV.SURR. SP £ AB Neo:6 ANALOG DTS MPEG • Segment Designation (9G to 2G) (1G) VSX-D511-K...
Page 74
6) Field of vision is a minimum of 21.8° from the lower side. • Anode Connection RFATT AUTO √ DIGITAL TUNED ANALOG DIGITAL (L) MPEG MPEG DIGITAL (R) PROLOGIC ∏ Neo:6 ADV.SURR. Re-EQ DIRECT MIDNIGHT LOUDNESS MONITOR STEREO MONO VSX-D511-K...
Switches between AM and FM radio bands. MULTI JOG/INPUT SELECTOR dial. 21 QUICK SETUP 12 MPX 22 MASTER VOLUME Press the MPX button to receive a radio broadcast in mono. When the headphones are connected, there is no sound output from the speakers. VSX-D511-K...
Page 76
Advanced surround, and Dolby 16 Speaker indicator Surround effects. Shows if the speaker system is on or not. SP 3A means speakers are switched on. SP 3 means the head MIDNIGHT phones are connected. Lights during Midnight listening. VSX-D511-K...
Use to switch between the various surround modes. These buttons are also used to control DVD menus/options. STEREO/DIRECT Switches direct playback on or off. Direct playback bypasses the tone controls and channel levels for the most accurate reproduction of a source. VSX-D511-K...
Use to add or subtract the amount of effect in different sound modes or advanced listening modes. 15 DVD CONTROL buttons You can use these buttons to control a Pioneer DVD player connected to your system. Rear Panel DIGITAL IN...